Polaris General 1000 Falcon Ridge Cab Instruction Manual

Polaris General 1000 Falcon Ridge Cab

NOTICE: Please check the contents of the package for any damage and make sure all parts fit correctly and you are happy with the product before removing the protective film. Once the film is removed you cannot return the product for a full refund.

1. Check over the parts included in the cartons with the parts list shown below:
   Metal Brackets 2 each
   2″ Stainless Bolts 2 each
   1″ Stainless Bolts 2 each
   Large Stainless Washers 2 each
   Large Rubber Washers 2 each
   Small Washers 2 each
   Thumb Nuts 4 each
   92″ Small Side Bulb Gasket 1 each
   Rear Window 1 each

2. Start by pulling it out of the box; find a clean area to lay it down and install the hardware. Next, take the rubber gasket and starting at one end firmly place it along the sides and top edges of the rear window. You will need to peel back the protective film from the edge to install the gasket. If you leave the bulk of the protective film on while installing you can avoid scratching the windshield. Ensure that the gasket is seated fully home on along the edge to ensure a good fit of the windshield.

3. Begin attaching the two top bolts on the Rear Window. Use the 2″ bolts along with the large stainless and rubber washers as well as a thumb nut. Run the bolt with the washer through the large hole in the top rear corner of the vehicle frame and into the hole of the Rear Window. Then put the thumb nut on the bolt and tighten it. See photos below

4. Next, take the Metal brackets and bolt them to the Rear Window from the inside using the supplied 1″ bolts washer and thumbnut as shown in the picture below.

5. Enjoy, and remember- when cleaning the rear window do so gently at first with warm water and mild detergent to dislodge any grit that may scratch the Polycarbonate. After rinsing and drying with a soft cloth, you may then polish the windshield with an appropriate commercially available plastic polish, also available from Falcon Ridge. This will ensure many seasons of clarity and keep scratching and swirling to a minimum. Never use cleaners such as Windex that contain ammonia as doing so may adversely affect the rear window.

Thank You for your purchase!

If for any reason you choose to return this product it must be returned within 30 days from the date the item is received. You MUST package the product exactly as it was originally packaged from the factory to get a full refund for the product! The vinyl windows should never be folded when packaging in the box or for storage purposes. Lay all the windows on top of each other with the canvas folded in between and the paper (if available) on both sides of the windows. All returned products will be inspected upon arrival at the production facility and must be in unused, factory-new condition to receive a refund – a 25% restocking fee will apply. If ordered from Falcon Ridge please call 606-845-7439 to gain a return authorization number, use our preferred shipping carrier (UPS) to return the item (unless the item is defective, you are responsible for paying the shipping to return the item.) Any returns submitted to Falcon Ridge without a return authorization number will be charged a 20% restocking fee. If ordered from one of Falcon Ridge’s many distributors, you must first call them and see what their return policy is. Once your item reaches our production facility, our customer satisfaction team will inspect your item to ensure unused, factory-new condition. NOTE: All windshields must be returned with the original protective film intact and not removed. Do NOT REMOVE it if you have any intentions of returning the item. Refund/ replacement of a windshield will only be processed on items with original protective film or if the windshield is defective. Items must be properly packaged in the original shipping carton to protect them during transit and ensure your returned item arrives back factory fresh, and in new resalable condition (any returned items that have been used, altered, or damaged in any way will not be subject for a refund.) All contents including instruction manuals, accessories, hardware, Velcro, etc. must be included in your return shipment. Only items in OEM factory new condition will be approved. Once returned items are received, the credit will be issued to the original credit card/ payment method used for the purchase. Outbound shipping and return shipping costs will not be refunded. Please allow 4 to 6 weeks for your refund to be processed.

Warranty

To The Owner of this Product:
Thank you for purchasing one of Falcon Ridge’s Cab Enclosures, Tops &/or Windshields! Below are the terms under which your product is covered under our manufacturer’s warranty. 30 Day Warranty which includes and is not limited to replacing the enclosure, tops, and/or windshield due to defects of the product. Please refer to the return policy in this case for more information. 1 Year Warranty includes any defect in material or workmanship within this time frame we will gladly correct the problem or replace the enclosure, tops &/or windshield. Upon submitting for the correction or replacement we will need to receive pictures of the defect in material or workmanship along with the receipt from the date of purchase.

• Thank you,
• Falcon Ridge

Documents / Resources

| FALCON RIDGE Polaris General 1000 Falcon Ridge Cab [pdf] Instruction Manual
Polaris General 1000 Falcon Ridge Cab, 1000 Falcon Ridge Cab, Polaris General Ridge Cab, Ridge Cab, Cab
---|---

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>