Char-Griller 2123 Wrangler Charcoal Grill Owner’s Manual

OWNER’S MANUAL
Wrangler™
Model #2123

Keep your receipt with this manual for Warranty.
CUSTOMER SERVICE
1-912-638-4724
Service@CharGriller.com
Contents of this manual are Trademarked and Copyrighted by Char-Griller | A&J Manufacturing.
Using the information contained in this manual without consent of Char-Griller and/or A&J Manufacturing is strictly prohibited.

IMPORTANT SAFETY WARNINGS

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING AND OPERATING YOUR GRILL
Read the following instructions carefully and be sure your appliance is properly assembled, installed, and maintained. Failure to follow these instructions may result in serious bodily injury and/or property damage. If you have any questions concerning assembly or operation, call 912-638-4724.

• Grill is for use outdoors and in well-ventilated areas, only.
• Use caution when assembling and operating your grill to avoid scrapes or cuts from sharp edges.
• Do not use gasoline, kerosene, or alcohol to light charcoal. Use of any of these or similar products could cause an explosion possibly leading to severe bodily injury.
• Do not leave a lit grill unattended. Keep children and pets away from grill at all times.
• Use caution when moving grill to prevent strains.
• Keep grill at least 15 feet from any combustible material (decks, buildings, fences, trees, bushes, etc).
• When adding charcoal and/or wood, use extreme caution.
• Never move grill when it is in use or when it contains hot coals or ashes.
• Do not place grill near fl ammable liquids, gases, or where fl ammable vapors may be present.
• Use caution since fl ames can fl are-up when fresh air suddenly comes in contact with fi re.
• When opening the lid, keep hands, face, and body safe from hot steam and fl ame fl are-ups.
• WARNING: To avoid injuries gloves or other protective articles should be used when touching the ash pan hangers.
• Do not exceed a temperature of 400°F.
• Do not allow charcoal and/ or wood to rest on the walls of grill. Doing so will greatly reduce the life of the grill.
• Always wear oven mitts to protect hands from burns. Avoid touching hot surfaces.
• CAUTION: Exposed metal dampers on air vents and and/or metal handles are hot during usage.
  Again, always wear oven mitts when adjusting air fl ow to protect hands from burns.

WARNING: FUELS USED IN WOOD OR CHARCOAL BURNING APPLIANCES, AND THE PRODUCTS OF COMBUSTION OF SUCH FUELS, CAN EXPOSE YOU TO CHEMICALS INCLUDING CARBON BLACK, WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND CARBON MONOXIDE, WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. For more information go to: www.P65Warnings.ca.gov.

• When opening lid, make sure it is pushed all the way back so it rests against the lid support brackets. Use extreme caution as hood could fall back to a closed position and cause bodily injury.
• Close lid and all dampers to help suffocate fl ame.
• Always hold an open lid from the handle to prevent it from closing unexpectedly.
• Never leave coals and ashes unattended. Before grill can be left unattended, coals and ashes must be removed. Use caution to protect yourself and property.
• Carefully place remaining coals and ashes in a noncombustible metal container and saturate completely with water. Allow coals and water to remain in metal container 24 hours prior to disposing.
• To protect against bacteria that could cause illness, keep all meats refrigerated and thaw in refrigerator or microwave. Keep raw meats separate from other foods, and wash everything that comes in contact with raw meat.
• Cook meat thoroughly, and refrigerate leftovers immediately.
• Use a calibrated food thermometer and the USDA guidelines to ensure that meat, poultry, seafood, and other cooked foods reach a safe minimum internal temperature.
• Always have a fi re extinguisher near at all times. Maintain and check your fi re extinguisher regularly.

THESE WARNINGS ALSO APPLY TO THE SIDE FIRE BOX.
REGISTER YOUR GRILL:
To take full advantage of the Char-Griller warranty be sure to register your grill by visiting www.CharGriller.com/Register or calling Customer Service at 1-912-638-4724. Registration provides important protections:

1. In the extremely unlikely event of a product recall Char-Griller can easily contact you and rectify the issue.
2. If a warrantied part is broken or missing we can send you the needed parts promptly.

NOTE: You will need your model #, serial number, and a copy of the original sales receipt when registering.
STOP! CALL FIRST!
Do NOT Return Product to Store.
This grill has been made according to the highest of quality standards. If you have any questions that are not addressed in this manual or if you need parts please call our Customer Service Department at 1-912-638-4724 (USA) or email Char- Griller at: Service@CharGriller.com and have your serial number handy.
Document Your Grill Model and Serial Numbers HERE:
(Model and Serial number are located on the back of the grill body or on the leg.)

(MODEL #) (SERIAL#) WARRANTY INFORMATION
A COPY OF THE DATED PROOF OF PURCHASE (RECEIPT) IS REQUIRED WHEN REGISTERING OR SUBMITTING A WARRANTY* CLAIM. PLEASE RETAIN A COPY OF THE RECEIPT FOR YOUR RECORDS.
Char-Griller will replace any defective part of its grillers/smokers, under warranty, as outlined below.
PLEASE READ THIS INFORMATION IN DETAIL AND IF YOU HAVE ANY QUESTIONS CONTACT CUSTOMER SERVICE AT 912-638-4724 OR SERVICE@CHARGRILLER.COM.

Charcoal / Pellet / Kamado Grills

Grill – Hood AND Bottom
(excludes removable Ash Pan)| 5 years from date of purchase for rust through / burn through
Ash Pan AND Defective Parts| 1 year from date of purchase
Gas Grills|
Grill Hood (TOP half) AND Main Burner Tubes
(exckudes Side Burner)| 5 years from date of purchase for rust through / burn through
Grill Body (BOTTOM half) AND Side Burner
AND Defective Parts| 1 year from date of purchase
Dual Fuel Grills (Gas & Charcoal)
Charcoal Grill – Hood AND Bottom AND Gas
Grill Hood (TOP half) AND Main Burner Tubes
(excludes Ash Pan and Side Burne| 5 years from date of purchase for rust through / burn through
Ash Pan AND Defective Parts AND Gas Grill
Body (BOTTOM half) AND Side Burner| 1 year from date of purchase
Parts, Accessories, and Grill Covers| 1 year from date of purchase (seam tears only for covers)

SURFACE RUST IS NOT CONSIDERED A MANUFACTURING OR MATERIALS DEFECT
Char-Griller grills are made of steel and if exposed to the elements rust will occur naturally. Please refer to the section entitled, “Usage” to review how to care for your grill properly.
Surface issues such as scratches, dents, corrosion or discoloring by heat, abrasive and chemical clearers, surface rust or the discoloration of steel surfaces are NOT covered under these warranties.
Warranties are for the replacement of defective parts only. Char-Griller is not responsible for damage resulting from accident, alteration, misuse, abuse, hostile environments, improper installation, and installation not in accordance with local codes of service of unit.
Excluded Under ALL Warranties
Paint; Surface Rust; Heat Damage; Incorrect Parts ordered by customer, including shipping; Worn Parts; Missing or damaged parts not reported within two (2) months of purchase date; Defective parts not reported within one (1) year of purchase date; Fading grill cover.
*NOTE: For warranty claims, photos and prepaid return of the item in question may be required. Misuse, abuse or commercial use nullifi es all warranties.
PARTS LIST

HARDWARE AND TOOLS NEEDED
Assembly: Requires 2 people. Get another person to help. Tools Needed: Pliers, Phillips Head Screwdriver and a 7/16” Nut Driver.
NOTE: Do Not tighten any bolts unless instructed to do so. Tightening too soon may prohibit parts from fitting together. All Hex Nuts should be on the inside of the grill unless stated otherwise. Unpack all contents in a well cleared and padded area.
Estimated Assembly Time: 45 minutes
Hardware Pack:

| Hex Bolt 1/4-20 x 2”| 2
---|---|---
| Hex Bolt 1/4-20 x 1 3/4”| 12
| Hex Bolt 1/4-20 x 3/4”| 11
| Hex Bolt 1/4-20 x 1/2”| 4
| Hex Nut, Flange 1/4-20| 31
| Lock Washer 1/4”| 3
| Flat Washer 1/4”| 2
| Large Cotter Pin| 2
| Shoulder Bolt| 2
| Hub Cap| 2
| Small Cotter Pin| 2

ASSEMBLY

Step 1
Assemble LONG LEG, SHORT LEG, and LEG BRACES as shown below then secure the LEG BRACES to one set of LONG LEG and SHORT LEG with four (4) 1 3/4” HEX BOLTS and four (4) HEX NUTS. Step 2
Install BOTTOM WIRE SHELF by placing the four corner hooks inside the hole on each LEG then rotate the leg assemblies up and secure the LEG BRACES to the other side of the LONG LEG and SHORT LEG set. Step 3
Lay the cart assembly down with the LONG LEGS on the floor then install the WHEELS and WHEEL AXLE. On one end of the AXLE insert the LARGE COTTER PIN into the hole on the AXLE and snap on the HUB CAP. Slide one WHEEL onto the AXLE then slide the AXLE through the holes on the SHORT LEGS. Complete the assembly by sliding the other WHEEL onto the AXLE then insert the LARGE COTTER PIN and snap on the HUB CAP. Step 4
Attach the GRILL BODY to the previous assembly cart using four (4) 1 3/4” HEX BOLTS and four (4) HEX NUTS. The bolts and nuts go through the LEG, GRILL BODY then tighten with the HEX NUT inside the GRILL BODY. Step 5
Attach DAMPER CIRCLE to the side of the GRILL BODY with one (1) 3/4” HEX BOLT, two (2) FLAT WASHERS, one (1) LOCK WASHER and one (1) HEX NUT. Step 6
Attach the GRILL HOOD to the GRILL BODY using two (2) SHOULDER BOLTS and two (2) SMALL COTTER PINS provided. Step 7
Insert the THERMOMETER through the THERMOMETER BEZEL then through the hole in GRILL HOOD (from outside) then secure with a WINGNUT. Then attach the HOOD HANDLE to the HOOD with two (2) 3/4” HEX BOLTS, two (2) LOCK WASHERS, and two (2) HEX NUTS, see below. Step 8
Install SMOKESTACK through the hole on the GRILL HOOD from the inside of the GRILL HOOD then secure it with two (2) 3/4” HEX BOLTS and two (2) HEX NUTS. Step 9
Attach SIDE SHELF to GRILL BODY using four (4) 1/2” HEX BOLTS and four (4) HEX NUTS. Step 10
Attach FRONT SHELF to GRILL BODY using four (4) 3/4” HEX BOLTS and four (4) HEX NUTS. Step 11
To install WARMING RACK first attach two (2) 2” HEX BOLTS and two (2) HEX NUTS onto each side of the GRILL HOOD. Then attach two (2) 3/4” HEX BOLTS and two (2) HEX NUTS onto each side of the GRILL BODY. And then position the WARMING RACK onto the HEX BOLTS and secure it with two (2) HEX NUTS at the GRILL HOOD. Step 12
Place ASH PAN and ASH PAN HANGERS into GRILL BODY. Step 13
Place COOKING GRATES onto GRILL BODY then install the UTENSIL HOOKS underneath each SIDE SHELF slab at the front of the grill. Then install the GREASE CUP HOLDER underneath the GRILL BODY. Fully Assembled Hint: The paper label that is affixed to the hood is more easily removed when the hood is warm. Any remaining glue residue can be cleaned off with a spray lubricant like WD-40 . Do NOT use any other type of solvent or cleaner because this will damage the finish/paint/coating on the grill.

OPERATING INSTRUCTIONS

Setting Up
Set grill up on solid, fl at surface with adequate wind shelter. Do not move grill while hot, and do not leave unattended during operation.
This appliance is designed for use outdoors, away from any fl ammable materials. It is important that there are no overhead obstructions and that there is a minimum distance of 3 feet (90cm) from the side or rear of the appliance. It is important that the ventilation openings of the appliance are not obstructed.
The barbecue must be used on a level, stable surface. The appliance should be protected from direct drafts and positioned or protected against direct penetration by any trickling water (e.g. rain).
PLEASE NOTE: NO RETURNS ON USED GRILLS
Seasoning and Preparing the Grill
IMPORTANT! BEFORE YOU USE YOUR GRILL FOR THE FIRST TIME YOU MUST SEASON THE CAST IRON COOKING GRATE(S).
Cure grill prior to your initial use to protect the interior and exterior fi nish, cooking grates, and to prevent unnatural fl avors to your fi rst meals.

1. Lightly coat ALL INTERIOR SURFACES (including grills, grates, and inside of barrel.) with vegetable oil (spray vegetable oil is easiest but do not use near hot coals or fi re).
2. Build a medium sized fi re on the fi re grate. Always put charcoal on top of the fi re grate and not directly into the bottom of the grill.
3. After coals ash over, spread out coals, replace cooking grates, close lid and heat at approximately 250 F for two hours.
4. Remove grates from the grill with oven mitts, allow to cool, then re-coat grates and return to grill at approximately 200° F for two hours.
5. You can lightly coat the exterior of the grill body (while warm) with vegetable oil. This will extend the life of the fi nish, much like waxing a car. Your grill is now ready for use.

NOTE: Grill will drip oil during this process and for several uses afterwards. This is normal.
NEVER EXCEED 400°F BECAUSE THIS WILL DAMAGE THE FINISH AND CONTRIBUTE TO RUST. PAINT IS NOT WARRANTED AND WILL REQUIRE TOUCH-UP. THIS UNIT IS NOT WARRANTED AGAINST RUST.
Lighting Instructions

1. To start a charcoal fi re, stack 15 briquettes in a pyramid and saturate with lighter fl uid.
   NOTE: Do not use gasoline, kerosene or alcohol for lighting charcoal. Use of any of these or similar products could cause an explosion possibly leading to severe bodily injury.

2. Light coals in several places

3. After briquettes ash over or turn gray, spread them out and start cooking

4. If one end burns faster, use tongs to move coals from one end to the other for even heat.

Grill Operation & Tips

• Control heat with amount and type of fuel, Dual dampers, and adjustable fi re grate. Adjust grate one end at a time. Wood burns hotter than coals. More airfl ow is more heat.
• To reduce fl are-ups, cook with lid in the down position.
• Add water soaked hardwood chips for a smoked fl avor.
• Ashes left in bottom too long hold moisture and will rust through any thickness of steel. This grill is made of steel and cast iron, which WILL RUST, ESPECIALLY IF NOT PROPERLY CARED FOR.
• Do not use self-starting charcoal as it will give unnatural fl avor. Burn lighter fl uid completely before closing lid.
• After each use, coat vegetable oil on the interior grates and bare metal while warm to reduce rust
• On the EXTERIOR, remove dust with wire brush and touch up with a high heat paint, available at most hardware/auto stores.
• You may place a coffee can on bottom shelf under the hole in the grill to catch drippings.
• Heat guage may obtain moisture, which will steam out during cooking. Gauge can be removed and calibrated in oven.
• You may fi ll unwanted holes with Nuts & Bolts (Not Provided).

NOTE: Smoke may escape from areas other than the smokestack. This should not affect cooking.
Finishing Up
When your are fi nished grilling you can shut down your grill by closing both dampers and allowing the fi re to suffocate. Be patient. This may take an hour or more.
Emptying the Ashes & Ash Pan:
ONLY EMPTY ASHES WHILE GRILL IS NOT IS USE
After the fi re is completely extinguished you should wait several hours before emptying the ashes to ensure they are not still hot and a burn hazard.

1. Knock any ashes that did not fall into the ash pan from the fi re grate. (If there are pieces of partially burned charcoal on the fi re grate you can save them for next time. They are still good).
2. Tap the sides of the fi re bowl to knock loose any ash that is on the sides.
3. Unclip the ash pan from the bottom of the grill and slide out towards the front.
4. Give the ash pan a few fi rm taps to loosen any ash that may be stuck.
5. Place the ashes in a metal container and cover with water to ensure there are no lit coals then you can dispose of the ashes.

IMPORTANT: Charcoal is porous and holds moisture. DO NOT leave charcoal in your grill while you are not using it. Charcoal and ashes left inside the ash pan may reduce the life of your grill.
This Page Intentionally Left Blank

GRILLING RECIPES

Know Your Cuts of Meat![Char Griller 2123 Wrangler Charcoal Grill

• Meat 1](https://manuals.plus/wp-content/uploads/2023/10/Char-Griller-2123 -Wrangler-Charcoal-Grill-Meat-1.png) Direct Heat

  • Direct Heat is a high heat method used to cook foods that take less than 25 minutes to cook. Typically, this means foods that are relatively small or thin such as steaks, chops, boneless chicken breasts, fi sh fi llets, hamburgers, etc.

  • Cooking with a MEAT THERMOMETER ensures food is fully cooked. Insert into the thickest part not touching bone, and allow fi ve minutes to register.

  • Internal temperatures for FOWL should be 170°F to 180°F.

  • Internal temperature for meat should be 140°F for rare, 160°F medium, and 170°F for well done.
    STEAK ( & ALL MEATS):

  • Cook food on the charcoal side of the unit, directly above coals/heat.

  • To grill meats, raise fi re grate to high position (hot) and sear for one minute on each side with the lid open to seal in fl avor and juices. Then lower fi re grate to medium position with lid closed and cook to desired doneness.

  • Control heat with dual dampers and adjustable fi re grate.
    Tip: Place grilled meat back in the marinade for several minutes before serving – it will become tastier and juicier.
    CAUTION: Boil extra marinade fi rst to kill bacteria remaining from the raw meat.
    MARINATED FLANK STEAK:

  • Mix marinade ingredients in nonmetal dish.

  • Let steak stand in marinade for no less than 4 hours in refrigerator.

  • Brown each side for 5 minutes, but center should remain rare.

  • Cut steak diagonally across the grain into thin slices before serving.

  • Grill with fi re grate in high (hot) position with lid open or closed.

Meat Marinade
1/2 cup vegetable or olive oil
1/3 cup soy sauce
1/4 cup red wine vinegar
2 tbsp lemon juice
1 tsp dry mustard
1 minced clove garlic
1 small minced onion
1/4 tsp pepper
QUAIL OR DOVES:

• Cover birds in Italian dressing (Good Seasons or Kraft Zesty) and marinate overnight.

• Pour remaining dressing and cover with Texas Pete Hot Sauce for 6 hours.

• Wrap birds in thick bacon secured by a toothpick.

• Place on grill. Keep turning until bacon is black.

• Grill for 20 minutes. Sear with lid open and fi re grate in high (hot) position for 1 minute on each side before lowering grate and closing lid.

• To SMOKE, place birds in center of GRID with fi re in both ends of FIRE BOX.
  KABOBS:

• Alternating on skewers any combination of meat, onions, tomatoes, green peppers, mushrooms, zucchini, circular slice of corn-on-the-cob, or pineapple. Meat could consist of chunks of shrimp, scallops, lobster, chicken, sausage, pork, beef, etc.

• Marinate the meat in refrigerator for several hours.

• Grill each side approximately 7 minutes turning occasionally while basting with marinade. Leave a small amount of room between pieces in order to cook faster.

• Grill with lid up and the fi re grate in the lowest position. See marinade recipe on last page.

Kabob Marinade:
1 cup soy sauce
½ cup brown sugar
½ cup vinegar
½ cup pineapple juice
2 tsp salt
½ tsp garlic powder

• Mix all ingredients in a saucepan and bring to boil.

• Allow marinade to cool before marinating your meat in it.

• Marinate beef in mixture a minimum of 4 hours.
  HOT DOGS:

• Grill with lid up and fi re grate in high (hot) position for approximately 6 minutes.

• Turn every few minutes.
  HAMBURGERS:
  See Meat Marinade on prior pages.
  You may also marinate by allowing to stand in marinade for 1 or 2 hours at room temperature before cooking, or let stand in covered dish in refrigerator up to 24 hours.

• Bring to room temperature before cooking.

• Mix in chopped onions, green peppers, salt, sear 3/4 inch patties on each side with fi re grate in high position for a few minutes.

• Lower fi re grate to medium position and grill with lid down to avoid fl are-ups.

• Cook each side 3 to 7 minutes according to desired doneness.

• Cook ground meat to 150 internally or until juice runs clear (free of blood) for prevention of E-coli.

• Burgers can be basted with marinade when turning and/or other ingredients can be mixed in with the ground beef such as chili sauce or powder.
  SHRIMP (Peeled) & CRAYFISH:

• Place on skewers.

• Coat with melted butter and garlic salt.

• Grill 4 minutes on each side or until pink. Cocktail sauce optional.
  BAKED POTATOES:

• Rub with butter and wrap in foil and cook on grill with lid down for 50 minutes.

• Turn after 25 minutes (no need to turn if smoked).

• Squeeze to check for doneness.
  SWEET CORN IN HUSKS:

• Trim excess silk from end and soak in cold salted water 1 hour before grilling.

• Grill 25 minutes – turning several times.

SMOKING RECIPES
Indirect Heat
SMOKING TIME

Food| Weight| Water pan Smokin| Side Fire Box| Temperature on Meat Thermometer
---|---|---|---|---
Beef Roasts, Beef Brisket| 3 — 4 lbs.| 1 —1 1/2 hours| 4 — 5 hours| 140° rare
Lamb Roasts, Venison| 5 — 7 lbs.| 1 3/4 — 2 1/2 hours| 5 — 6 hours| 160° medium
Large cuts of Game| 7 – 9 lbs.| 2 1/2 — 3 1/2 hours| 7 – 10 hours| 170° well done
Pork Roasts| 3 — 4 lbs.| 1 3/4 — 2 1/2 hours 2 1/2| 5 — 6 hours| 170°
5 — 8 lbs.| 3 hours| 7 – 8 hours| 170°
Pork /Beef Ribs| Full grill| 1 1/2 – 2 hours| 4 — 6 hours| Meat lulls from bone
Pork Chops| Full grill| 3/4 —1 1/4 hour| 4 — 6 hours| Meat pulls from bone
Sausage Links| Full grill| 2 – 2 3/4 hours| 4 – 5 hours| 170° for fresh sausage
Ham, Fresh| 10 lbs.| 3 – 4 hours| 7 – 8 hours| 170°
Ham, Cooked| All sizes| 1 1/2 – 2 hours| 3 – 4 hours| 130°
Chicken (Cut up or split)| 1-4 fryers. cut up or spilt| 1 – 1 1/4 hours| 4 – 5 hours| 180°/ leg moves easily in joint
Chicken (Whole)| 1-4 fryers| 1 1/4— 1/ 2 hour| 5 — 6 hours| 180°/ leg moves easily in joint
Turkey (Unstuffed)| 8 -12 lbs.| 1 3/4— 2 1/2 hours| 7 – 8 hours| 180°/ leg moves easily in joint
Fish. small whole| Full grill| 1/2- 3/4 hours| 2 — 3 hours| Flakes with fork
Fish, filets, steak| Full grill| 1/4 —1/2 hours| 1— 3 hours| Flakes with fork
Duck| 3 – 5 lbs.| 1 – 1 3/4 hours| 5 — 6 hours| 180°/ leg moves easily in joint
Small game birds| Full grill| 3/4 -1 hour| 4 – 5 hours| 180°/ leg moves easily in joint

Pan not included. Disposable bread pan is recommended. SMOKE BY COOKING SLOWLY (See chart above).

1. Place water/drip pan on left side of fi re grate.
2. Place hot coals on right side (damper end) of fi re grate. The charcoal basket accessory helps confi ne coals to one side.
3. Place meat above water pan.
4. Place fi re grate in low position.
5. Close lid & control heat with dampers & adjustable grate.
   • You may want to sear certain foods before smoking by placing meat directly above coals with LID open and FIRE GRATE in high (hot) position for several minutes. Add fl avor soaked wood chips to the fi re and add 1 part marinade, beer, or wine to 3 parts water to the drip pan.
   • OPENING THE SMOKING CHAMBER WILL EXTEND COOKING TIME. Cooking with meat thermometer ensures food is fully cooked. Insert thermometer into thickest part not touching bone, and allow fi ve minutes to register. Internal temperature for birds should be 170°F to 180°F or when leg moves easily in joint. Meat should be cooked to internal temperature of 140°F for rate, 160°F for medium and 170°F for well done. Check the water level when cooking more than 4 hours or when you can’t hear the water simmering. Add water by moving meat over and pouring water through GRILL into WATER PAN.
   • IF THE SMOKE IS WHITE, THE FIRE’S RIGHT. IF THE SMOKE IS BLACK, ADD SOME DRAFT.

SMOKED TURKEY:

• Empty cavity rinse and pat dry with paper towel.
• Tuck wing tips under the back and tie legs together.
• Place in center of cooking grid directly above foil drip pan of water.
• Smoke for 12 minutes per pound. Allow several extra minutes per pound if stuffed to allow for expansion.
• Use a meat thermometer for best results (190F internal).

SMOKED BAKED HAM:
You can smoke fully cooked canned ham or smoked and cured whole ham or shank or butt portion.
Glaze
1 cup of light brown sugar, fi rmly packed
1/2 cup orange juice
1/2 cup honey

• Combine sugar, juice and honey. Let glaze sit for at least 4 hours.

• Place fi re grate in the lowest position and a drip pan under the meat.

• Remove rind and score fat diagonally to give a diamond effect.

• Insert a whole clove into the center of every diamond.

• Place ham with fat side up in center of cooking grid directly above drip pan. Close lid.

• About 9 minutes per pound is suggested for fully cooked hams. Smoked or cured ham, which is not fully cooked, should be cooked to an internal temperature of 160°F.

• Baste with ham glaze 3 or 4 times during last 30 minutes of cooking time.

• Garnish with pineapple rings about 15 minutes before end of cooking time.
  SMOKED HOT DOGS STUFFED:

• Slit hot dogs lengthwise, within 1/4 inch of each end.

• Stuff hot dogs with cheese and relish and wrap in bacon.

• Place on cooking grid over drip pan and smoke 15-20 minutes or until bacon is crisp.
  SMOKED CHICKEN PARTS AND HALVES:

• Rinse pieces in cold water and pat dry with paper towels.

• Brush each piece with vegetable oil and season to taste with salt and pepper.

• Brown pieces directly above coals with lid open and grate in high or medium position for several minutes.

• Then place pieces on cooking grate directly above drip pan.

• With the grate in the low position, cook with lid down for 55 to 60 minutes or until done. Do not use vegetable oil or salt and pepper if using marinade.

SMOKED VENISON:
Venison Marinade:
1 cup Balsamic or wine vinegar
1 cup olive oil
2 oz. Worcestershire
1/2 oz. Tabasco
2 tbsp. Season All
1-2 chopped jalapenos
3 oz. soy sauce
Bacon Marinade
2 oz. wine vinegar
2 oz. Worcestershire
4 dashes Tabasco

• Place leg of venison in a container or “hefty bag” and marinate for 2-4 days, turning daily. Marinate bacon overnight in its marinade.

• Remove roast from refrigerator at least an hour before cooking.

• Season generously with seasoned salt and coarse ground black pepper.

• Wrap 1 lb. Bacon over the top of the roast, and smoke 20/25 minutes per pound, or until tender. Do not overcook.
  SMOKED SHRIMP & CRAYFISH:

• Mix in a foil pan 1/2 cup butter, two cloves of crushed garlic, Tabasco, sliced green pepper, 1 tablespoon each of minced onions, salt and juices from one lemon.

• Add shrimp and/ or crayfi sh and smoke 45 minutes.
  SMOKED VEGETABLES:

• Turnips, potatoes, carrots, okra, mushrooms, peeled onions, zucchini, squash, etc.

• Put in pan and cover with water and cook for several hours while cooking the meat. Or place vegetables on grill and smoke for 50 minutes, either wrapped in foil or not.
  SMOKED FISH:

• Marinate in brine (1/4 cup dissolved in 1 qt of water) or marinate fi sh in 1 cup white wine, 1 cup soy sauce mixed with 1 cup lemon juice.

• Marinate overnight in covered dish in refrigerator.

• Let air on rack 20 minutes before placing on Pam-sprayed grill.

• Smoke 25 minutes.
  SMOKED SPARE/BACK RIBS:

• Peel off tough layer of skin on back side.

• Rub all surfaces with seasoning.

• Place ribs in center of grid above drip pan and smoke approximately 1 1/2 hours or until meat pulls away from bone.

• Baste with barbecue sauce during last 30 minutes.

CHICKEN MARINADE:
Combine
1/2 cup soy sauce
1/4 cup vegetable oil
1/4 cup red wine vinegar
1 teaspoon oregano
1/2 teaspoon sweet basil
1/2 teaspoon garlic powder with parsley
1/4 teaspoon pepper

• Pour over chicken pieces in non-metal dish
• Cover and refrigerate overnight, turning occasionally. Use marinade to baste chicken while cooking.

MEAT MARINADE: (For steaks, chops, and burgers)
Combine
¼ cup soy sauce
2 coarsely chopped large onions
2 cloves garlic (halved)

• Combine ingredients in an electric blender, cover, and process at high speed 1 minute or until mixture is very smooth.
• Stir in 1/4 cup bottle gravy coloring (Kitchen Bouquet and Gravy Master) and 2 teaspoons Beau Monde seasoning (or substitute 1 teaspoon MSG and 1 teaspoon seasoned salt).
• Allow meat to stand in marinade at room temperature for 2 hours or refrigerate up to 24 hours in a covered dish.
• Bring meat to room temperature before cooking.

SHISH KABOB MARINADE:
Mix
1 cup soy sauce
1/2 cup brown sugar
1/2 cup vinegar
1/2 cup pineapple juice
2 teaspoons salt
1/2 teaspoon garlic powder

• Mix ingredients and bring to a boil.
• Marinate beef in mixture a minimum of 4 hours.

ACCESSORIES

Cover Custom Fit
Weather Resistant
Protects Grill Finish
Cover Accommodates Side
Shelf or Side Fire Box

Side Fire Box
Turn your charcoal grill into an authentic
Texas-Style Offset Smoker in minutes! Charcoal Basket
Confi nes Coals to One
Side for Smoking
Indirect Cooking Apron
Machine Washable
Two Front Pockets
Adjustable Straps Warming Rack
Increase Grill Area
Keeps Food Warm Rotisserie
Excellent for Effortless Grilling
Universal Fit for Any Grill Quick Release
Chimney Starter
E-Z starter with patented
Trigger release
ABS handle with heat shield
Zinc coated galvanized steel
Makes starting charcoal grill fast and easy Cast-Iron Grates
Heavy-duty Durability
Authentic BBQ Flavor
Non-Warp Design

For pricing or to order accessories visit:
www.CharGriller.com
OR
CALL: 912-638-4724
P.O. Box 30864
Sea Island, GA 31561
912-638-4724
www.CharGriller.com
Service@CharGriller.com

References

• Char-Griller BBQ Grills and Smokers
• P65Warnings.ca.gov

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>