NIGHTSTICk XPP-5564GX-RX Angle Light XPP Instruction Manual

NIGHTSTICk XPP-5564GX-RX Angle Light XPP

Specifications:

• Brand: Bayco Products, Inc.

• Model: XPP-5564GX/RX

• Address: 640 S. Sanden Blvd., Wylie, TX 75098

• Patent: US PATENT 9,713,217

• For use in hazardous locations

• Power Source: 4 AA Energizer Type EN91, E91, Panasonic LR6XWA,
  or Duracell MN1500 batteries

• Electrical Safety: Intrinsically safe, Class I Div 1 Grps A-D T4

• Operating Voltage: 1.5V/Cell Alkaline

Product Usage Instructions

Powering the XPP-5564 :
The XPP-5564 is powered by 4 AA Energizer EN91, Energizer E91, Panasonic LR6XWA, or Duracell MN1500 batteries. Only approved batteries should be used to maintain the Intrinsically Safe rating.

• Do not use any other type or brand of AA battery with this light.
• Do not use rechargeable AA batteries with this light.

Operation :

Lighting Modes:

• Flashlight Modes – Switch 1:
• High – Full press and release
• Low – Second full press and release
• Off – Third full press and release
• Floodlight Modes – Switch 2:
• High – Full press and release
• Low – Second full press and release
• Off – Third full press and release

Dual-Light Mode:
Both the flashlight and floodlight can be turned on at the same time. Pressing either switch will turn both lights off.

Battery Status Indicator:
The light on the top of the bezel indicates battery status:

• Green – Normal operation
• Red – Low power, battery capacity at or below 30%

Warranty Information:

Limited Lifetime Warranty:
Bayco Products, Inc. offers a limited lifetime warranty covering defects in workmanship and materials for the original purchaser’s lifetime. For full warranty details, visit www.baycoproducts.com/nightstick- productsupport/warranties.

Note: Retain your receipt for proof of purchase.

Frequently Asked Questions (FAQ):

• Q: Can I use rechargeable AA batteries with this flashlight?
  A: No, only use AA Energizer Type EN91, E91, Panasonic LR6XWA, or Duracell MN1500 batteries to maintain the Intrinsically Safe rating of the flashlight.

• Q: How can I tell when it’s time to replace the batteries?
  A: The battery status indicator light on the top of the bezel will turn red when the battery capacity is at or below 30%.

Instruction Manual
INTRANT® DUO XPP-5564
US PATENT 9,713,217

Bayco Products, Inc. XPP-5564GX/RX
640 S. Sanden Blvd., Wylie, TX 75098

Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS For use with Bayco 5564-CARRIER with 4 AA Energizer Type EN91, E91, Panasonic LR6XWA or Duracell MN1500 batteries only

• ID 5012927
• ELECTRICAL SAFETY
• INTRINSICALLY SAFE
• SECURITE INTRINSEQIUE
• CLASS I DIV I GRPS A-D T4
• CLASS 11 & Ill DIVI GRPS E-G T1350C
• CLASS I ZONE O AEx ia IIC T4 Ga
• ZONE 20 AEx ia IIIC T1350C Da
• Oil I G Ex ia IIC T4 Ga
• Oil I D Ex ia IIIC T1350C Da
• Ex ia Ilc T4 Ga
• Ex ia IIIC T1350C Da
• IECEx: IECEx ETL 23.0048X
• ATEX: ITS 124ATEX39286X
• -200C Tamb +400C
• I .5 ≤ ceII  ≤ Alkaline

Bayco Products, Inc. XPP-5564GXA/RXA 640 S. Sanden Blvd., Wylie, TX 75098

Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS For use with Bayco 5564-CARRIER with 4 AA Energizer Type EN91, E91, Panasonic LR6XWA or Duracell MN1500 batteries only

• ID 5012927
• ELECTRICAL SAFETY
• INTRINSICALLY SAFE
• SECURITE INTRINSEQIUE
• CLASS I DIV I GRPS A-D T4
• CLASS 11 & Ill DIVI GRPS E-G T1350C
• CLASS I ZONE O AEx ia IIC T4 Ga
• ZONE 20 AEx ia IIIC T1350C Da
• Oil I G Ex ia IIC T4 Ga
• Oil I D Ex ia IIIC T1350C Da
• Ex ia Ilc T4 Ga
• Ex ia IIIC T1350C Da
• IECEx: IECEx ETL 23.0048X
• ATEX: ITS 124ATEX39286X
• -200C Tamb +400C
• I .5 ≤ ceII  ≤ Alkaline

WARNINGS – INTRINSICALLY SAFE

• WARNING: To prevent ignition of a hazardous atmosphere, do not open any part or attempt to exchange any of the supplied battery packs while in the hazardous environment. This task must ONLY be performed in an area known to be non-hazardous.
• WARNING: The XPP-5564 is only approved for use with 4 AA Energizer EN91, Energizer E91, Panasonic LR6XWA or Duracell MN1500 batteries.
• WARNING: To prevent ignition of a hazardous atmosphere, non-rechargeable AA batteries must only be changed in an area known to be non-hazardous.
• WARNING: To reduce the risk of explosion, do not mix new non-rechargeable batteries with used non-rechargeable batteries, or mix non-rechargeable batteries from different manufacturers.
•  WARNING: Substitution of components may impair intrinsic safety.

SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY

• For personal safety, always confirm the rating of any known hazardous or potentially hazardous location where the Angle Light is to be used.
• Only devices directly connected to apparatus complying with the IEC 60950 series are allowed.

POWERING THE XPP-5564
The XPP-5564 Intrinsically Safe Light is powered by 4 – AA Energizer EN91, Energizer E91, Panasonic LR6XWA, or Duracell MN1500 batteries. To maintain the Intrinsically Safe rating use only approved batteries with the XPP-5564.

• Do not use any other type or brand of AA battery with this light.
• Do not use rechargeable AA batteries with this light.

INSTALLING THE BATTERIES

WARNING: To prevent ignition of a hazardous atmosphere, do not open the battery compartment in the hazardous environment. This task must ONLY be done in an area known to be non-hazardous.

1. Loosen the screw on the battery compartment door on the base of the light
   Do not try to remove door screw. It is captured to prevent loss.

2. Place the batteries into the light per the diagram located on the inside of the battery door. Do not over-tighten the battery compartment door screw.

OPERATION

• LIGHTING MODE S: Flashlight Modes – Switch 1
  • High – Full press and release
  • Low – Second full press and release Off – Third full press and release
• Floodlight Modes – Switch 2
  • High – Full press and release
  • Low – Second full press and release
  • Off – Third full press and release
• Dual-Light Mode
  • Both the flashlight and floodlight can be turned on at the same time. Pressing either switch will turn both lights off.
• Battery Status Indicator
  • The light located on top of the bezel indicates when it is time to replace the batteries:
  • Green – Normal operation
  • Red – Low power, battery capacity at or below 30%

WARRANTY

LIMITED LIFETIME WARRANTY
Bayco Products, Inc. warrants this product to be free from defects in workmanship and materials for the original purchaser’s lifetime. The Limited Lifetime Warranty includes the LEDs, housing and lenses. Rechargeable batteries, chargers, switches, electronics and included accessories are warranted for a period of two years with proof of purchase. Normal wear and failures which are caused by accidents, misuse, abuse, faulty installation and lightning damage are excluded.

We will repair or replace this product should we determine it to be defective. This is the only warranty, expressed or implied, including any warranty of merchantability or fitness for a particular purpose.
For a complete copy of the warranty, go to www.baycoproducts.com/nightstick- product-support/warranties. Retain your receipt for proof of purchase.
Mode D’emploi
INTRANT® DUO XPP-5564

Bayco Products, Inc. • 640 South Sanden Blvd. • Wylie, TX 75098 • 1-800-233-2155 • 1-469-326-9400 • www.nightstick.com INS-XPP-5564-LG-24

Declaration of Conformity

Model(s):| XPP-5564GX / XPP-5564RX

XPP-5564GXA / XPP-5564RXA

| Declaration Number:| 20240307-A
---|---|---|---
Product Type:| Flashlight
Company Name:| Bayco Products Inc.
---|---
Address:| 640 S. Sanden Blvd.
City, State, Postcode:| Wylie, Texas 75098 USA
Phone / Website:| 001-469-326-9400 / www.nightstick.com

We hereby declare that the product identified above meets the requirements of the Directives listed below. Therefore, they qualify for free movement within markets comprising the European Union (EU), the European Economic Area (EEA) and the United  Kingdom (UK). This declaration is issued under the sole responsibility of the manufacturer.

The following EU harmonized, UK designated standards and technical specifications have been applied and evaluated by:

Via Guido Miglioli, 2/A

20063 Cernusco sul Naviglio (MI) Italy

Notified Body Number:| 2575
Certificate Number:| ITSI24ATEX39286X
Standards:| EN 60079-0:2018
---|---
EN 60079-11:2012
EN 50303: 2000
Type Approval:|
---|---

These Products are fully compliant and do not contain the restricted substances above levels noted in EU and UK RoHS.

Name : Mark Situ
Title : Director, Global Quality
Date : 7th March 2024

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>