FALCON RIDGE PO-RANGER400-WD05 2010 Polaris Ranger 400/500 Aero-VentLexan Windshield Instruction Manual
- June 3, 2024
- FALCON RIDGE
Table of Contents
2515 Bypass Rd. Flemingsburg, KY 41041
606-845-7439
Instructions for Installation and Care of
2010 Polaris Ranger 400/500
Aero-VentLexan Windshield
PO-RANGER400-WD05
Instruction Manual
PO-RANGER400-WD05 2010 Polaris Ranger 400/500 Aero-VentLexan Windshield
NOTICE: Please check the contents of the package for any damage and make sure all parts fit correctly and you are happy with the product before removing the protective film. Once the film is removed you cannot return the product for a full refund.
- Be sure to read these instructions thoroughly before opening and installing the 09” Polaris Ranger Lexan Windshield.
- Check over the parts included in the cartons with the parts list shown below:
1 ¾” Loom Clamps
1” Stainless sheets of steel Bolts
Stainless Steel Washers
Slide Fasteners
Plastic Thumb Nuts
Sliding Vent Panels
Rubber Gasket
Lexan Windshield
Lock Nuts| 10 each
16 each
22 each
8 each
12 each
2 each
2- 48”
2 Pieces
4 Each
---|---
Start by pulling it out of the box and find a clean area to lay it down and install the hardware. Next, take the rubber gasket and starting at one end firmly place it along the entire bottom and top edges of the lower Windshield Section. You will need to peel back the protective film from the edge to install the gasket. If you leave the bulk of the protective film on while installing you can keep from scratching the windshield.
-
Next, Install the Aero-Vent sliders as shown in the diagram below.
| 
---|--- -
Now you are ready to place the windshield on the Ranger and attach it to the roll cage. NOTE: THE BEND AT THE TOP OF THE WINDSHIELD SHOULD GO BELOW THE TOP TUBE. The diagram on the next page shows the proper placement of the hardware. Install the clamps as shown for the top two slots in the windshield only. Use the 1” bolts for this application.
-
Now Place the two halves onto the frame as shown below. (diagram not Ranger)
-
Now you are ready to take it out and enjoy. To clean the windshield, always clean using a liquid of some sort to decrease the chance of scratches. We recommend using microfiber cloths that are readily available at any dollar store. Any window cleaner will work fine; just remember to use a soft clean rag or micro-fiber cloth to clean it
Falcon Ridge
2515 Bypass Rd, Flemingsburg, KY 41041 Phone:
606-845-7439 or
606-748-5136
If for any reason you choose to return this product it must be returned within
30 days from the date the item is received. you must package the product
exactly as it was originally packaged from the factory to get a full refund
for the product! The vinyl windows should never be folded when packaging in
the box or for storage purposes. Lay all the windows on top of each other with
the canvas folded in between and the paper (if available) on both sides of the
windows.
All returned products will be inspected upon arrival at the production
facility and must be in unused, factory-new condition to receive a refund – a
20% restocking fee will apply.
If ordered from Falcon Ridge please call at
606-845-7439 to gain a return
authorization number, use our preferred shipping carrier (UPS) to return the
item (unless the item is defective, you are responsible for paying the
shipping to return the item.) Any returns submitted to Falcon Ridge without a
return authorization number will be charged a 20% restocking fee. If ordered
from one of Falcon Ridge’s many distributors, you must first call them and see
what their return policy is. Once your item reaches our production facility,
our customer satisfaction team will inspect your item to ensure unused,
factory-new condition.
NOTE: All Lexan windshields must be returned with the original protective
film intact and not removed. Do NOT REMOVE if you have any intentions of
returning the item. Refund/ replacement on Lexan windshields will only be
processed on items with original protective film or if the windshield is
defective.
Items must be properly packaged in the original shipping carton to protect
them during transit and ensure your returned item arrives back factory fresh,
and in new resalable condition (any returned items that have been used,
altered or damaged in any way will not be subject to a refund.) All contents
including instruction manuals, accessories, hardware, Velcro, etc. must be
included in your return shipment. Only items in OEM factory new condition will
be approved. Once returned items are received, a credit will be issued to the
original credit card/ payment method used for the purchase. Outbound shipping
and return shipping costs will not be refunded. Please allow 4 to 6 weeks for
your refund to be processed.
To The Owner of this Product:
Thank you for purchasing one of Falcon Ridges Enclosure &/or Windshields!
Below are the terms under which your product is covered under our
manufacturer’s warranty.
30-Day Warranty which includes and is not limited to replacing the enclosure
and/or windshield due to defect of the product. Please refer to the return
policy in this case for more information. 1 Year Warranty includes any defect
in material or workmanship within this time frame we will gladly correct the
problem or replace the enclosure &/or windshield. Upon submitting for the
correction or replacement we will need to receive pictures of the defect in
material or workmanship along with the receipt from the date of purchase.
Thank you,
Falcon Ridge
Documents / Resources
|
FALCON RIDGE PO-RANGER400-WD05 2010 Polaris Ranger 400/500 Aero-VentLexan
Windshield
[pdf] Instruction Manual
PO-RANGER400-WD05 2010 Polaris Ranger 400 500 Aero-VentLexan Windshield, PO-
RANGER400-WD05, 2010 Polaris Ranger, 400 Aero-VentLexan Windshield, 500 Aero-
VentLexan Windshield, Aero-VentLexan Windshield, Windshield
---|---
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>