FALCON RIDGE JD-835-RW01 John Deere XUV 835 Soft Rear Window Instruction Manual
- June 3, 2024
- FALCON RIDGE
Table of Contents
FALCON RIDGE JD-835-RW01 John Deere XUV 835 Soft Rear Window
Notice: Do not smoke inside the cab or expose the enclosure to direct flames. The cab is Flammable.
-
Be sure to read these instructions thoroughly before opening and installing the John Deere 835 Soft Rear Window. The installation is best done when the temperature is 70 degrees F. or warmer. This is to allow the Velcro to stick to the roll cage better, if you must install it outside in the cold it will help to warm the Velcro inside at room temp. until ready to install.
-
Check over the parts included in the carton with the parts list shown below:
Velcro Hook strips:
Soft Rear Window- 2″ Adhesive Velcro Strips 1 each 44″
- 2 each 45″
- 1 each 36″
-
Begin by placing the 44″ adhesive Velcro strip on top of the of the rear horizontal bar along the back edge. Make sure it is centered properly. See photo below.
-
Next place the 45″ strip on the rear vertical bar. It should be placed on the outside of the bars along the back edge. See photo below.
-
Last piece of adhesive Velcro goes at the bottom of the Rear Window along the plastic piece. Place the 36″ strip centered on the plastic piece facing towards the rear of the vehicle. See photo below
-
Now that all the Adhesive Velcro is in place you can start putting on the Rear Window. Be sure to Center the Rear Window and attach the top along the 44″ adhesive Velcro strip as shown in the photo below.
-
Now attach both sides of the Rear Window to the adhesive Velcro strips down the outside of the rear corner bars as shown in the photo below.
-
Then just push the bottom of the Rear Window against the Velcro strip across the bottom as shown in the photo below.
Cleaning and Storage Recommendations
- Before removing the Falcon Ridge Cab for storage, make sure it is very clean in order to prevent scratching of the window panels. Clean with a soft rag or sponge using a mild liquid detergent soap and warm water solution. Never rub the windows with a dry cloth or rag! Let the Cab dry thoroughly before attempting to roll for storage.
- It is important that the Cab be rolled up for storage rather than folding. Folding will causedamage to the windows!!! Carefully roll up the Cab similar to the way it was when it was packed at the factory On a large, clean and flat surface, fold the doors over the rear panel first, then, interleave the top and windshield on top of the doors. Begin rolling the Cab into a roll approximately 8 inches in diameter. Put the rolled Cab back into the carton for storage at anormal room temperature. It is best not to expose the Cab to either extreme hot or cold temperatures when storing.
- A special cleaner conditioner is available from Falcon Ridge that will greatly increase the service life of the Cab Enclosure. In addition, if additional hook and loop sets are needed, they can also be ordered.
Return Policy
If for any reason you choose to return this product it must be returned within 30 days from date item is received. You MUST package the product exactly as it was originally packaged from the factory to get a full refund for the product! The vinyl windows should never be folded when packaging in the box or for storage purposes. Lay all the windows on top of each other with the canvas folded in between and the paper (if available) on both sides of the windows. All returned products will be inspected upon arrival at the production facility and must be in unused, factory new condition to receive refund – a 25% restocking fee will apply. If ordered from Falcon Ridge please call at 606-845-7439 to gain a return authorization number, use our preferred shipping carrier (UPS) to return the item (unless the item is defective, you are responsible for paying the shipping to return the item.) Any returns submitted to Falcon Ridge without a return authorization number will be charged a 20% restocking fee. If ordered from one of Falcon Ridge’s many distributors, you must first call them and see what their return policy is. Once your item reaches our production facility, our customer satisfaction team will inspect your item to ensure unused, factory new condition. NOTE: All windshields must be returned with the original protective film intact and not removed. Do NOT REMOVE if you have any intentions of returning the item. Refund/ replacement of a windshield will only be processed on items with original protective film or if the windshield is defective. Items must be properly packaged in the original shipping carton to protect them during transit and ensure your returned item arrives back factory fresh, and in new resalable condition (any returned items that have been used, altered or damaged in any way will not be subject for a refund.) All contents including instruction manuals, accessories, hardware, Velcro, etc. must be included in your return shipment. Only items in OEM factory new condition will be approved. Once returned items are received, credit will be issued to the original credit card/ payment method used for the purchase. Outbound shipping and return shipping cost will not be refunded. Please allow 4 to 6 weeks for your refund to be processed.
Warranty
To The Owner of this Product:
Thank you for purchasing one of our Falcon Ridge Cab Enclosures, Tops &/or
Windshields! Below are the terms under which your product is covered under our
manufacturer’s warranty. 30 Day Warranty which includes and is not limited to
replacing the enclosure, tops and/or windshield due to defect of the product.
Please refer to the return policy in this case for more information. 1 Year
Warranty includes any defect in material or workmanship within this time frame
we will gladly correct the problem or replace the enclosure, tops &/or
windshield. Upon submitting for the correction or replacement we will need to
receive pictures of the defect in material or workmanship along with the
receipt from the date of purchase.
Thank you,
Falcon Ridge
www.overarmouroffroad.com
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>