SARIS 10690 801 Bones 3 Bike Bike Rack Instruction Manual
- June 6, 2024
- SARIS
Table of Contents
SARIS 10690 801 Bones 3 Bike Bike Rack Featured
Accessories
- Bike Beam is required H bicycle wheels are not parallel to the ground when carrying a bicycle with a sloped top tube, or a full suspension bicycle.
- Bike Beam is also required if bicycle wheels are 12″ or less from the ground when installed on the rack.
Installation
Technical Specifications
Bike carrier weight: 11 lbs/5kg
Permitted load capacity: max 1051bs/48 kg Max bike weight: 35 lbs/16 kg
CAUTIONS:
- All requirements for compatibility/fit as stated in the current Saris vehicle/carrier compatibility guide must be followed. (Available at any Saris dealer). If your vehicle is not listed or you have any questions, please call our customer service at 800-783-7257 or visit www.saris.com.
- Read and follow instructions carefully. Save owner’s manual for future reference or parts information. Ensure that any other users of the bicycle carrier are familiar with their content.
- It’s the end users responsibility to ensure that use of this product meets all local and state laws.
- License plate dimensions and lighting systems shall be type approved according to national regulation.
- When a lighting – signaling system is duplicated, it is important that the electrical connections shall be made in accordance with the state of the art and the recommendation of the vehicle manufacturer.
- When cleaning vehicle and rack, use only water soluble cleaners. Do not take rack through car wash.
- Make sure bike tires are not directly behind exhaust pipe.
- Do not mount to any type of trailer or towed vehicle.
- Prior to usage on the road, remove all loose parts from bicycle, including (but not limited to) child seat, basket, lock, light, pump, etc.
- This carrier is not recommended for off-road use or for use at speed exceeding 80 mph (130 km/h).
- The handling characteristics of a vehicle will change when a rear bicycles carrier is fitted and especially when it is loaded (in particular crosswind sensitivity, handling on bends and braking). Driving techniques should be altered to allow for these changes, reduce speed, especially on bends and allowing for longer braking distances.
- The vehicle’s total length increases when the bike carrier is attached. The bikes themselves may increase the vehicle’s total width and height. Take care when reversing and/or entering garages or ferries, etc.
- Do not open rear deck (trunk) with carrier installed.
- Remove carrier from vehicle when not in use.
- Rear window wipers may not be usable while carrier is attached to vehicle.
- This carrier is a bumper-supported bike rack. Bumper legs must rest on bumper.
- This carrier is constructed to carry standard-bike-frames. It is not intended for use with tandem or recumbent bicycles.
- Never place more than three bicycles (maximum weight 1051bs/48 kg) on carrier. Secure properly and adjust for even load distribution, loading the heavies / biggest bike first and closest to the vehicle.
- Replace any mounting strap at the first sign of wear. Replacement parts are available through your local Saris dealer or call 1-800-783-7257.
- Upper-hook straps must be parallel with the rear leg to prevent shifting.
- Central tube should be directly above bumper.
- No part of carrier, including straps, should ever come in contact with spoiler.
- To prevent potential damage, secure the front tires of bicycles (part number 3033 recommended).
- Tighten straps and buckles regularly during the journey.
- Saris absolves itself of responsibility for any personal injuries or consequential damage to property or wealth caused by incorrect fitting or use.
Recommended Rack Maintenance & Care Instructions Each use:
- Wipe down trunk rack feet
- Avoid ground contact with trunk rack feet
- Check straps for signs of wear
- Check bike cradles and wheel scoops
- Check for loose bolts
Every 90 days actions:
- Clean with water and mild soap
- Lubricate locks if applicable (use wet, oil-based lubricant; NO WD-40)
- Grease hitch bolt threads
- Check for scratches in paint.
Official Warranty Terms: Saris Racks
Saris Cycling Group, Inc (SCG), parent company of Saris Racks, warrants our
products to the original consumer to be free from defects in materials and
workmanship. Your purchase includes the following warranty which is in lieu of
all other express warranties. This warranty is extended only to the initial
consumer purchaser. This warranty gives you specific legal rights. You may
have other legal rights which vary from state to state. Please retain your
sales slip for your records, as proof of purchase will be required.
Warranty Term
- Car Racks – Limited Lifetime*
- Home Storage/Bike Storage – Limited Lifetime*
- Kool Rack – 1 Year
- Parking Racks – 1 Year
*Warranty only valid for original purchaser. Limited lifetime warranty available in North America only.
Manufacturing defects are most likely to be identified on new products or
early in the product’s lifespan. Each warranty claim is unique, and it is
solely up to SCG to determine if a product can be covered by the limited
life1ime warranty due to defects, or if the product has suffered wear and
tear.
Any product or part thereof found to be defective within the term as set forth
above will be replaced without charge provided that: (1) its failure resulted
from a defect in material or workmanship and not from normal wear and tear
expected in the use of the product; (2) the product was not abused, misused,
improperly assembled, improperly maintained or damaged by accident or
installation of parts or accessories not originally intended or compatible
with the racks as originally sold., (3) there was no failure to follow
instructions or warnings in Owner’s Manual; (4) no alterations or
modifications were made; and (5) the product or part is delivered, freight
prepaid, to Saris Cycling Group or an authorized service center. Please call
1-800-783-7257 to obtain return
authorization prior to return. Any other claims not included in the statements
above are void and will not be honored. SCG reserves the right to inspect any
product before issuing a replacement. SCG’s only obligation shall be to
replace such products or parts that it determines are defective.
Limitations
THE FOREGOING WARRANTIES ARE THE ONLY WARRANTIES MADE BY SCG. THERE ARE NO
OTHER WARRANTIES. ANY WARRANTY THAT MIGHT OTHERWISE BE IMPLIED BY LAW
INCLUDING, BUT NOT LIMITED TO ANY IMPLIED WARRANTY OF MERCHANTABILITY OR
FITNESS FOR A PARTICULAR PURPOSE ARE LIMITED STRICTLY TO THE APPLICABLE LENGTH
OF THIS LIMITED WARRANTY.
SCG shall not be liable for incidental or consequential losses, damages, or expenses in connection with its products. SCG’s liability hereunder is expressly limited to the replacement of goods not complying with this warranty or, at SCG’s election, to the repayment of an amount of the purchase price of the product in question.
Exclusions
- If consumer does not comply with all warnings, cautions, or instructions listed in Instruction Manual, damage is not covered under warranty.
- Impact / collision damage is not covered under warranty
- Cradles and strap damage due to improper arm placement are not covered under warranty
- Carrying anything other than a bicycle is not covered under warranty
- Paint damage – chipping, cracking, or fading is not covered under warranty
- Rust is wear and tear and is preventable with rack maintenance
- Weather impact (UV, salt air/water)
- Damage to mounting surface
- Damage or loss resulting from failure to replace/maintain consumable items not covered.
- Not following Recommended Rack Maintenance
- Consumable Items not covered by warranty. Including but not limited to.
- Arm and wheel tray adjustment knobs
- Frame and wheel straps
- Vehicle attachment straps
- Molded wheel trays
- Frame cradles
- Threaded assemblies
- Ratcheting assemblies
Saris Cycling Group 5253 Verona Road Madison WI 53711 USA
Ph: 608.274.6550
Fax: 608.274.1702
www.saris.com