Adexa CP-105IR Electric Adjustable Conveyor Oven User Manual
- October 30, 2023
- Adexa
Table of Contents
Adexa CP-105IR Electric Adjustable Conveyor Oven User Manual
Adjust the speed of conveyor to control the color of toasting bread. The feed ramp can lead bread on to the conveyor. The toast crumb tray collect crumb easily. The front and rear discharge can be changed to use. To ensure proper operation, please read this manual carefully before using. After reading, keep this manual in a convenient place for further reference.
Technical Parameter
| Model | CP-105IR | CP-140IR |
|---|---|---|
| Voltage(V) | 220-240 | 220-240 |
| Power(W) | 2600 | 3600 |
| Frequency(Hz) | 50/60 | 50/60 |
| Dimension(mm) | 1029x447x495 | 1029x522x495 |
| Conveyor belt width | 10 ½” | 14” |
Electricity installation
- Make sure the supplied voltage is coordinated with the using voltage.
- The power wire should be connected the special socket which lead through the special air switch and the electric leakage protector. Make sure the ground wire connection is connected well. For convenient operation, ban to pile up the sundry goods near the switch.
Operation
This conveyor oven has been designed to continuously produce toasted bread or
buns. The desired toasted colour of the product can be adjusted by changing
the belt speed of the conveyor and the individual heat controls for the top
and bottom elements. Depending on installation position the toasted product
can be discharged to the front or rear of the unit.
Before operating this unit thoroughly clean as described in the cleaning
section of this leaflet.
As detailed in the diagrams below the unit can either be assembled with front
or rear discharge depending on installation position and preference.
The unit has three controls.
- Speed or colour control determines the length of time the toast or product is in the heating chamber. Obviously, the slower the speed the longer the exposure the darker the product.
- The top and bottom heater elements have individual heat control switches which have 7 settings:
a. “1” – Position is the lowest temperature setting
b. “1 – 7” – the heat will vary from low to high where “1” is the lowest
setting and 7 is the highest setting
When using the machine select switch positions according to requirements and allow approximately 5 minutes for operating temperature to be attained. As described above product appearance or colour is dependent on conveyor speed, heat settings and product. Please note that a number of factors can affect the toasting colour.
- Moisture content of the product
- Sugar content of the product
- Initial product temperature
Generally for best results use day old bread stored at room temperature.
Turn on the main switch the conveyor will now run. Set the temperature to approx. 400F which equates to 5.7 on the scale. Any high-quality edible oil can be used with this conveyor oven. It is preferable to use oil specifically suited for use in toasters/ovens. The pilot cycle cycles with the heating element and indicates when the heater is on. It is preferable to wait until the unit has reached operating temperature and the light has cycled on and off twice. Try to toast two pieces of bread to see whether the color is good or not, and adjust the speed of the chain net. If want the color deepen, turn the color controller to right to go over “3” position. (Notice: the more graduation and lower chain net speed, the color of the bread will deepen. As the visa.) After adjusting the speed of the chain net, put the bread into the chain net follow the tray. The bread will go with the chain net into the inside of the unit and toasting in the inside of the unit.
After finished working, turn the main switch to “OFF” position and pull the
plug out.
If the wire was damaged, replace it by the manufacturer or service agent and
the qualified person only, in order to avoid dangerous.
Clean and maintenance
Note: THE UNIT MUST BE DISCONNECTED FROM THE POWER SOURCE AND ALLOWED TO COOL DOWN BEFORE CLEANING TAKES PLACE
After finished a day’s work, pull out the tray and clean it. Use the soft wet
towel that has not corrosive clean preparation to cleaning the unit. Do not
wash the unit with water jets.
To prevent the unit to be polluted and effect the unit’s function, do not use
the unit to toast the food that content too much sugar in the surface or the
food will flow and stick after heating.
Daily checking
Check the appliance before and after use. Before using, make sure the
appliance dose not lean. Be certain that the power cord is not worn out or
broken. When in use, make sure no unpleasant smell is present and there is no
any unusual noise.
This manual must be read and understood by all persons using or installing this appliance. Contact your local dealer if you have any questions concerning installation, operation or maintenance of this equipment.
IMPORTANT: DO NOT DISCARD THIS MANUAL
This manual is considered to be part of the appliance and is to be given to the owner or manager of the hotel or restaurant, or to the person responsible for training operators of this appliance. It should be retained for future reference. Additional manuals are available from your local dealer.
EC Declaration of Conformity
Adexa Direct Limited declares that:
- Equipment Type: Electric conveyor oven
- Model: CP-105IR, CP140IR
- Imported By: ADEXA DIRECT LIMITED GROUND FLOOR UNIT 1 214 PURLEY WAY CROYDON CR0 4XG LONDON, UNITD KINGDOM Brand: ADEXA
- Application of Council Directive(s): EMC 2014/30/EU LVD 2014/35/EU
- Standards:
- EN 55014-1:2017+A11:2020
- EN IEC 61000-3-2:2019
- EN IEC 61000-3-3:2013+A1:2019
- EN 55014-2:2015
- EN 60335-1:2012+A11:2014+A13:2017+A1:2019+A2:2019+A14:2019
- EN 60335-2-48:2003+A1:2008+A11:2012+A2:2019
- EN 62233:2008
I, the undersigned, hereby declare that the equipment specified above conforms to the above Directive(s) and Standard(s).
Date: 16.8.2022
Signature:
Full Name: Hakan Baykal
Position: Purchase Manager
Declaration of Conformity
Adexa Direct Limited declares that:
- Equipment Type: Electric conveyor oven
- Model: CP-105IR, CP140IR
- Imported By: ADEXA DIRECT LIMITED GROUND FLOOR UNIT 1 214 PURLEY WAY CROYDON CR0 4XG LONDON, UNITED KINGDOM
- Brand: ADEXA
- Application of Council Directive(s): Electromagnetic Compatibility Regulations 2016 and Electrical
- Standards:
- BS EN 55014‐1:2017+A11:2020
- BS EN IEC 61000‐3‐2:2019
- BS EN IEC 61000‐3‐3:2013+A1:2019
- BS EN 55014‐2: 2015
- BS EN 60335‐1:2012+A11:2014+A13:2017+A1:2019+A2:2019+A14:2019
- BS EN 60335‐2‐48:2003+A1:2008+A11:2012+A2:2019
- BS EN 62233:2008
I, the undersigned, hereby declare that the equipment specified above conforms to the above Directive(s) and Standard(s).
Date: 25.10.2022
Signature:
Full Name: Hakan Baykal
Position: Purchase Manager
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>