FALCON RIDGE PO-14MIDRANGER-WD05 Full Aero-Vent Polycarbonate Windshield Instruction Manual
- June 3, 2024
- FALCON RIDGE
Table of Contents
PO-14MIDRANGER-WD05 Full Aero-Vent Polycarbonate Windshield
Instruction Manual
PO-14MIDRANGER-WD05 Full Aero-Vent Polycarbonate Windshield
2515 Bypass Rd. F
lemingsburg, KY 41041
606-845-7439
Instructions for Installation and Care of Full Aero-Vent Polycarbonate
Windshield
PO-14MIDRANGER-WD05
-
Be sure to read these instructions thoroughly before opening and installing the windshield.
-
Check over the parts included in the cartons with the parts list shown below:
11/4″ Stainless Bolts
Small Washers
Metal Brackets
Plastic Thumb Nuts
Plastic Slide Fasteners
26″ Small Side Bulb Gasket
44″ Small Side Bulb Gasket
45″ Small Side Bulb Gasket
Vent Sliders| 6 each
6 each
4 each
6 each
8 each
2 each
1 each
1 each
2 each
---|--- -
Start by pulling it out of the box; find a clean area to lay it down and install the hardware next take the rubber gasket and start at one end firmly placing it along the entire outer edge of the windshield. The 44″ goes on a strait edge and on top of the Windshield. The 45″ is along the bottom curved edge. And the two 26″ strips go down the sides. You will need to peel back the protective film from the edge to install the gasket. If you leave the bulk of the protective film on while installing you can avoid scratching the windshield. Ensure that the gasket is seated fully home on along the edge to ensure a good fit of the windshield.
-
Next, take the two vent sliders and install them on the inside surface of the windshield as shown in the diagram below.
-
Now place the windshield inside the frame of the Ranger. Take the Metal brackets and bolt them to the windshield from the inside using the supplied 11/4″ bolts washer and thumbnut as shown in the picture below.
-
Enjoy, and remember- when cleaning the windshield do so gently at first with warm water and mild detergent to dislodge any grit that may scratch the Polycarbonate. After rinsing and drying with a soft cloth, you may then polish the windshield with an appropriate commercially available plastic polish, also available from Falcon Ridge. This will ensure many seasons of clarity and keep scratching and swirling to a minimum.
Never use cleaners such as Windex that contain ammonia as doing so may adversely affect the windshield.
Thank You for your purchase!
Return Policy
If for any reason you choose to return this product it must be returned within
30 days from the date item is received. You MUST package the product exactly
as it was originally packaged from the factory to get a full refund for the
product!
The vinyl windows should never be folded when packaging in the box or for
storage purposes.
Lay all the windows on top of each other with the canvas folded in between and
the paper (if available) on both sides of the windows.
All returned products will be inspected upon arrival at the production
facility and must be in unused, factory-new condition to receive a refund – a
25% restocking fee will apply.
If ordered from Falcon Ridge please call
606-845-7439 to gain a return
authorization number, use our preferred shipping carrier (UPS) to return the
item (unless the item is defective, you are responsible for paying the
shipping to return the item.) Any returns submitted to Falcon Ridge without a
return authorization number will be charged a 20% restocking fee. If ordered
from one of Falcon Ridges’s many distributors, you must first call them and
see what their return policy is. Once your item reaches our production
facility, our customer satisfaction team will inspect your item to ensure
unused, factory-new condition.
NOTE: All windshields must be returned with the original protective film
intact and not removed. Do NOT REMOVE it if you have any intentions of
returning the item. Refund/ replacement of a windshield will only be processed
on items with original protective film or if the windshield is defective.
Items must be properly packaged in the original shipping carton to protect
them during transit and ensure your returned item arrives back factory fresh,
and in new resalable condition (any returned items that have been used,
altered, or damaged in any way will not be subject to a refund.) All contents
including instruction manuals, accessories, hardware, Velcro, etc. must be
included in your return shipment. Only items in OEM factory new condition will
be approved.
Once returned items are received, a credit will be issued to the original
credit card/ payment method used for the purchase. Outbound shipping and
return shipping costs will not be refunded. Please allow 4 to 6 weeks for your
refund to be processed.
Warranty
To The Owner of this Product:
Thank you for purchasing one of Falcon Ridge Cab Enclosures, Tops &/or
Windshields! Below are the terms under which your product is covered under our
manufacturer’s warranty.
30 Day Warranty which includes and is not limited to replacing the enclosure,
tops, and/or windshield due to defects in the product. Please refer to the
return policy in this case for more information.
1 Year Warranty includes any defect in material or workmanship within this
time frame we will gladly correct the problem or replace the enclosure, tops
&/or windshield. Upon submitting for the correction or replacement we will
need to receive pictures of the defect in material or workmanship along with
the receipt from the date of purchase.
Thank you,
Falcon Ridge
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>