Caterlite HE152 Electric Airpot Instruction Manual

HE152 Electric Airpot
Instruction Manual

Electric Airpot
Instruction manual

Safety Instructions

• Position on a flat, stable surface.

• A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components on this product.

• Consult Local and National Standards to comply with the following:
  – Health and Safety at Work Legislation
  – BS EN Codes of Practice
  – Fire Precautions
  – IEE Wiring Regulations
  – Building Regulations

• DO NOT overfill the appliance.

• DO NOT allow the appliance to boil dry.

• DO NOT drink directly from the spout.

• DO NOT tilt or overturn the Airpot.

• DO NOT touch hot surfaces with bare hands. Always use the handle.

• DO NOT cover the steam vent.

• DO NOT carry the appliance when full.

• DO NOT dispense liquid when holding the appliance by the handle.

• Use extreme caution when operating appliances that contain hot liquids.

• Do not use the appliance for anything other than its intended use.

• Not suitable for outdoor use.

• Do not fill the inner pot with anything other than water.

• Keep all packaging away from children. Dispose of the packaging in accordance to the regulations of local authorities.

• If the power cord is damaged, it must be replaced by a Caterlite agent or a recommended qualified technician in order to avoid a hazard.

• Caterlite recommend that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity and Functional Testing.

• This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Cleaning and user maintenance shall not be made by children unless they are older than 8 and supervised. Keep the appliance and its cord out of reach of children aged less than 8 years.

• Children shall not play with the appliance.

• This appliance is intended to be used in household and similar applications such as:
  – staff kitchen areas in shops, offices and other working environments;
  – farm houses; – by clients in hotels, motels and other residential type environments;
  – bed and breakfast type environments.

• Caterlite recommend that this product is connected to a circuit protected by an appropriate RCD (Residual Current Device).

Introduction

Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your Caterlite product.

Pack Contents

The following is included:

• Craterlike Airport – 2.8Ltr
• Instruction manual

Craterlike prides itself on quality and service, ensuring that at the time of packaging the contents are supplied fully functional and free of damage.
Should you find any damage as a result of transit, please contact your Caterlite dealer immediately.

Operation

1. Lift the latch to open the lid.

2. Fill the appliance with liquid. Do not fill above the “MAX” line.

3. Close the lid, ensuring it locks firmly in place.

4. Plug in the power cord and connect it to the mains power supply.

5. The Boiling indicator lights up and the appliance begins to heat.
   Note: The appliance will take approximately 20 minutes to heat up when filled with cold water.

6. Once the correct temperature has been reached, the Keep Warm indicator lights up and the appliance is ready to dispense.
   Warning: There is a danger of scalding when opening the lid during and after use. Take care to avoid the expulsion of steam.

Dispense Liquid
There are 2 methods of dispensing liquid:

1. Hold a suitable receptacle beneath the spout.
2. Push the Water Dispense button to dispense the liquid, or Unlock the Pump button and push down repeatedly to pump out the liquid.

Reboil
It may be necessary to reheat the water in the appliance. Press the Reboil button to reboil the water.
Lock/Unlock the Pump Button

• Slide the lock to the CLOSED position to lock the pump button ( **** position).
• Slide the lock to the OPEN position to unlock the pump button ( ****position).

Cleaning, Care & Maintenance

Always disconnect the appliance from the power supply and let it cool down before cleaning and maintenance.

• Use soapy water and a damp cloth to clean the exterior of the appliance.
• Dry thoroughly after cleaning.
•  NEVER immerse the appliance in water.

Removable lid

• For easier cleaning, the lid can be removed by pressing the lid release tap at the back. Relocate the lid afterwards.

De-scaling
For the best water quality, Caterlite recommend that a water filter is installed to the mains water supply, particularly in hard water areas. Doing so will reduce the build up of limescale and contaminants in the water tank thus maintaining energy efficiency and prolonging the life of the appliance.
To de-scale the appliance:

• Fill the inner pot with water and lemon juice (or a suitable de-scaler), and boil.
• Discard the solution.

Note: Always run water through the appliance after descaling to rinse the inner pot and tubes.
Note: Use a suitable de-scaler and always follow the instructions on the packaging.
Caterlite recommend that this appliance is de-scaled every 3 months or more frequently in hard water areas.
IMPORTANT: Failure to de-scale or maintain will invalidate your guarantee.

Troubleshooting

plugged in correctly and switched on
Plug or lead is damaged| Call Caterlite agent or qualified technician
Fuse in the plug has blown| Replace the plug fuse
Power supply| Check power supply
Steam leaks from the silicon seal| Seal worn| Call Caterlite agent or qualified technician
No water is pumped out| Seal deformed or lost pliancy| Call Caterlite agent or qualified technician
When the water just gets boiled, there is too much
steam accumulated inside the pot| Once temperature has been reached, please allow several seconds for the pressures to equalise prior to activating the pump
Unit stops working suddenly, “Empty” indicator on| No water inside so boil dry protection is activated| Allow to cool thoroughly before re-filling

Technical Specifications

Model| Voltage| Power| Current| Capacity| Dimensions h x w x d (mm)| Weight (kg)
---|---|---|---|---|---|---
HE152| 220-290W, 50/6011z| 750W| 3.2A| 2.8Ltr| 205 x 205 x 295| 2.

Electrical Wiring

This appliance is supplied with a 3 pin BS1363 plug and lead.
The plug is to be connected to a suitable mains socket.
This appliance is wired as follows:

• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E

This appliance must be earthed. ****
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required they must be readily accessible.

Compliance

The WEEE logo on this product or its documentation indicates that the product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area.
Caterlite parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities. **** Caterlite products have been approved to carry the following symbol:

All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of Caterlite.
**** Every effort is made to ensure all details are correct at the time of going to press, however, Caterlite reserves the right to change specifications without notice.

DECLARATION OF CONFORMITY

Application of Territory Legislation & Council Directives(s)
Low Voltage Directive (LVD) – 2014/35/EU
Electrical Equipment (Safety) Regulations 2016
EN 60335-1:2012 +A11:2014 +A13:2017 +A1:2019 +A14:2019 +A2:2019
EN 60335-2-15:2016 +A11:2018
EN 62233:2008
Electro-Magnetic Compatibility (EMC) Directive 2014/30/EU – recast of 2004/108/EC
Electromagnetic Compatibility Regulations 2016 (S.I. 2016/1091)
EN 55014-1: 2017 +A11:2020
EN 55014-2:2015
EN IEC 61000-3-2:2019
EN 61000-3-3: 2013 +A1:2019
Ecodesign energy-related products Directive 2009/125/EC
Regulation (EC) 1275/2008 – Standby and off mode power consumption
Restriction of Hazardous Substances Directive (RoHS) 2015/863 amending Annex II to
Directive 2011/65/EU
Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic
Equipment Regulations 2012 (S.I. 2012/3032)
Producer Name……..
Caterlite…..
11th October 2021
Equipment Type…….
Model …………….
Date……………………..
Signature………………………
Full Name…………………….
Position…………………….
Producer Address …………………

|
---|---
Ashley Hooper| Eoghan Donnellan
Technical & Quality Manager| Commercial Manager/ Importer
Fourth Way,
Avonmouth,
Bristol,
BS11 8TB
United Kingdom| 42 North Point Business Park
New Mallow Road
Cork
Ireland

UK +44 (0)845 146 2887

Documents / Resources

| Caterlite HE152 Electric Airpot [pdf] Instruction Manual
HE152, Electric Airpot, Airpot
---|---

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>