NIGHTSTICK XPP-5452G Depends Light Instruction Manual
- June 15, 2024
- NIGHTSTICK
Table of Contents
Instruction Manual
XPP-5452G
XPP-5452G Depends Light
THE XPP-5452G IS APPROVED FOR USE
XPP-5452G
Bayco Products, Inc.
640 S. Sanden Blvd.
Wylie, TX 75098
ID 4003544
INTRINSICALLY SAFE
SECURITE INTRINSEQUE|
---|---
CLASS I DIV 1 GRPS A-D T4
CLASS II & III GRPS E-G T135C
CLASS I ZONE 0 AEx ia IIC T4 Ga
CLASS I ZONE 0 Ex ia IIC T4 Ga
II 1 G Ex ia op is IIC T4 Ga| Ex ia op is IIC T4 Ga
Intertek ITS 13 ATEX27854X
ITS21UKEX0247X
IECEx ITS 17.0002X
-20ºC ≤ Tamb ≤ +40ºC
1.5V/Cell AAA Alkaline
WARNINGS – INTRINSICALLY SAFE
- Warning: Use only the approved non-rechargeable batteries listed below.
- Warning: Do NOT attempt to use rechargeable AAA batteries with this light.
- Warning: To prevent ignition of a hazardous atmosphere, do not open the battery compartment in the hazardous environment. This task must ONLY be performed in an area known to be non-hazardous.
- Warning: When exchanging batteries, use only ENERGIZER E92 or EN92 BATTERIES.
- Warning: To prevent ignition of a hazardous atmosphere, the AAA batteries must only be exchanged in an area known to be non-hazardous.
- Warning: To reduce the risk of explosion, do not mix new non-rechargeable batteries with used non-rechargeable batteries, or mix non-rechargeable batteries from different manufacturers.
- Warning: Substitution of components may impair intrinsic safety.
SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY
For personal safety, always confirm the rating of any known hazardous or
potentially hazardous location where the light is to be used.
BATTERY INSTALLATION
WARNING: In order to maintain the XPP-5452G’s Intrinsically Safe rating, the only AAAbatteries certified for use with this light are the ENERGIZER E92 or EN92 BATTERIES.
-
Do not attempt to use any other brand or model of AAA batteries with this light.
-
Do not attempt to use any type of rechargeable AAA batteries with this light.
Warning: To prevent ignition of a hazardous atmosphere, do not open the battery compartment door in the hazardous environment. This task must ONLY be done in an area known to be non-hazardous. -
Loosen the locking screw located on the back of the battery compartment door.
NOTE: Do NOT attempt to completely remove the locking screw. Doing so is not necessary andmay damage the threads. The screw simply needs to be loosened enough to allow thebattery compartment door to open. -
Using 3 – AAA ENERGIZER E92 or EN92 BATTERIES (make sure that all 3 batteries are of the same model), install the batteries in the back of the light paying close attention to the markings inside the battery compartment for proper battery terminal polarity alignment.
-
Close the battery compartment door.
-
Tighten locking screw.
CAUTION: Do NOT over-tighten. Doing so may damage the threads and impact the light’s Intrinsic Safety.
OPERATION
THE XPP-5452G HAS TWO SEPARATE LIGHTING MODES:
HIGH-BRIGHTNESS SPOTLIGHT MODE
Press the button on top of the light one time.
LOW-BRIGHTNESS SPOTLIGHT MODE
Press the button on top of the light two times. Pressing the button a third
time will turn the light off.
THE XPP-5452G HAS A TILT ADJUSTMENT FEATURE:
Simply adjust the tilt angle of the light to illuminate the desired area.
THE XPP-5452G COMES WITH TWO DIFFERENT HEADBANDS:
ELASTIC NON-SLIP HEADBAND
Use this headband for wearing the headlamp directly on your head or while
wearing a soft hat such as a ball cap. The non-slip feature will keep the
light positioned on the head even during vigorous movement.
HEAVY-DUTY RUBBER HEADBAND
Use the heavy-duty rubber headband on any hardhat. The tacky nature of the
strap will keep the light attached even if the hat is dropped or used in wet
conditions.
WARRANTY
LIMITED LIFETIME WARRANTY
Bayco Products, Inc. warrants this product to be free from defects in
workmanship and materials for the original purchaser’s lifetime. The Limited
Lifetime Warranty includes the LEDs, housing and lenses. Rechargeable
batteries, chargers, switches, electronics and included accessories are
warranted for a period of two years with proof of purchase. Normal wear and
failures which are caused by accidents, misuse, abuse, faulty installation and
lightning damage are excluded.
We will repair or replace this product should we determine it to be defective.
This is the only warranty, expressed or implied, including any warranty of
merchantability or fitness for a particular purpose.
For a complete copy of the warranty, go to www.baycoproducts.com/bayco-
productsupport/warranties. Retain your receipt for proof of purchase.
EU / UK Declaration of Conformity
Model(s):| XPP-5450G
XPP-5452G| Declaration Number:| 20140516-G
---|---|---|---
Product Type:| Portable LED Intrinsically Safe Headlamp
Company Name:| Bayco Products Inc.
---|---
Address:| 640 S. Sanden Blvd.
City, State, Postcode:| Wylie, Texas 75098 USA
Phone / Website:| 001-469-326-9400 /
www.nightstick.com
We hereby declare that the product identified above meets the requirements of
the Diectives listed below. Therefore, they qualify for free movement within
markets comprising the European Union (EU), the European Economic Area (EEA)
and the United Kingdom (UK). This declaration is issued under the sole
responsibility of the manufacturer.
The following EU harmonized, UK designated standards and technical
specifications have been applied and evaluated by:
Directives:| ATEX Directive 2014/34/EU| UKSI 2016 No. 1107| Article 34 of the
Industrial
Safety and Health Act
and Article 58-4,
Paragraph 4 of the
Enforcement Rule of the same Act.
---|---|---|---
Notified Body:| INTERTEK ITALIA SPA
Via Guido Miglioli, 2/A
20063 Cernusco sul
Naviglio (MI)
Italy| INTERTEK TESTING & CERTIFICATION LTD
Academy Place, 1-9 Brook
Street
Brentwood, Essex, CM14 5NQ United Kingdom| Korea Occupational
Safety and Health
Agency
Notified Body Number:| 2575| 359| N/A
Certificate Number:| ITS13ATEX27854X| UKEX: ITS21UKEX0247X| 22-AV4BO-0216X
22-AV4BO-0217X
Standards:| EN 60079-0: 2018
EN 60079-11: 2012 (ia)
EN 60079-28: 2015
Type Approval:| ll 1G Ex ia op is llIC T4 Ga
-20°C s Ta s 40°C
These Products are fully compliant and do not contain the restricted
substances above levels noted in EU and UK RoHS.
Name: Mark Situ
Title: Quality Director
Date: 5th August 2022
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>