Caterlite BW002 Hand Mixer Instruction Manual

Caterlite BW002 Hand Mixer

Safety Instructions

• A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components on this product.

• Consult Local and National Standards to comply with the following:- Health and Safety at Work Legislation

  • BS EN Codes of Practice
  • Fire Precautions
  • IEE Wiring Regulations
  • Building Regulations

• NEVER leave the appliance unattended when in use.

• Do not attempt to defeat the interlock mechanism.

• The use of accessory attachments not recommended or sold by Caterlite may cause fire, electric shock, or injury, which will invalidate your guarantee.

• DO NOT remove food from the appliance until the mixing attachments have come to a complete stop.

• Avoid contacting moving parts. Keep hands, hair, clothing and utensils away from mixing attachment and container while operation to prevent the possibility of severe injury to persons and/or damage to the appliance.
  DO NOT operate the unit if damaged.

• DO NOT use jet/pressure washers to clean the appliance.

• DO NOT attempt to mix items that this machine is not designed for. This can damage the mixing attachments.

• Always switch off and disconnect the power supply to the appliance when not in use, before cleaning and before putting on or taking off parts.

• Not suitable for outdoor use.

• Keep all packaging away from children. Dispose of the packaging in accordance to the regulations of local authorities.

• If the power cord is damaged, it must be replaced by a Caterlite agent or a recommended qualified technician in order
  to avoid a hazard.

• This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety.

• Children should be supervised to ensure that they do not play with the appliance.

• DO NOT let cord hang over edge of table or counter, or touch hot surfaces.

• Caterlite recommend that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Insulation Continuity and Functional Testing.

• Caterlite recommend that this product is connected to a circuit protected by an appropriate RCD (Residual Current Device).

Introduction

Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your Caterlite product. This appliance is intended for domestic or semi-commercial use only. Do not use for professional purposes, or your guarantee will be invalidated and any liability caused will be refused.

Pack Contents

The following is included:

• Caterlite hand mixer
• Dough hooks
• Beaters
• Instruction manual

Caterlite prides itself on quality and service, ensuring that at the time of packaging the contents are supplied fully functional and free of damage.Should you find any damage as a result of transit, please contact your Caterlite dealer immediately.

Operation

1. Disconnect mixer from power supply and set the speed selector to “0”.

2. Clean the beaters and dough hooks. Let them dry well, then mount into the mixer head.
   Note: Both beaters can be inserted in either opening, as they are identical. For the 2 dough hooks, make sure to insert the one with washer in the large opening and the other in the small opening.Otherwise, they cannot lock in place.

3. Lower the beaters or dough hooks into the foodstuff to be mixed. Then connect the appliance to the
   power supply.

  * Slow mixing for combining and aerating dry ingredients without splattering,
  * Add ingredients to cookie doughs or cake batters
  * Fold creams or egg whites into batters
  * Stir sauces and gravies
  * Mix muffin or pancake batters
  * Add dry ingredients to doughs or batters

| Refrigerated ingredients like butter and eggs should be set out in advance, until reaches room temperature before mixing.

It is suggested to start with lower speed then increase gradually as necessary

Do not over beat. Only mix/blend mixtures as recommended in your recipe

3 to 4|

  * Mix cake mixes
  * Add eggs to doughs or batters
  * Add dry ingredients with liquid ingredients
  * Cream softened butter and sugar
  * Whip potatoes or squash
  * Whip cream
  * Beat whole eggs or yolks
  * Mix thin batters  

5 to 6|

  * Add sugar to whipped egg whites for meringues
  * Beat egg yolks until thick and light
  * Whip egg whites
  * Stir the dough (speed setting 6 is recommended)Set the speed selector to desired setting (1 to 6). The table below is for reference only.  

Caution:

1. Do not let the mixer run continuously for more than 5 minutes to avoid overheating. Ensure to let the mixer rest for at least 20 minutes between consecutive cycles.
2.  During mixing, never let the beaters or dough hooks face towards people or objects. Risk of damage or injury!
3. Never add ingredients into the container during mixing.

4. During operation, you can also press the “TURBO” button to mix with the highest speed. In turbo mode, do not let the motor run for more than 1 minute.
5. After mixing, turn off the mixer by setting the speed selector to “0”, then disconnect from power supply and let cool completely.
6. To remove the beaters or dough hooks, hold them with one hand and press the Eject button with the other hand.

Removing the lodged food

If a piece of food gets lodged onto the attachments, please follow the instructions below:

1. Turn off mixer, disconnect from power supply and let it come to a complete stop.
2. Press the Eject button to release the attachments.
3. Use a rubber/wooden spatula to carefully remove the food lodged.

Cleaning, Care & Maintenance

• Always turn off the mixer and disconnect from power supply before cleaning.
• Never put the mixer body in water or let the body, cord or plug get wet.
• Use warm soapy water to clean the mixing attachments. Do not use abrasive cleaning chemicals as these can leave harmful residues. The mixing attachments are dishwasher safe.
• Clean the exterior of the appliance with a slightly damp cloth.
• Dry all parts thoroughly after cleaning.

Troubleshooting

If your Caterlite appliance develops a fault, please check the following table before making a call to the Helpline or your Caterlite dealer.

plugged in correctly and switched on
Plug or lead is damaged| Call Caterlite agent or qualified Technician
Fuse in the plug has blown| Replace the fuse
Power supply| Check power supply
Mixer slows down| Too many contents in the mixing container, and unit runs at speed setting 1 for too long time| Turn off the mixer and remove some of the contents. Adjust the food formula if needed
Wrong mixing attachment used| Select suitable  attachment
Loud noise| Mixing attachments not correctly fitted| Remove and refit attachments
Mixing attachments deforms| Call Caterlite agent or qualified Technician

Technical Specifications

Model| Voltage| Power| Current| Dimensions

H x W x D mm

| Weight (kg)
---|---|---|---|---|---
BW002| 220-240V~50Hz| 400W| 3A| 150 x 190 x 84| 0.92kg

Electrical Wiring

This appliance is supplied with a 3 pin BS1363 plug and lead.The plug is to be connected to a suitable mains socket. This appliance is wired as follows:

• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N

If in doubt consult a qualified electrician. Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required they must be readily accessible.

Compliance

The WEEE logo on this product or its documentation indicates that the product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area.
Caterlite parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities.
Caterlite products have been approved to carry the following symbol:

DECLARATION OF CONFORMITY

Application of Territory Legislation & Council Directives(s)

| Low Voltage Directive (LVD) – 2014/35/EU E l ectrical Equipment (Safety) Regulations 2016

EN 60335-1:2012 +A11:2014 +A13:2017 +A1:2019 +A14:2019 +A2:2019

EN 60335-2-14:2006 +A1:2008 +A11:2012 +A12:2016

EN 62233:2008

Electro-Magnetic Compatibility (EMC) Directive 2014/30/EU – recast of 2004/108/EC E l ectromagnetic Compatibility Regulations 2016 (S.I. 2016/1091)

EN 55014-1:2017 +A11:2020

EN 55014-2:2015

EN IEC 61000-3-2:2019

EN 61000-3-3:2013 +A1:2019

Regulation (EC) 1275/2008 – Standby and off mode power consumption

Restriction of Hazardous Substances Directive (RoHS) 2015/863 amending Annex II to

Directive 2011/65/EU

Restriction of the Use of Certain Hazardous Substances in Electrical and Electronic

E quipment Regulations 2012 (S.I. 2012/3032)

Producer Name| C aterlite

I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s) and Standard(s).

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>