MODSTER M550 Electric Scooter User Manual

MODSTER M550 Electric Scooter

Introduction

Welcome to the Club of e-scooter drivers!
We are happy to welcome you to the MODSTER M550/MK083 drivers community and we are sure you will enjoy this e-scooter! This operating manual explains the most important points that should be observed, helps you to maintain your MODSTER e-Scooter, and describes the correct operation of the vehicle for safe and long-term use. All information is based on the technical state at the time of the constitution of this operating manual. Changes and additions made in the meantime are not included in this version. You can find the latest version of the manual online at www.modster.at. If you have any questions or problems, please do not hesitate to contact us by writing an email to info@modster.at and we will take care of a quick and uncomplicated help.

WARNING

ATTENTION: Be aware that driving with electrical assistance needs getting used to. The acceleration and therefore the force forward are very intense. This unusual acceleration can lead to falls of inexperienced drivers. Begin carefully and make sure you have enough space. It is best to practice in a safe place without traffic.
ATTENTION: In addition to the normal braking performance due to friction, when the disc brake is activated, the MODSTER M550/MK083 brakes with an electric motor brake. This improves the braking performance massively and leads to a shorter braking dis-tance. Please be aware, however, that the engine brake is not supported when:

• The battery is empty and therefore you drive with pure muscle power.
• The battery is 100% charged and therefore no energy can be regenerated.

The additional braking power of the engine brake is enormous and shortens the braking distance immensely. Be aware of this, especially if the additional braking power is not present in the situations mentioned above.

ATTENTION: Always use the fender brake and let go of the accelerator pad to slow down and stop. Do not brake by using the sole of your foot!
ATTENTION: Read this chapter completely before using the scooter! Improper operation of the device may result in damage to the product or other property or serious injury.
ATTENTION: Failure to exercise caution when using this product and disregard the following warnings may result in a product malfunction, electrical problems, excessive heat, fire, and ultimately personal injury and property damage.

Important Notes & General Information Before Driving

General information

• The MODSTER M550/MK083 is designed for the transport of a single person up to the max. 100 kg and should be used for this purpose only. Failure to observe this warning is considered to be improper use and is at the user‘s own risk.
• All interventions to increase the performance or speed and generally to change the characteristics of the scooter are punishable and are prosecuted by law. They will void the warranty.
• The road traffic regulations must be observed at all times. You are obliged to inform yourself about applicable law in your country and to comply with it.
• The MODSTER M550/MK083 is not a toy! It is not designed for the weight of children. We recommend a minimum age of 16 years and a minimum weight of 25 kg.

Preparation for driving

• Choose a flat road for your first ride and make sure there are no obstacles in your environment.
• Check if the scooter has been fully extended and then correctly secured again.
• Make sure that the steering rods are screwed in properly and not loose.
• Check the effectiveness and correct function of your brake.
• Test the pedal screws and make sure that they are tightened.
• Check the battery charge and if it is sufficient for your trip.

Safety information

• Only drive on dry roads. Riding on wet floor coverings can be very dangerous and has to be avoided at all costs.
• Never drive with motor support on the sidewalk. This is not only dangerous for you and your fellow human beings, but also illegal in many countries.
• Due to safety reasons do not drive in the dark.
• Always wear protective equipment, in particular a suitable helmet, which reliably protects you against head injuries.
• Never brake by rubbing on the ground with your sole! Always brake with the rear brake (foot brake)!

The battery is only partially charged. Charge the battery completely before using the vehicle for the first time.
Please also note that depending on the country, different maximum speeds and restrictions regarding maximum power apply to electrically assisted vehicles. It is your own responsibility to be informed accordingly and to stick to this.
Please always observe the laws and regulations applicable in your country regarding road traffic and vehicle class. Keep in mind that legislation may vary by country and that MODSTER M550/MK083 has no road registration. Please also check out www.der.MODSTER.at.
Beware of steep slopes! The braking performance is not sufficient in steep, rapid journeys to ensure a safe ride.
Drive slowly on your first ride to get used to the new kind of driving. Keep in mind that a higher speed also results in a longer braking distance. If the vehicle is wet or after cleaning the vehicle, the brake system can react delayed due to the moisture. After cleaning the scooter, take care that the brakes are dried before using the vehicle again.
Each range information, as well as information on maximum speeds and incline ability, are heavily dependent on parameters such as the state of charge of the battery, condition of the ground, inclines or declines during the driving route, weight of the person driving, physical performance by diving, or if available, use of the pedals, weather conditions, headwind and depending on other factors. Our information relates to the optimal case.
For a long-term driving fun
Never use the MODSTER M550/MK083 on a wet road.
Do not jump with the scooter, as this will lead to excessive loads, which can result in damage to the scooter which is excluded from the warranty. Be sure to avoid slopping holes at any time and drive at right angles over curbs and other obstacles.
Warranty notes

• The MODSTER M550/MK083 may only be used on dry ground, any ride on wet surfaces will void the warranty.
• Do not perform any independent repairs. Always contact your service center. Any opening of the scooter will lead to the automatic lapse of the warranty. In individual cases, the manufacturer, in consultation with the customer, allows the opening of the footboard under certain conditions.
• The „tuning“ of the M550/MK083 is forbidden. It endangers your own safety as well as operational safety and reduces the lifespan of your vehicle. In addition, this will invalidate the warranty. You will find more information at the chapter Warranty.

Product Detailed Specification

The MODSTER e-scooter is compact, lightweight and easy to use, and ready to go within a minute.

Please check the box about all those accessories shown above.

Product Dimensions| Length Width Height| 105,4-120 x 43,6 x 48 cm
---|---|---
Length Width Height foldet| 105,4-120 x 43,6 x 115 cm
Product Weight| Net Weight| 14,5 kg

Riding Requirements

| Max. Load| 100 kg
Min. Load| 25 kg
Age| 16 to 50 years old
Recommended height of the driver 1| 120 – 200 cm
Terrain Clearance| 9 cm

Main Parameters

| Max Speed| up to 25 km/h
Range2| up to 40 km
Climbing Angle| up to 11 degree
Working Temperature| Minus 10 to 40 degree
Storage Temperature| Minus 20 to 40 degree
Water-proof level| IP54

Battery Parameters

| Rated Voltage (VDC)| 36 V/10,4 Ah
Rated Input Voltage (VDC)| 42 V
Battery Capacity| 10,4 Ah
Motor Parameters| Rated Power| 350 W

Charger Parameters

| Rated Input Voltage| AC 100-240V/50-60 Hz
Rated Output Voltage| 42 V 2,0 A
Charging time| 5-6 hours

Remarks:

1. Recommended height: The distance from the floor to the top of the body
2. The MODSTER M550/MK083 has a range of up to 40 kilometers, but please note that this is just a guideline value with optimal conditions for a 75 kg driver, measured at 15 km/h and 25°C. Top speed up to 25 km/h.

Ultimately, range and top speed are greatly dependent on different facts, such as:

• Profile of the driven route (hills or flat),
• Own contribution by the driver
• Flooring
• Outside temperature
• Driver weight
• and more

Name and Content of Toxic or Harmful Elements of the Scooter

Above the table is made according to the regulation of SJ/T 11364.

• means the content of such kind of element is below the standard base on GB/T 26572.
• means the content of such kind of element is above the standard base on GB/T26572.

Warranty Policy

This scooter strictly offers after-sales service based on the Consumer Protection Law and Product Quality Law of China.

• We offer 1 year warranty of main body of the scooter including the frame, motor, controller, handlebar, meter platform, rear wheel, brake disc, folding mechanism, brake cable, and front fork.
• Acessories like battery and home adapter offer 6 months warranty. The fender, tires, bell-set rear taillights foot pad, decorative cover etc frequently contact part will be offer 3 months of warranty.
• Free coming gift like hex wrench or extended air connector there is no warranty.

Non-warrant regulations

1. Unauthorized repair, malfunction, collision, negligence, abuse, infusion, accident and alteration, or any kind of improper use of the pro duct accessories cause the result of damage of the unit itself.
2. Beyond the warranty time
3. Any damage caused by the force majeure.
4. Any man-made reason cause the damage.
5. If the product is used for commercial use, it is not guaranteed.

Functions and instructions

The Control Panel

1. Speed display: showing the running speed while riding
2. Model display: Green light is on when the power on in low speed mode first and max speed it 15km/h, double press the switch to change it to high speed mode with red light on and max speed is 25km/h.
3. Battery indicator: The battery light status will change from right to left: 4 lights on indicating battery between 86 to 100%; 3 lights on indicating battery between 71 to 85%; when the battery used up, all lights are extinct and the scooter will slide to natural stop by inertia. Then time to recharge.
4. Power switch: When the scooter is power on, quick press the switch to turn on the vehicle, long press the switch for 2S, can turn it off. After turning on the vehicle, quick press the switch: on/off the light.

Assembling the scooter

Charging the scooter

• Never charge the battery unattended!
• Never leave the charger connected for a long time after charging!

Learning to ride

Safety Instructions

Dangerous Riding is not allowed

• Do not ride the scooter into the motor lane or ride it in high speed!
• No Sharp turn allowed in the residential area or passing with a large group

Safety Notifications:

1. The electric scooter is not a motor vehicle but once you are driving into a public area, you must obey the public regulations and understand riding into public would bring risks for you and others of injury. Read this user manual carefully before you drive it.
2. Comply with all safety instructions while riding in the public area. Never forget there is a possibility of collision due to the violation of pedestrian or vehicle traffic rules. Improper operation will cause a risk of injury. Like any other kind of vehicle, the higher speed you are riding, the bigger distance you need for braking. Emergency braking may cause slippery on the smooth or wet roads. Therefore, always keep an appropriate speed while you are riding this scooter, always keep s safe distance from pedestrians and passing vehicles, and pay more attention on that roads that you are not familiar.
3. Always respect the rights of pedestrians, do not scare them, especially the children, while passing them, and reduce your speed. For the right-hand traffic countries: if you are moving in the same direction with the pedestrians, stay in the left side of the road as much as possible; if you are moving in the opposite direction, stay to the right and slow down.
4. Follow the Driving Regulations & Safety Instructions in your country. Violation of those rules may result in fines, per-sonal injury or serious traffic accidents, legal disputes, conflict or any other unpleasant situations. Our company does not bear any those directly or un-directly lost or injury liability.
5. Do not borrow this scooter to others who does not know how to ride for avoiding personal injury. Must take some time to train him/her if you want to as well as require them to wear the proper safety gear.
6. Check the scooter carefully before you ride on it. If you find parts broken, battery life has decreased obviously, flat tire or abnormal sounds or symptoms. STOP riding immediately and check or repair it first.

Fold and transportation

Make sure the scooter is off and open the folding wrench in the front bar like picture showing above. Dip down the front bar to the hook in the rear fender and tie it up. When you want to use it the scooter again, just simply release the hook and lift the front bar up and lock the wrench again.

Transportation:

After folding, carry the front bar with one hand or both hands to transport

Daily Maintenance and Storage

1. Clean the electric scooter:
   If you see any stains on this scooter surface, use a soft cloth to wipe it off. If the stain still there, then you can use the toothpaste and a toothbrush to clean it and wipe it off with the soft cloth again. If you find scratches on the plastic parts, use the sandpaper or grinding materials for polishing.
   Warning:
   

   • Do not use alcohol, petrol, kerosene or other corrosive and chemical material to clean the scooter, otherwise, it will cause serious damage to the scooter body and even disrupt the internal functions.
   • Do not wash the electric scooter under a strong pressure of water, make the scooter is off while cleaning.
   • Insert the plug back after charging the scooter, or you may get an electrics shock or during the cleaning the water may falling into to the charging port and cause the serious damage of the scooter.

2. Storage the electric scooter:
   If you do not use the scooter, storage it in a dry, cool place and do not leave it in the street for a long time. Leave the device under the extremely high or low temperature can shorter the life of the electric scooter or reduce the battery life.

3. Maintenance of electric scooter battery:
   

   • Do not use the batteries from the other factory to avoid a dangerous situation.

   • Do not disassemble the battery to prevent the electric shock. Avoid contact with metal objects to prevent an occurrence for a short-circuit. Otherwise the battery may have malfunction or can injure the user.

   • It is recommended to use the home adapter that comes in the original device to prevent accidents or fire of the scooter.

   • Improper disposal of used batteries will cause severe environmental pollution. Please dispose of the battery according to the local laws, do not dispose it with food waste and protect the environment together.

   • After each use of the device, charging the scooter would prolong its life
     

   • Do not store the scooter battery in any place with a temperature higher 50°C or lower than -20°C (For example, do not leave the scooter in the trunk in summertime). Do not leave the scooter near the fire, and all those actions may cause inflammation.

   • If you don’t use the scooter within 30 days, then charge the battery and keep the device in a cool and dry place. Then you need to charge it every 60 days, otherwise, it might cause failure, which is not included in warranty services.

   • Avoid fully discharging the device to prolong the battery life. Using the device in normal room temperature, the range will be bigger and the performance is better. If you use the scooter at a temperature below 0 °C, the range and performance will be decreased.

   • At -20°C, the range is less than the scooter in normal temperature or even half, if the temperature rises, the range will also increase. You can check the remained range in the APP.

Note: Fully-charge scooter standby time is 120 to 180 days, the battery has a smart-chip to monitor the charging and discharging information. If you are not changing the battery for a long time, it will cause the batteries die directly. Such kind of damage is not included in the warranty services. (Caution: Do not disassemble the device by the unauthorized person, this might cause electric shock or serious injury from the short-circuit.)

Adjusting the brake disc

If you feel the brakes are too tight, use the M5 hex wrench counterclockwise to release the plate screws on the disc, slightly shorten the tail brakes cable then lock it up with plate screws; If you feel the brakes are too loose, release the plate screws and slightly extend the tail brakes cable to the tail side and tighten the screws again.

Adjusting the front bar

If the front bar is shaking, use the M5 hex wrench to lock the two screws at the folding mechanism.

Disclaimer of warranties

• the maximum total weight and load must not be exceeded. High loads in connection with the overloading operation of the device can lead to structural damage. Jumping with the device is not allowed and leads to loss of warranty, as well as driving through potholes and the like. Driving on cobblestones leads to increased wear!
• Only one person is allowed to drive at the same time.
• The device is designed for operation on flat, smooth surfaces. It must not be used on sandy, muddy, wet, slippery, icy or snow-covered surfaces. Driving in rain and snow is not allowed.
• Do not disassemble or repair the device by yourself. This leads to loss of warranty.
• Do not store the device with empty batteries. You must check the charge state of the battery each month and recharge if needed.
• Cleaning the device with high-pressure cleaners or using a garden hose is not allowed. Wipe only with a damp cloth.
• Depending on the load, the device is subject to more or less severe wear. This can lead to a deflection of the steering, wheel bearings, folding mechanism and the like; this is not covered by the warranty. Brakes, tires, drive chains, and sprockets are wearing parts and are also not covered by the warranty. The drive battery is designed for 200 charging cycles. A gradual decrease in performance cannot be avoided and is not covered by the warranty.
• Store the device in a dry place at a temperature between 10°-30°C.
• Only use the original charger and never charge the battery unobserved.
• Do not exceed the design speed of the device. This can easily be exceeded, especially when driving downhill.

DECLARATION OF CONFORMITY

SHENZHEN MANKE TECHNOLOGY CO.,LTD

• ADD: Room 515,
• Floor 5, Building A, Country Garden Fenghuangzhigu, Tiezai Road, Xixiang Street, Bao ‘a District, Shenzhen, 518000, China
• Tel: 0755-23005256 We, Shenzhen Manke Technology Co., ltd
• ADD: Room 515, Floor 5, Building A, Country Garden Fenghuangzhigu, Tiezai Road, Xixiang Street, Bao ‘a District, Shenzhen, 518000, China
• TYPE: Electric Scooter
• BRAND: Mankeel
• Model: MK083
• Declare under our sole responsibility that the above product, manufactured by: Shenzhen Manke Technology Co., ltd
• Add: Room 515, Floor 5, Building A, Country Garden Fenghuangzhigu, Tiezai Road, Xixiang Street, Bao ‘a District, Shenzhen, 518000, China
• To which this declaration relates, is in conformity with the requirements of the following EC Directives:
• This Declaration of Conformity is based upon compliance of the product with the following harmonized standards Test Standards:
• Year CE mark first affixed： 2022
• In accordance with the following Directives: EC Council Directive of 2014/35/EU Low Voltage Directive
• Date: 5th May 2023
• Signed by or for the manufacturer: Shenzhen Manke Technology Co., ltd
• Contact Person: Mr. Huang
• Title: Engineer

References

• MODSTER

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>