HAMRON 008041 ATV Trailer Instruction Manual

HAMRON 008041 ATV Trailer Instruction

SAFETY INSTRUCTIONS

WARNING! Warnings and instructions in these operating instructions do not cover all of the possible situations that may arise. Users must employ common sense and due caution.

• Do not use the product to transport persons, either sitting or standing.
• Children must not play, stand or climb on the product.
• Check the product for wear and damage before use.
• Check the tyre pressure before use.
• Do not climb up on the product when it is moving.
• Do not go under a raised flatbed. Risk of personal injury through crushing.
• Immediately repair or replace damaged parts.
• Check, and if necessary re-tighten or secure assembled parts before use.
• Do not exceed the maximum permitted load.
• Avoid driving over ditches and over large holes in the road or terrain when transporting loads.
• Be careful when driving and manoeuvring on steep slopes – risk of tipping over.
• Always maintain a low speed when driving on steep slopes, in terrain, or on other rough surfaces.
• Do not drive or manoeuvre near public roads, ditches, or streams, etc.
• Never exceed 30 km/h -risk of personal injury and/or material damage
• Be careful when loading and unloading.
• Only use recommended towing vehicles (garden tractors and ATVs).
• Always check before use that the trailer is coupled correctly to, and locked in the towing vehicle.
• Never drive with the flatbed in raised position.
• Do not overfill the trailer. Material that falls out over the dropsides can cause the trailer or towing vehicle wheels to lose traction and skid.
• Do not overfill the flatbed if the load is to be tipped. Large and heavy loads can be difficult to handle and tip.
• Check that there is free space over the flatbed when tipping.
• Close the dropsides when transporting the trailer.
• The flatbed must be empty when disconnecting the trailer from the vehicle.
• Do not use the trailer for any other purpose than the one it is intended to be used for.
• Make sure that the weight of the towing vehicle and the driver is always greater than the weight of the trailer and load, for good driving characteristics.
• Do not use the trailer on public roads.
• Be careful on sharp corners -the tyres on the towing vehicle can rub against the trailer.
• Always reduce speed before cornering with the trailer.
• Be careful and pay attention when reversing. As far as possible reverse straight back- if you need to turn when reversing there is a risk of the trailer knocking into the towing vehicle.
• Use wheel chocks to stop the trailer rolling away when it is not connected to a vehicle.
• If any of the nuts need replacing, replace them with the same type of nyloc-nuts.

TECHNICAL DATA

• Load ca pa city Max 500 kg
• Max speed 30 km/h
• Tyre size 22×11-8/22×10-1o/22×12-8
• Weight, empty 100 kg

DESCRIPTION

1. Tailgate
2.  Flatbed
3. Wheel axle
4.  Wheel
5. Towbar
6. Ball coupling
7. Front dropside

ASSEMBLY

1. Place the trailer bottom up.
2. Secure the wheels on the wheel axles.
3. Pump the tyres up to the correct pressure.
4. Fasten the towbar with two nuts and bolts.
5. Fasten the tip lock with the cotter.
6. Turn over the trailer.
7. Fit the front and back dropsides.

MAINTENANCE

CLEANING

• Clear any debris from the flatbed after use.
• Wash and dry the trailer after use.
• Check the wheel axle and wheel bearings at regular intervals, and lubricate if necessary.
• Check all bolted joints regularly, and retighten if necessary.
• Clean and lightly lubricate all moving parts once a year.

STORAGE

• Do not leave any loads in the flatbed for long periods.
• Make sure that the trailer is clean and dry before putting into storage, this increases its lifespan and reliability.
• Store the trailer indoors, or otherwise protected in the winter and in bad weather.
• When storing outdoors, raise the towbar end a little higher than the back of the flatbed to ensure good run-off.

NOTE:

• Incorrect maintenance and/or incorrect storage will invalidate the warranty.
• Only use spare parts recommended by the manufacturer. The use of other spare parts can cause malfunctioning, damage to property and/or personal injury.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>