FALCON RIDGE AC-PRO-RW02 Care of Full Polycarbonate Rear Window Instruction Manual
- June 3, 2024
- FALCON RIDGE
Table of Contents
AC-PRO-RW02 Care of Full Polycarbonate Rear Window
Instruction Manual
AC-PRO-RW02 Care of Full Polycarbonate Rear Window
2515 Bypass Rd. Flemingsburg, KY 41041
606-845-7439
Instructions for Installation and Care of Full Polycarbonate Rear Window AC-
PRO-RW02
NOTICE: Please check the contents of the package for any damage and make
sure all parts fit correctly and you are happy with the product before
removing the protective film. Once the film is removed you cannot return the
product for a full refund.
-
Check over the parts included in the cartons with the parts list shown below:
1″ Stainless Bolts………….. 7 each
Small Washers………………. 7 each
Thumb Nuts……………………………. 7 each
Large Metal Brackets…………………….. 4 each
Small Metal Brackets……………………… 3 each
150″ Side Bulb Gasket………………………. 1 each
Rear Window…………………… 1 each
If any parts are damaged or missing please contact customer service at 606-845-7439. -
Start by pulling it out of the box; find a clean area to lay it down and install the hardware. Next, take the rubber gasket and starting at one end firmly place it along the entire outer edge of the rear window. You will need to peel back the protective film from the edge to install the gasket. If you leave the bulk of the protective film on while installing you can avoid scratching the windshield. Ensure that the gasket is seated fully home on along the edge to insure a good fit of the windshield.
-
Once the gasket is in place install the three small brackets along the bottom of the Rear Window. Place the bracket on the inside or bulb side of the Rear Window so that the bent part of the bracket faces toward the bottom as shown in the photo below. Don’t fully tighten it down yet.
-
Next, place the Rear window on the frame of the Prowler and hook the brackets on the bottom of the frame as shown in the photo below. You will need to get someone else to hold the Rear Window in place in order to install the remaining brackets.
-
Now install the rest of the large brackets across the top and down the sides of the Rear Window. They are made to grab hold of the frame and pull the window tightly against the frame as shown in the photos below.
-
Enjoy, and remember- when cleaning the rear window do so gently at first with warm water and mild detergent to dislodge any grit that may scratch the Polycarbonate. After rinsing and drying with a soft cloth, you may then polish the windshield with an appropriate commercially available plastic polish, also available from Falcon Ridge. This will ensure many seasons of clarity and keep scratching and swirling to a minimum. Never use cleaners such as Windex that contain ammonia as doing so may adversely affect the rear window.
Thank you for your purchase!
Return Policy
If for any reason you choose to return this product it must be returned within
30 days from the date the item is received. You MUST package the product
exactly as it was originally packaged from the factory to get a full refund
for the product!
The vinyl windows should never be folded when packaging in the box or for
storage purposes. Lay all the windows on top of each other with the canvas
folded in between and the paper (if available) on both sides of the windows.
All returned products will be inspected upon arrival at the production
facility and must be in unused, factory-new condition to receive a refund – a
25% restocking fee will apply.
If ordered from Falcon Ridge please call at
606-845-7439 to gain a return
authorization number, use our preferred shipping carrier (UPS) to return the
item (unless the item is defective, you are responsible for paying the
shipping to return the item.) Any returns submitted to Falcon Ridge without a
return authorization number will be charged a 20% restocking fee. If ordered
from one of Falcon Ridge’s many distributors’, you must first call them and
see what their return policy is. Once your item reaches our production
facility, our customer satisfaction team will inspect your item to ensure
unused, factory-new condition.
NOTE: All windshields must be returned with the original protective film
intact and not removed. Do NOT REMOVE if you have any intentions of returning
the item. Refund/ replacement of a windshield will only be processed on items
with original protective film or if the windshield is defective.
Items must be properly packaged in the original shipping carton to protect
them during transit and ensure your returned item arrives back factory fresh,
and in new resalable condition (any returned items that have been used,
altered or damaged in any way will not be subject for a refund.) All contents
including instruction manuals, accessories, hardware, Velcro, etc. must be
included in your return shipment. Only items in OEM factory new condition will
be approved. Once returned items are received, a credit will be issued to the
original credit card/ payment method used for the purchase. Outbound shipping
and return shipping costs will not be refunded. Please allow 4 to 6 weeks for
your refund to be processed.
Warranty
To The Owner of this Product:
Thank you for purchasing one of our Falcon Ridge Cab Enclosures, Tops &/or
Windshields! Below are the terms under which your product is covered under our
manufacturer’s warranty.
30 Day Warranty which includes and is not limited to replacing the enclosure,
tops, and/or windshield due to defects in the product. Please refer to the
return policy in this case for more information.
1 Year Warranty includes any defect in material or workmanship within this
time frame we will gladly correct the problem or replace the enclosure, tops
&/or windshield. Upon submitting for the correction or replacement we will
need to receive pictures of the defect in material or workmanship along with
the receipt from the date of purchase.
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>