FALCON RIDGE MS-500-RW01 Massimo 500 Soft Rear Window Instruction Manual
- October 27, 2023
- FALCON RIDGE
Table of Contents
FALCON RIDGE MS-500-RW01 Massimo 500 Soft Rear Window
INSTALLATION INSTRUCTION
Notice: Do not smoke inside the cab or expose the enclosure to direct flames. Cab is Flammable.
- Be sure to read these instructions thoroughly before opening and installing the Kawasaki Teryx 4Top Cap. The installation is best done when the temperature is 70 degrees F. or warmer. The temperature affects the adhesive Velcro, if conditions prevent installing in warmer weather it helps to store the adhesive Velcro at room temp. Prior to installation.
- Carefully open the carton and remove the rolled up Top Cap on a large flat surface that is clean and free of dirt.
- Check over the parts included in the carton with the parts list shown below:
- Adhesive Hook strips 7 each 6” long
- Webbing straps with Velcro 4 each
- Webbing straps with Grommet 2 each
- Top Cap 1 each
- Place the Top Cap over the roll cage of the Teryx 4. Down the front and rear of the roll cage you must wrap the bar with one of the adhesive hook strips roughly 6-10” from where the top is. Wrap the double-sided Velcro sewn to the ends of the webbing straps around the adhesive hook strips so that the webbing strap is pointing up towards the top.
- Next, take the straps and lace them through the buckles sewn to the corners of the Top Cap as shown in the diagram below.
- Next wrap the roll cage with the Double-Sided Velcro strip with snap around the middle bar to match up with the snap on the Top Cap. Install the double-sided Velcro with snap the same as above. Then snap the two together as shown in the photos below.
Cleaning and Storage Recommendations:
- Before removing the Falcon Ridge Cab for storage, make sure it is very clean in order to prevent scratching of the window panels. Clean with a soft rag or sponge using a mild liquid detergent soap and warm water solution. Never rub the windows with a dry cloth or rag! Let the Cab dry thoroughly before attempting to roll for storage.
- It is important that the Cab be rolled up for storage rather than folding. Folding will cause damage to the windows!!! Carefully roll up the Cab similar to the way it was when it was packed at the factory On a large, clean and flat surface, fold the doors over the rear panel first, then, interleave the top and windshield on top of the doors. Begin rolling the Cab into a roll approximately 8 inches in diameter. Put the rolled Cab back into the carton for storage at a normal room temperature. It is best not to expose the Cab to either extreme hot or cold temperatures when storing.
- A special cleaner conditioner is available from Falcon Ridge that will greatly increase the service life of the Cab Enclosure. In addition, if additional hook and loop sets are needed, they can also be ordered.
Return Policy
If for any reason you choose to return this product it must be returned within
30 days from date item is received. You MUST package the product exactly as it
was originally packaged from the factory to get a full refund for the product!
The vinyl windows should never be folded when packaging in the box or for
storage purposes. Lay all the windows on top of each other with the canvas
folded in between and the paper (if available) on both sides of the windows.
All returned products will be inspected upon arrival at the production
facility and must be in unused, factory new condition to receive refund – a
25% restocking fee will apply. If ordered from Falcon Ridge please call at
606-845-7439 to gain a return authorization number, use our preferred shipping
carrier (UPS) to return the item (unless the item is defective, you are
responsible for paying the shipping to return the item.) Any returns submitted
to Falcon Ridge without a return authorization number will be charged a 20%
restocking fee. If ordered from one of Falcon Ridge’s many distributors, you
must first call them and see what their return policy is. Once your item
reaches our production facility, our customer satisfaction team will inspect
your item to ensure unused, factory new condition. NOTE: All windshields must
be returned with the original protective film intact and not removed. Do NOT
REMOVE if you have any intentions of returning the item. Refund/ replacement
of a windshield will only be processed on items with original protective film
or if the windshield is defective.
Items must be properly packaged in the original shipping carton to protect
them during transit and ensure your returned item arrives back factory fresh,
and in new resalable condition (any returned items that have been used,
altered or damaged in any way will not be subject for a refund.) All contents
including instruction manuals, accessories, hardware, Velcro, etc. must be
included in your return shipment. Only items in OEM factory new condition will
be approved. Once returned items are received, credit will be issued to the
original credit card/ payment method used for the purchase. Outbound shipping
and return shipping cost will not be refunded. Please allow 4 to 6 weeks for
your refund to be processed.
Warranty
To The Owner of this Product:
Thank you for purchasing one of our Falcon Ridge Cab Enclosures, Tops &/or
Windshields! Below are the terms under which your product is covered under our
manufacturer’s warranty. 30 Day Warranty which includes and is not limited to
replacing the enclosure, tops and/or windshield due to defects of the product.
Please refer to the return policy in this case for more information.
1 Year Warranty includes any defect in material or workmanship within this
time frame we will gladly correct the problem or replace the enclosure, tops
&/or windshield. Upon submitting for the correction or replacement we will
need to receive pictures of the defect in material or workmanship along with
the receipt from the date of purchase.