NIGHTSTICK XPR-5562GX Safe Low-Profile Dual-Light Rechargeable Headlamp Instruction Manual

: June 5, 2024
: NIGHTSTICK

Table of Contents

WARNINGS – INTRINSICALLY SAFE
SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY
INSTALL THE BATTERY
CHARGING THE LIGHT
OPERATION
WARRANTY
References
Read User Manual Online (PDF format)
Download This Manual (PDF format)

Instruction Manual
DICATA® XPR-5562GX
US PATENT 9,713,217

THE XPR-5562 IS APPROVED FOR USE

Bayco Products, Inc. XPR-5562GX
640 S. Sanden Blvd., Wylie, TX 75098
Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS UL listed for use with Bayco Li-ion Battery Pack 5562-BATT

E 467756
ID 4003544
INTRINSICALLY SAFE
SECURITE INTRINSEQUE| CLASS I DIV 1 GRPS A-D T4
CLASS II & III DIV 1 GRPS E-G T135ºC
CLASS I ZONE 0 AEx ia op is IIC T4 Ga
II 1 G Ex ia op is IIC T4 Ga| Ex ia op is IIC T4 Ga
DEMKO 20 ATEX 2267
IECEx UL 20.0036
-20ºC ≤ Tamb ≤ +40ºC
3.7V/Cell 5562-BATT
Um 4.2V
---|---|---

WARNING: Do not charge the battery in a hazardous location
WARNING: Do not replace the battery when an explosive atmosphere is present

WARNINGS – INTRINSICALLY SAFE

Warning: To prevent ignition of a hazardous atmosphere, the XPR-5562 must only be charged in an area known to be non-hazardous.
Warning: Use only the approved Nightstick 5562-BATT Lithium-ion rechargeable battery pack.
Warning: The approved Nightstick 5562-BATT Lithium-ion rechargeable battery pack must be replaced by a qualified technician only.
Warning: To prevent ignition of a hazardous atmosphere, do not open the battery compartment or attempt to exchange the battery pack while in the hazardous environment. This task must ONLY be performed in an area known to be non-hazardous.
Warning: Open the battery compartment on the XPR-5562 and replace the approved Nightstick 5562-BATT Lithium-ion rechargeable battery pack in fresh air only.
Warning: Substitution of components may impair intrinsic safety.

SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY

For personal safety, always confirm the rating of any known hazardous or potentially hazardous location where the light is to be used.

INSTALL THE BATTERY

Loosen the locking screw on the underside of the battery compartment before removing the tail cap.
Reinstall the locking screw after placing the battery to maintain the intrinsic safety certification.

CHARGING THE LIGHT

CHARGER INPUT: 5 VDC Max
WARNING: TO PREVENT IGNITION OF A HAZARDOUS ATMOSPHERE, DO NOT ATTEMPT TO CHARGE THIS PRODUCT IN A HAZARDOUS ENVIRONMENT. THIS TASK MUST ONLY BE PERFORMED IN AN AREA KNOWN TO BE NON-HAZARDOUS.
Use only the supplied Nightstick rechargeable battery and Magmate™ cable. Fully charge the light before the first use, or if the battery is new or has been unused for several months. For best performance, charge the light when the fl ashlight beam starts to dim.

Connect the Magmate cable to a power source with a USB connector. Attach the magnetic end to the charging port located on the light.
The USB end of the cable includes an LED charge status indicator. The LED indicator remains red until the battery is fully charged. At full charge, the LED indicator turns green.
The total time to fully charge the light varies depending on the remaining charge in the battery.

OPERATION

Two switches on the front of the headlamp control all functions.
SPOTLIGHT SWITCH

First Press = spotlight high-brightness
Second Press = spotlight low-brightness
Third Press = off

FLOODLIGHT SWITCH

First Press = fl Goodlight high-brightness
Second Press = fl Goodlight low-brightness
Third Press = off

DUAL-LIGHT MODE

Press each switch one time to turn on both lights in high-brightness mode.
To shut down Dual-Light mode, press each switch two more times until each light turns off.

WARRANTY

LIMITED LIFETIME WARRANTY

Bayco Products, Inc. warrants this product to be free from defects in workmanship and materials for the original purchaser’s lifetime. The Limited Lifetime Warranty includes LEDs, housing, and lenses. Rechargeable batteries, chargers, switches, electronics, and included accessories are warranted for a period of two years with proof of purchase. Normal wear and failures which are caused by accidents, misuse, abuse, faulty installation, and lightning damage are excluded.
We will repair or replace this product should we determine it to be defective. This is the only warranty, expressed or implied, including any warranty of merchantability or fitness for a particular purpose.
For a complete copy of the warranty, go to www.baycoproducts.com/bayco- productsupport/warranties. Retain your receipt for proof of purchase.

EU Declaration of Conformity

Model(s): X	XPR-5562GX	Declaration Number	20200527-B
Product Type:	Headlight
Company Name:	Bayco Products Inc.
---	---
Address:	640 S. Sanden Blvd.
City, State, Postcode:	Wylie, Texas 75098 USA
Phone / Website:	001-469-326-9400 /

www.nightstick.com

We hereby declare that the product identified above meets the requirements of the Directives listed below. Therefore, they qualify for free movement within markets comprising the European Union (EU), and the European Economic Area (EEA). This declaration is issued under the sole responsibility of the manufacturer.
The following EU harmonized, designated standards and technical specifications have been applied and evaluated by: