FLUVAL AC20 AquaClear 20 Power Filter User Guide
- June 1, 2024
- FLUVAL
Table of Contents
FLUVAL AC20 AquaClear 20 Power Filter
Product Specifications
- Brand: Fluval
- Model: AC20
- Usage: Aquarium Filter
- Includes: Filter Cover, Media Basket, Filter Case, Impeller Assembly, Seal Ring, Motor Unit, Levelling Device, Impeller Cover, Intake Tube, Extension Tube, Intake Stem, Intake Sponge, Bio-Foam Carbon, BIOMAX
Installation
- Refer to the detailed installation instructions available at fluvalaquatics.com/ac-im/
- Assemble the filter components as per the provided list of included items
- Ensure all safety instructions are followed during installation
Filter Setup
- Rinse Bio-Foam thoroughly and place it in the bottom section of the media basket
- Insert the media basket into the filter case, ensuring proper alignment
Maintenance
- Regularly clean and replace filter media as per manufacturer recommendations
- Inspect for any signs of abnormal water leakage or damage
- Keep electrical components dry and away from water
FAQ (Frequently Asked Questions)
Q: What should I do if the appliance falls into the water?
A: If the appliance falls into the water, do not reach for it. Unplug it first
and then retrieve it. Ensure all electrical components are dry before plugging
it back in.
Installation
For detailed installation, use and maintenance instructions, visit fluvalaquatics.com/ac-im/ or scan QR code below.
WHAT’S INCLUDED
- Filter Cover
- Media Basket
- Filter Case
- Impeller Assembly
- Seal Ring
- Motor Unit
- Levelling Device
- Impeller Cover
- Intake “U” Tube
- Extension Tube
- Intake Stem
- Intake Sponge
- Bio-Foam
- Carbon
- BIOMAX
IMPORTANT SAFETY INSTRUCTIONS
WARNING–To guard against injury, basic safety precautions should be observed, including the following:
-
READ AND FOLLOW ALL SAFETY INSTRUCTIONS and all important notices on the appliance before using. Failure to do so may result in damage to the appliance.
-
DANGER – To avoid possible electrical shock, special care should be taken since water is employed in the use of this equipment. For each of the following situations, do not attempt repairs yourself; return the appliance to an authorized service facility for service or discard the appliance.
-
If the appliance falls into the water DO NOT reach for it! First unplug it and then retrieve it. If any of the electrical components of the appliance gets wet, unplug it immediately.
-
If the appliance shows any sign of abnormal water leakage or if RCD
(or GFCI- Ground Fault Current Interrupter) switches off disconnect the power supply cord from mains and remove pump from water. -
Carefully examine the appliance after installation. It should not be plugged in if there is water on parts not intended to be wet.
-
Do not operate any appliance if it has a damaged cord or plug, or if it is malfunctioning or if it is dropped or damaged in any manner. The power cord of this appliance cannot be replaced; if the cord is damaged, the appliance should be discarded. Never cut the cord.
-
To avoid the possibility of the appliance plug or receptacle getting wet, position the appliance to one side of a wall mounted receptacle to prevent water from dripping onto the receptacle or plug. A “drip loop” (A) should be arranged to the receptacle. The “drip loop” is the part of the cord below the level of the receptacle or the connector if an extension cord is used, to prevent water traveling along the cord and coming into contact with the receptacle. If the plug or receptacle does get wet, DO NOT unplug the cord. Disconnect the fuse or circuit breaker that supplies power to the appliance. Then unplug and examine for presence of water in the receptacle.
-
-
WARNING – Close supervision is necessary when any appliance is used by or near children. This appliance can be used by children ages 3 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children shall not play with the appliance. Cleaning and user maintenance shall not be made by children without supervision.
-
To avoid injury, do not contact moving parts or hot parts such as heaters,
reflectors, lamp bulbs, and the like. -
CAUTION – Always unplug or disconnect all appliances in the aquarium from electricity supply before placing hands in water, before putting on or taking off parts and while the equipment is being installed, maintained or handled. Never yank cord to pull plug from outlet. Grasp the plug and pull to disconnect. Always unplug an appliance from an outlet when not in use.
-
This appliance is a non-submersible aquarium filter-pump. It is intended for use in ornamental household aquariums. It may be used with fresh or salt water. Maximum water temperature 35°C. Do not use this appliance for other than intended use (ie: DO NOT use in swimming pools, bathtubs, etc.). The use of attachments not recommended or sold by the appliance manufacturer may cause an unsafe condition and will invalidate your warranty.
-
This is a HOUSEHOLD APPLIANCE INTENDED FOR DOMESTIC USE and it is suitable for INDOOR use only. Do not install or store this appliance where it will be exposed to the weather or temperatures below freezing.
-
Make sure that this appliance is securely installed before operating it and that the electrical connection is in accordance with the data on the rating label. Do not allow filter pump to run dry.
-
If an extension cord is necessary, a cord with a proper rating should be used. A cord rated for less amperes or watts than the appliance rating may overheat. Care should be taken to arrange the cord so that it will not be tripped over or pulled. The connection should be carried out by a qualified electrical installer.
-
SAVE THESE INSTRUCTIONS for future reference.
QUICK START GUIDE
-
Rinse Bio-Foam thoroughly and place in bottom section of media basket.
-
Place the media basket into the filter case, ensuring the side indicated “BIOMAX FRONT” on the basket is facing front of filter.
-
Remove Activated Carbon from protective plastic bag. Rinse thoroughly and place in top rear section of media basket, respecting the “MAX FILL” level.
-
Remove BIOMAX from protective plastic bag. Rinse thoroughly before placing in top front section of basket marked “BIOMAX FRONT”, respecting the “MAX FILL” level.
-
Install intake “U” tube and apply gentle pressure until it clicks into position.
-
Attach intake sponge to end of intake stem.
-
Add the extension tube to the intake stem if aquarium depth requires it.(Extension tube included with models AC30, AC50, AC70)
-
Attach intake assembly to intake “U” tube and apply gentle pressure until it slides into position.
-
Attach leveling device to filter case by inserting peg into place.
-
Mount filter onto rear of aquarium.
-
Rotate leveling device until filter is perfectly level.
-
Fill filter case completely with water.
-
For the initial start-up and for a faster priming of filter, adjust water flow control lever on the intake “U” tube to its minimum position.
-
Plug power cord into electrical outlet. Allow 30-45 seconds for priming.
-
When priming is complete, adjust flow control to desired output.
-
Install filter cover.
IMPORTANT – DO NOT OPERATE FILTER WITHOUT WATER For optimal filter operation and efficiency, regular cleaning of the filter and its parts is recommended every month. Do not use soaps or detergents.
MAINTENANCE / TROUBLESHOOTING / REPLACEMENT PARTS
Visit fluvalaquatics.com/ac-im/ or scan QR code.
RECYCLING
This symbol bears the selective sorting symbol for waste electrical and electronic equipment (WEEE). This means that this product must be handled pursuant to European Directive 2012/19/EU in order to be recycled or dismantled to minimize its impact on the environment. Check with your local Environmental Agency for possible disposal instructions or take to an official council registered refuse collection point. Electronic products not included in the selective sorting process are potentially dangerous for the environment and human health due to the presence of hazardous substances.
FOR AUTHORIZED WARRANTY REPAIR SERVICE
- QUESTIONS? If you have a problem or question about the operation of this product, please let us try to help you before you return the product to your dealer. Most problems can be handled promptly with a phone call. Or, if you prefer, you can contact us on our website at www.fluvalaquatics.com When you call (or write),
- please have all relevant information, such as model number and/or part numbers available.
- USA CALL US ON OUR TOLL-FREE NUMBER: 1-800-724-2436 between 9:00 a.m. and 4:00 p.m.
- Eastern Standard Time. Ask for Customer Service.
- CANADA CALL US ON OUR TOLL-FREE NUMBER: 1-800-554-2436 between 8:00 a.m. and 4:30 p.m.
- Eastern Standard Time. Ask for Customer Service.
- UK Helpline Number 01977 521015. Between 9:00 AM and 5:00 PM, Monday to Thursday and 9:00 AM and 4:00 PM on Friday (excluding Bank Holidays).
3 YEAR WARRANTY
The Fluval AquaClear or AC Series filter is guaranteed for defective parts and workmanship for a period of 3 years from the date of purchase. This guarantee is valid with proof of purchase only. The guarantee is limited to repair or replacement only and does not cover consequential loss, loss or damage to livestock and personal property or damage to animate or inanimate objects, irrespective of the cause thereof. This guarantee is valid only under normal operating conditions for which the unit is intended. It excludes any damage caused by unreasonable use, negligence, improper installation, tampering, abuse or commercial use. The warranty does not cover wear and tear, breakage of glass or parts which have not been adequately or correctly maintained. THIS DOES NOT AFFECT YOUR STATUTORY RIGHTS.
LIMITED TIME OFFER! Register this product online within 30 days of purchase and Fluval will extend your current warranty at no charge. The extended warranty is subject to provisions outlined within the standard Fluval warranty. Complete details and registration available at: Visit fluvalaquatics.com/ac-im/ or scan QR code.