Adexa E10C10C32 Gas BBQ Grill Instruction Manual

Adexa E10C10C32 Gas BBQ Grill

IMPORTANT: READ ALL INSTRUCTIONS AND OPERATIONS BEFORE OPERATING THIS UNIT.
FOLLOW ALL STEPS IN ORDER. NEVER ALLOW CHILDREN TO OPERATE THIS UNIT.
Warnings :

• Only to be used outdoors.

• Read the instructions before using the appliance.

• Accessible parts maybe very hot, keep young children away.

• Do not move the appliance during use.

• Turn off the gas supply at the gas cylinder after use.

• Any modification of the appliance may be dangerous.

• Parts sealed by the manufacturer or his agent must not be altered by the user.

• Do not modify the appliance.
  Attention:

• Some parts of this appliance become very hot, take special care when children or elderly are present.
  For your safety:

• Do not store or use gasoline or mentholated fuels or any other flammable vapors and liquids in the vicinity of this or any other appliance.

• Never light a gas grill with gasoline or comparable fluids!

• Suggestion: user should not change the assembly that the manufacturer packaged.

As a safety device, the tanks pressure relief valve will vent gas vapor to relieve this excess pressure. This vapor is combustible and therefore can be ignited.
To reduce this danger, you should take the following safety precautions:

• When you have your tank filled, be sure you tell the supplier to fill it to no more than 80% of its total capacity.
• If you own or use an extra spare tank, or have a disconnected tank, you should never store it near or under the grill unit or heat box, or near any other ignition or heat source.

USE AND CHARACTERISTICS

The barbecue grill is safe and easy to use. Please ensure you only use your barbecue at the correct pressure the appliance is designed for.
Food can be barbecued on the cooking grid either with or without the lid being closed. When the lid is closed for 5 minutes, the lid must be open for 1 minute to release heat.
With a grease tray or a grease cup under the case.

Adequate ventilation is vital for the combustion and efficient performance of the barbecue. This will ensure the safety of the user and other people in the vicinity of the area where the appliance is being used. Never use the appliance in any enclosed covered area.

• When the wind speed is above 2m/s, don’t use gas grill facing to the wind.
• The appliance is designed for use outdoors only.
• Warning! Accessible parts may be very hot. Keep young children away.
• Read the instructions before using the appliance.
• Do not move the appliance while in use.
• Turn off the appliance at the cylinder valve or regulator after use.
• Any modification to the appliance may be dangerous and may cause injury or property damage.
• The parts sealed by the manufacturer or his agent shall not be manipulated by the user.
• Any unauthorised modification of the appliance will invalidate the guarantee on this appliance.
• Do not modify the appliance
• Never mount the cylinder under the barbecue on the base shelf as this could result in serious injury to the user, other people and/or property.
• Use protective gloves when handling particularly hot components.
• The appliance must not have any overhead obstruction. E.g. trees, shrubs, lean to roofs. The appliance must be installed with a clearance of 1 m around the appliance.
• The appliance must not be used near flammable materials. (Petroleum-based products, thinners or any other solid object that carries a flammable warning label.)
• Close the valve of the gas cylinder or the regulator after use.
• The use of this appliance in enclosed areas can be dangerous and is PROHIBITED.

Technical data

ADEXA DIRECT LIMITED Product name: Outdoor gas Grill

Ground Floor, Unit 1, 214 Purley Way, Pin Number: 0063CN7292

Croydon CR0 4XG United Kingdom Serial Number:

T:(+44)01483 931040 service@adexa.co.uk

www.adexa.co.uk

Country of Destination

|

Appliance Category

|

Gas and Supply Pressure

|

Main Burner

| E10C10C32

Injector Size Ø

| Total Nominal Heat Inputs (Hs)
BE,CH,CY,CZ,ES,

FR,GB,GR,IE,IT,LT, LU,LV,PT,SK,SI

|

I3+(28-30/37)

| Butane(G30) 28-30 mbar| 0.86mm| 6.0kW    436g/h
Propane(G31) 37 mbar| 0.86mm| 6.0kW    428g/h
BE,CY,DK,EE,FI,HU,

LT,NL,NO,SE,SI,SK, RO,HR,

TR,BG,LU,MT

|

I3B/P(30)

|

Butane/Propane 30 mbar

|

0.86mm

|

6.0kW    436g/h

AT,CH,DE,S K| I3B/P(50)| Butane/Propane 50 mbar| 0.75mm| 6.0kW    436g/h
PL| I3B/P(37)| Butane/Propane 37 mbar| 0.82mm| 6.0kW    436g/h
Use Outdoors Only .

Read the instructions before using the appliance. 0063-21

The gas cylinder should not be placed inside BBQ.

Warning : Accessible parts may be very hot. Keep young children away. Made in China

• Reduce the opening time of the lid.
• Turn the grill off as soon as cooking is completed.
• Preheat the gas grill for 10 to 15 minutes only.(Except for the first use)
• Do not preheat longer then recommended.
•  Do not use a higher setting than required.
• Connect the hose and regulator to the gas container at the left side of the gas grill .Keeping in mind that the gas container must be kept away from heat and in a safe position .The hose dimension is 8-10mm diameter. The Length of hose recommended which shall not exceed 1.5m.

Installation

After purchasing your gas cylinder you will then be ready to set it up with your gas grill.

•  When changing the gas cylinder which shall be carried out away from any source of ignition. Position the gas cylinder at left side or inside of your BBQ, keeping in mind that the bottle must be kept away from heat and in a safe position.
• When ready to use your gas grill insert the regulator into the gas bottle valve and tighten firmly.

Warning: Before attempting to light your gas grill you must refer to your lighting  instructions and warning/ safety points.
Check the hose before each use, searching for cracking, cuts or any abrasions. If the hose is found to be faulty in any way do not attempt to use your gas grill.

When changing your gas bottle ensures that there are no sources of ignition close by i.e. fires, cigarettes, naked flames etc. Make sure that the appliance is switched off.
Ensure that the hose is not subjected to twisting which will affect the gas flow when installing your gas grill. Also the hose must not have undue tension and must not touch any part of the gas grill which may be hot.
Please choose flexible hose whose heatproof higher than ao·c
Flexible tube should be changed every 2 years; It’s necessary to change the flexible tube when the national conditions require it.

How to change your cylinder
Note: Turn off the switch of cylinder (No spanner is required) put the gas cylinder outside the grill, The height of the gas cylinder is below the 80cm, and the width is within 35cm,Net weight of gas cylinder should not be more than 15KG;

  How to connect a gas bottle

• Turn the orange cap so that the arrow is pointing to the gap in the shroud.
•  Remove the orange safety cap by pulling the lanyard out, then out. Do not use tools. Leave the cap hanging.
•  Check that the black sealing washer is fitted inside the cylinder valve. Connect the regulator to the valve.
• Turn the switch clockwise on gas bottle-then turn on the gas grill as instructed.

Warning: Always test gas line for leaks at connector with soap water finishing all connections._

How to disconnect a gas bottle

• Except for twin-cylinder installations with a changeover valve, turn off the gas tap if fitted to the appliance. Wait until the burner and pilot light have gone out. For installations with a changeover valve, it is only necessary to switch off the empty cylinder.
• Replace the orange safety cap onto the empty cylinder.

Warning and safety points

Please read the following points before using your gas grill:

•  Read the instructions before using the appliance. If instructions are not followed it may cause problems in use.
•  This gas grill accessible parts maybe very hot when being used. Keep young children away. Use protective when handling particularly hot components.
• In the event of a gas leak, Turn off the gas supply at the gas bottle, extinguish any open flames, open lid and if leak continues, check for damages, poor connections etc. Contact your local gas dealer immediately if the problem can’t be solved.
• Do not move Gas grill during use.
• Do not use or store any liquids, vapors or other materials in the vicinity when operating the gas grill.
• This gas grill only to be used outdoors.
•  Do not use a naked flame to check for gas leaks.
•  Do not operate gas grill if there is a gas leak. Turn off the gas supply.
• Do not attempt to disconnect any gas fitting part if your gas grill is being used, on the gas grill or the gas regulator / bottle.
• Care is advised when operating your gas grill, you should never leave unattended when in use. Turn off the gas supply at the gas container after use.
•  The gas grill should be cleaned after use. Don’t obstruct the fire opening of the container compartment. If the fire opening is obstructed, please use 1.6mm round stick to dredge.
• Take care not to enlarge burner ports or orifice/nozzle openings when cleaning the burner or valves.
• We would recommend that this gas grill should be serviced by your local gas retail outlet at least once a year by a competent engineer. Do not attempt to service this appliance yourself.
•  Any modification of the appliance may be dangerous. Do not attempt any unauthorized interference of the main controls on this gas grill, i.e. gas taps, injectors, valves etc.

WARNING: The Handle Black Area (See Above Picture for Reference) Will Become Hot When the Gas grill In Use, BE CAREFUL! Do Not Touch The Black Area.

Safety precautions

• Always test gas line for leaks at connector with soapy water after making connections.
• The top lid must always be open when lighting the burner.
• Use oven gloves and sturdy, long handled gas grill tools when cooking on the grill.
• Be prepared if an accident or fire should occur. Know where the first aid kit and fire extinguishers are and know how to use them.
• Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
• Always cook with great care.
• Do not heat any unopened glass or metal container of food on the grill. Pressure may build up and cause the container to burst, possibly resulting in serious personal injury or damage to the grill.

Lighting instructions

Caution: The lid must be open when lighting the burner!

Do not stand with your face directly over the gas grill when lighting it. Your gas grill will have following method of ignition:

Pilot Gas Control lgnition(Main burner or main burner with side burner or main burner with side burner and bac k burner ):

With all gas controls on the Gas grill in the ‘OFF” position”• OFF”, tum the gas cylinder valve to the on position at the regulator. To create a spark you must press the gas control knob (A) and hold in this position for 3-5 seconds to allow gas flow and then turn anticlockwise to” HI” (B). It can spark to the burner lighting tube (C). You will hear a ‘snap” from the igniter and you will also see a orange flame coming from the burner lighting tube at the left side of the burner (D).
Continue to hold the gas control knob in for two seconds after the ‘snap”, this will allow gas to flow completely down the burner tube (E) and insure ignition.

When the burner is alight, adjacent burners will cross light when their controls are turned to ‘HI”
At ‘HI” setting the burner flame should be approximately 12-20mm long with a minimum of orange flame. Turn the gas control knob fully anticlockwise for minimum setting.
Should you have any difficulty lighting your gas grill following the above steps, contact your dealer for advice.

If the automatic ignition can’t be used, please remove the cooking grill and heat diffuser(hotplate ), and turn the valve anticlockwise to 90° , to light with BBQ lighter in the distance of 5mm to the burner fire hole. Replace the cooking grill and heat diffuser (hotplate), please wear the fireproof and heat resisting gloves.

Warning : If the burner still does not light ,turn the gas control knob to” • OFF” and wait for 2 minutes for the unburnt gas to evaporate before lighting again .

WARNING FOR CHARCOAL GRILL

(lf included charcoal grill, please reference the following parts)
When using liquid starters always check ash catcher before lighting. Fluid can collect in the ash catcher and could ignite, resulting in a fire below the bowl. Remove any fluid from the ash catcher before lighting charcoal. Consider using non-liquid charcoal starters. Consider using non-liquid charcoal starters.
WARNING
For Your Safety
This grill has been made to high quality standards.

NOTE: The use and installation of this product must conform to local codes.

IMPORTANT NOTICE: read all instructions prior to assembly and use.
Read and understand all warnings and precautions prior to operating your grill.

CAUTION

1. This grill is for use with charcoal only.
2. Do not attempt to move the grill while it is lit.
3. Do not use the grill unless it is completely assembled and all parts are securely fastened and tightened.
4. Keep all combustible items and surfaces at least 36 inches (91.4cm) away from grill at all times.
5. DO NOT use this grill near unprotected combustible constructions.
6. Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.
7. Do not touch metal parts of grill until it has completely cooled (about 45 minutes) to avoid burns, unless you are wearing protective gear (BBQ mittens, pot holders, etc.)

WARNING

1. This grill is for outside use only, and should not be used in a building, garage or any other enclosed area.
2. The use of alcohol, prescription or non-prescription drugs may impair the operator’s ability to properly assemble or safely operate the grill.
3. Always open grill lid slowly and carefully as heat and steam trapped within the grill can burn you severely.
4. Always place your grill on a hard, level surface far away from combustibles. An asphalt or blacktop surface may not be acceptable for this purpose.
5. Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.
6. Do not place this grill on any type of tabletop surface.
7. Do not use the grill in high winds.

LIGHTING AND CONTROLLING THE FIRE

To light your grill:

1. Open lid, as well as all butterfly dampers.
2. Remove cooking grates and raise charcoal pan to its highest setting using the crank.
3. Pour 1.5kg max. of regular charcoal briquets into the charcoal pan and make into a pile.
4. Lower the charcoal pan to its the lowest setting using the crank, and light fire.
5. After charcoal is ashed over,using long-handled tongs to spread charcoal into a single layer on the charcoal pan.

PLEASE PAY ATTENTION

1.  The barbecue has to be installed on a secure level base prior to use.
2. The barbecue shall be heated up and the fuel kept red hot for at least 30 min prior to the first cooking.
3. Do not cook before the fuel has a coating of ash.
4. WARNING! This barbecue will become very hot, do not move it during operation.
5. Do not use indoors!
6. WARNING! Do not use spirit or petrol for lighting or re-lighting! Use only firelighters complying to EN 1860-3!
7. WARNING! Keep children and pets away

Storage

Your Gas Bottle must be stored outdoors in a well ventilated area and must be disconnected from your gas grill when not being used. Ensure that you are outdoors and away from any sources of ignition before attempting to disconnect your gas bottle from your gas grill. When you are using your gas grill after a period of storage, please ensure to check for gas leaks and check for any obstructions in the burner etc. before using. Also follow the cleaning instructions to ensure gas grill is safe.
If gas grill is stored outdoors ensure to check that all areas under the front panel are free from any obstructions (insects etc.) This area must be kept free as this may affect the flow of combustion or ventilation air.

Cleaning instructions

Maintenance is recommended that every 90 days for your gas grill, but it is absolutely necessary to perform maintenance at least once a year. By doing so, you will extend the life of your gas grill.
Your gas grill is easy to clean with minimum effort, just follow these helpful hints for cleaning convenience.

Trouble Shooting

Gas leaking from cracked/cut/burned hose| Damaged hose| Turn off gas at LP tank, if hoes is cut or cracked, replace hose.See LP tank lead

test and connection regulator to the LP

---|---|---
Gas| leaking| from LP tank| Mechanical mishandling| failure| due| to| resting| o1Turn off LP tank valve
!Gas leaking from LP tank.Failure or tank valve from mishandlingTurn off LP tank valve. Return LP tank to

alve                                   or mechanical failure gas supplier

Gas leaking between LP tank and regulator connection| Improper   installation, connection    notT tight, failure of rubber seal| urn off LP tank valve, remove regulator from cylinder and visually inspect rubber seal for damage, see LP tank test and

connection regulator to the LP tank

Fire coming through control panel| Fire in burner tube section of burner due to partial blockage| Turn off control knobs and LP tank valve. After fire is out and grill is cold, remove burner and inspect for spider nests or rust. see natural hazard and cleaning the burner assembly pages.
Grease fire or    continuous excessive flames above cooking surface| Too much grease buildup in burner area| Turn off LP Tank. Leave lid open to allow flames to die down. After cooling, clean food particles and excess grease from inside firebox area, grease cup/pan/tray,

and other surfaces

---|---|---
Burner will not light using ignitor| Gas issues

1. Trying to light wrong burner

2.  Burner not engaged with control valve

3.  Obstruction in burner 4.No gas flow

5. Vapor lock at coupling nut to LPtank

6.  Coupling nut ad LP tank valve not fullyc connected.

| 1.  See instructions on control panel and section in the Use and Care.

2.  Make sure valve are positioned inside of burner tubes.

3.  Ensure burner tubes are not obstructed with spider webs or other matted, see leaning section of use and care

4. Make sure LP tank is not empty. If LP tank is not empty, refer to ”sudden drop in gas flow.

5.Turn off knobs and disconnect coupling nut from LP tank.    Reconnect and retry.

6.  Turn the coupling nut approximately

one-half to three-quarters

Burner will not light using ignitor| Electrical issues:

1. Electrode cracked or broken;” sparks at crack.”

2. Electrode tip not in proper position

3. Wire and/or electrode covered with cooking residue.

4. Wires are loose or disconnected

5. Wires are shorting (sparking) between igitor and electrode.

6. push button sticks at bottom sparking between ignitor and electrode

| 1. Replace electrode.

2. Tip of electrode should be pointing toward port hole in burner. The distance should be 1/S”to 3/16″. Adjust if necessary.

3. Clean wire and or electrode with rubbing alcohol and clean swab.

4. Reconnect wires or replace electrode/wire assembly.

5. Replace ignitor wire 6.Replace ignitor

?.Inspect wire insulation and proper connection. Replace wires if insulation is

broken.

---|---|---
Burner will not mach light| See “gas issues;” on previous page. 1. See ‘Pilot Gas Control Ignition” section

2. Improper method of match-lighting      of use and care.

Sudden drop in gas flow or1 low flame| . Grease buildup.

2.  Excessive fat in meat.

3.  Excessive cooking temperature

| 1.  Clean burners and inside of grill/ firebox

2.  Trim fat from meat before grilling.

Flames blow out| High or gusting winds. Low on LP gas. Excess flow valve tripped.| Turn front of grill to face wind or increase flame height.

Refill LP tank.

Refer to “sudden drop in gas flow” above.

Persistent grease fire| Grease trapped by food buildup around burner system.| Turn knobs to OFF. Turn gas off at LP tank. Leave lid in position and let fire burn out. After grill cools, remove and clean all parts
Flashback…

(fire in burner tube(s)

| Burner and burner tubes are blocked| Turn knobs to OFF. clean burner

and/or burner tubes. See burner cleaning section of use and care manual

Flare-up| 1.   Grease buildup.

2.   Excessive fat in meat.

3.   Excessive cooking temperature

| 1.     Clean burners and inside of grill/ firebox

2.  Trim fat from meat before grilling.

3. Adjust (lower) temperature

Unable to fill LP tank| Some dealers have older fill nozzles with worn threads.| Turn worn nozzles don’t have enough ‘bite”to engage the valve. Try a second LP

dealer.

One burner does not light from other burner(s)| Grease buildup or food particles in end ofC carryover tube| lean carry-over tube with wire brush

If your problem is not resolved from the information above, please Contact your local gas dealer.

• Turn the burner on for 15 to 20 minutes. Ensure appliance is cold before continuing.
• Grids should be cleaned periodically by soaking and washing in soapy water.
• The interior surfaces of the grill housing cover should also be washed with hot, soapy water. Use a wire brush, steel wool or a scouring pad to remove stubborn spots.
•  Periodically check the burner to see that it is free from insects and spiders which may clog the gas system, deflecting gas flow. Ensure to clean venturi pipes on burner very carefully, make sure that there are no obstructions. We recommend that you use a pipe cleaner to clean the venturi pipe area.
• Any modifications of this appliance may be dangerous and are not permitted.

Gas grill Safety Hints

• Stand your gas grill on a safe level surface, away from inflammable items such as wooden fences or overhanging tree branches.

• Never use your gas grill indoors!

• Once lit do not move your gas grill or leave it unattended.

• Keep children and pets at a safe distance from the gas grill.
  Keep a fire extinguisher handy.

• The gas grill will become hot when in use, so handle lids etc. with the help of gloves. Ensure that the appliance has completely cooled down before storing.

• Use outdoors only!

• Read the instructions before using the gas grill.

• Assessable parts may be very hot, Keep young children away!

• Do not move the gas grill during using.

• Turn off the gas supply at the gas container after use.

• Any modification of the appliance may be dangerous and be not permitted.

References

• Adexa Direct | UK's Leading Supplier of Catering & Kitchen Equipment

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>