FALCON RIDGE JD-550S4-TC01 John Deere Gator XUV 560 S4 Crew Top Instruction Manual

2515 Bypass Rd. Flemingsburg, KY 41041
606-845-7439
Instructions for Installation and Care of
John Deere 550 S4 Top Cap Canopy
JD-550S4-TC01

JD-550S4-TC01 John Deere Gator XUV 560 S4 Crew Top

Notice: Do not smoke inside the cab or expose the enclosure to direct flames. The cab is Flammable.

1. Be sure to read these instructions thoroughly before opening and installing the John
   Deere 550 S4 Top Cap. The installation is best done when the temperature is 70 degrees
   F. or warmer. The temperature affects the adhesive Velcro, if conditions prevent installing in warmer weather it helps to store the adhesive Velcro at room temp prior to
   installation.

2. Carefully open the carton and remove the rolled Top Cap on a large flat surface that is clean and free of dirt.

3. Check over the parts included in the carton with the parts list shown below:
   Adhesive Velcro Hook
   Webbing Strap with Velcro
   Webbing Strap with Grommet
   Double-Sided Velcro with Snap
   Top Cap| 7 each
   6 each
   2 each
   2 each
   1 each
   ---|---

Place the Top Cap over the roll cage of the Gator.

4. You have been supplied with two types of straps, with grommet holes and with double-sided Velcro sewn to them.

5. If you are using the top alone you will be using the buckles with double-sided Velcro all the way around the top. If using the top with a Lexan windshield you will be using the two buckles with grommets for the front two straps on the Top Cap.

6. If no windshield all straps of the top will use the buckles with double-sided Velcro.
   Wrap the roll cage with the adhesive Velcro strip roughly half the strap length from the top. Then wrap the double-sided Velcro around the adhesive Velcro leaving the buckle facing towards the top. See the Pictures below for wrapping the Velcro around the bar.
   

7.  Now run the strap from the top to the buckle and install it as shown in the diagram below.

8.  If you have a windshield the two buckles that have grommet holes, in the end, will attach to one of the bolts holding the windshield down. Face the buckle towards the top and attach the straps from the top as shown above. The photo below shows how this should look.

9. The middle of the top down the sides has a snap that will attach using the included double-sided strap with a snap stud in it. Wrap the roll cage with the adhesive Velcro hook and then wrap the adhesive Velcro with the double-sided

10.  Once in place pull all straps tight making sure the top is centered.

11. Enjoy!

Return Policy

If for any reason you choose to return this product it must be returned within 30 days from the date the item is received. You MUST package the product exactly as it was originally packaged from the factory to get a full refund for the product!
The vinyl windows should never be folded when packaging in the box or for storage purposes.
Lay all the windows on top of each other with the canvas folded in between and the paper (if available) on both sides of the windows.
All returned products will be inspected upon arrival at the production facility and must be in unused, factory-new condition to receive a refund – a 25% restocking fee will apply.
If ordered from Falcon Ridge please call 606-845-7439 to gain a return authorization number, use our preferred shipping carrier (UPS) to return the item (unless the item is defective, you are responsible for paying the shipping to return the item.) Any returns submitted to Falcon Ridge without a return authorization number will be charged a 20% restocking fee. If ordered from one of Falcon Ridge’s many distributors, you must first call them and see what their return policy is. Once your item reaches our production facility, our customer satisfaction team will inspect your item to ensure unused, factory-new condition.
NOTE: All windshields must be returned with the original protective film intact and not removed.
Do NOT REMOVE it if you have any intentions of returning the item. Refund/ replacement of a windshield will only be processed on items with original protective film or if the windshield is defective. Items must be properly packaged in the original shipping carton to protect them during transit and ensure your returned item arrives back factory fresh, and in new resalable condition (any returned items that have been used, altered or damaged in any way will not be subject to a refund.) All contents including instruction manuals, accessories, hardware, Velcro, etc. must be included in your return shipment. Only items in OEM factory new condition will be approved. Once returned items are received, a credit will be issued to the original credit card/ payment method used for the purchase. Outbound shipping and return shipping costs will not be refunded. Please allow 4 to 6 weeks for your refund to be processed.

Warranty

To The Owner of this Product:
Thank you for purchasing one of our Falcon Ridge Cab Enclosures, Tops &/or Windshields!
Below are the terms under which your product is covered under our manufacturer’s warranty.
30 Day Warranty which includes and is not limited to replacing the enclosure, tops, and/or windshield due to defects in the product. Please refer to the return policy in this case for more information. 1 Year Warranty includes any defect in material or workmanship within this time frame we will gladly correct the problem or replace the enclosure, tops &/or windshield. Upon submitting for the correction or replacement we will need to receive pictures of the defect in material or workmanship along with the receipt from the date of purchase.

Thank you,
Falcon Ridge

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>