NIGHTSTICK XPP-5462 DICATA Safe Low-Profile Dual-Light LED Headlamp, 310 Lumens Instruction Manual

Instruction Manual
XPP-5462GX/RX DICATA® US PATENT 9,713,217

THE XPP-5462 IS APPROVED FOR USE

INTRINSICALLY SAFE SECURITE INTRINSEQUE

| Bayco Products, Inc. XPP-5462
Wylie, TX 75098
Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS
CLASS I DIV 1 GRPS A-D T4
CLASS II & III DIV 1 GRPS E-G
CLASS I ZONE 0 GRP IIC T4
CLASS II ZONE 20 IIIC T135ºC
II 1 G Ex ia IIC T4 Ga|

XPP-5462
ID 4003544
Ex ia IIC T4 Ga
DEMKO 16 ATEX 1814X
IECEx UL 16.0167X
-20ºC ≤ Tamb ≤ +40ºC
1.5V/Cell / E91 or EN91

---|---|---

WARNINGS:
Replace batteries in a non-hazardous location.
Use only Energizer AA Model E91 or EN91 batteries.

SPECIAL CONDITIONS OF USE

The Nightstick XPP-5462 contains an accessible metal part with a measured capacitance of 9.9pF. Care must be taken to avoid ignition hazards due to potential electrostatic charging hazards.

WARNINGS – INTRINSICALLY SAFE

• Warning: Use only the approved non-rechargeable batteries listed below.

• Warning: Do NOT attempt to use rechargeable AA batteries with this light.

• Warning: To prevent ignition of a hazardous atmosphere, do not open the battery compartment in the hazardous environment. This task must ONLY be performed in an
  area known to be non-hazardous.

• Warning: When exchanging batteries, use only ENERGIZER E91 or EN91 BATTERIES.

• Warning: To prevent ignition of a hazardous atmosphere, the AA batteries must only be exchanged in an area known to be non-hazardous.

• Warning: To reduce the risk of explosion, do not mix new non-rechargeable batteries with used non-rechargeable batteries or mix non-rechargeable batteries from different manufacturers.

• Warning: Substitution of components may impair intrinsic safety.

SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY

For personal safety, always confirm the rating of any known hazardous or potentially hazardous location where the light is to be used.

BATTERY INSTALLATION

WARNING: In order to maintain the XPP-5462’s Intrinsically Safe rating, the only AA batteries certified for use with this light are the ENERGIZER E91 or EN91 BATTERIES.

• Do not attempt to use any other brand or model of AA batteries with this light.

• Do not attempt to use any type of rechargeable AA batteries with this light.
  Warning: To prevent ignition of a hazardous atmosphere, do not open the battery compartment door in the hazardous environment. This task must ONLY be done in
  an area known to be non-hazardous.

• Loosen the locking screw located on the back of the battery compartment door.
  NOTE: Do NOT attempt to completely remove the locking screw. Doing so is not necessary and may damage the threads. The screw simply needs to be loosened enough to allow the battery compartment door to open.

• Using 3 – AA ENERGIZER E91 or EN91 BATTERIES (make sure that all 3 batteries are of the same model), install the batteries in the back of the light paying close
  attention to the markings inside the battery compartment for proper battery terminal polarity alignment.

• Close the battery compartment door.

• Tighten locking screw. CAUTION: Do NOT over-tighten. Doing so may damage the threads and impact the light’s Intrinsic Safety.

OPERATION

Two switches on the front of the headlamp control all functions.
SPOTLIGHT SWITCH

• First Press = spotlight high-brightness
• Second Press = spotlight low-brightness
• Third Press = off

FLOODLIGHT SWITCH

• First Press = floodlight high-brightness
• Second Press = floodlight low-brightness
• Third Press = off

DUAL-LIGHT MODE

• Press each switch one time to turn on both lights in high-brightness mode.
• To shut down Dual-Light mode, press each switch two more times until each light turns off.

WARRANTY

LIMITED LIFETIME WARRANTY
Bayco Products, Inc. warrants this product to be free from defects in workmanship and materials for the original purchaser’s lifetime. The Limited Lifetime Warranty includes LEDs, housing, and lenses. Rechargeable batteries, chargers, switches, electronics, and included accessories are warranted for a period of two years with proof of purchase. Normal wear and failures which are caused by accidents, misuse, abuse, faulty installation, and lightning damage are excluded.
We will repair or replace this product should we determine it to be defective. This is the only warranty, expressed or implied, including any warranty of merchantability or fitness for a particular purpose.
For a complete copy of the warranty, go to www.baycoproducts.com/bayco- productsupport/warranties. Retain your receipt for proof of purchase.

EU Declaration of Conformity

Model(s): X| XPP-5462GX
XPP-5462RX| Declaration Number:| 20170220-G
---|---|---|---
Product Type:| Flashlight
Company Name:| Bayco Products Inc.
---|---
Address:| 640 S. Sanden Blvd.
City, State, Postcode:| Wylie, Texas 75098 USA
Phone / Website:| 001-469-326-9400 / www.nightstick.com

We hereby declare that the product identified above meets the requirements of the following EU Directives and therefore qualifies for free movement within markets comprising the European Union (EU) and the European Economic Area (EEA). This declaration is issued under the sole responsibility of the manufacturer.
ATEX Directive 2014/34/EU
The following harmonized standards and technical specifications have been applied and evaluated by:

EN 60079-11:2012 (is)
Type Approval:|
---|---

These Products are fully compliant and do not contain the restricted substances above levels noted in EU RoHS.

Bayco Products, Inc.
640 South Sanden Blvd.
Wylie, TX 75098
USA
1-800-233-2155 
1-469-326-9400 
www.nightstick.com
INS-XPP-5462-DL-21
09-01-2021

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>