AquaOne CBG-500 CBG Series Hang On Back Filter Instruction Manual

AquaOne CBG-500 CBG Series Hang On Back Filter

Product Information

Specifications

• Model: CBG-500
• Volt: 220-240V/50Hz
• Power: 5W UV
• Flow Rate: 500L/h (132GPH)
• Recommended Tank Size: 38-115L
• Dimensions: 192×110.5x165mm

Product Using Instructions

Safety Instructions

1. Electrical installations must meet national regulations.
2. The unit may only be connected when the electrical data of the unit and the power supply match.
3. Do not expose the filter to water or moisture.
4. Do not operate the filter with wet hands.
5. Keep children away from the filter and do not allow them to use it without adult supervision.

Startup

1. Before using the filter, read the manual carefully.
2. Ensure that the electrical connections are properly made according to the national regulations.
3. Place the filter on the back of the aquarium, ensuring it is securely attached.
4. Connect the power cord to a suitable power outlet.
5. Adjust the water flow rate using the side regulator. If the
   skimmer is producing too much air, reduce the flow rate.

Maintenance / Cleaning

Regularly clean or replace the filter media to maintain optimal performance. Turn off and unplug the filter before performing any maintenance.

1. Remove the filter basket and discard the used filter media.
2. Rinse the filter basket, impeller, and other parts with clean water to remove debris.
3. Reassemble the filter with new filter media and place it back onto the aquarium.

Troubleshooting

• Problem: Filter does not pump water.
  • Cause: Power is not connected.
  • Solution: Connect the power cord to a suitable power outlet.
  • Cause: Impeller is blocked.
  • Solution: Clean the impeller.
  • Cause: Defective pump.
  • Solution: Replace the pump.
• Problem: Loud noise from the pump.
  • Cause: Blocked or defective impeller.
  • Solution: Clean or replace the impeller.
• Problem: Low water flow rate.
  • Cause: Dirty filter media.
  • Solution: Clean or replace the filter media.
  • Cause: Dirty inlet.
  • Solution: Clean the inlet cover.

FAQ

• Q: How often should I clean the filter media?
  • A: It is recommended to clean or replace the filter media every 2-4 weeks, depending on the aquarium’s bio-load.
• Q: Can I use the filter in saltwater aquariums?
  • A: Yes, the filter can be used in both freshwater and saltwater aquariums.
• Q: How long is the warranty period for the filter?
  • A: The warranty period is 2 years from the invoice date. Please note that the warranty does not cover wearing parts or damage caused by improper use.

Thank you for choosing AquaOne CBG series of hang on back filter. Please read the manual before you use the filter. Do not let children use the filter without adult supervision. Please keep the manual for future reference.

This marking indicates that this product should not be disposed with other household wastes throughout the EU. To prevent possible harm to the environment or human health from uncontrolled waste disposal, recycle it responsibly to promote the sustainable reuse of material resources. To return your used device, please use the return and collection systems or contact the retailer where the product was purchased. They can take this product for environmental safe recycling.

Warranty

• The guarantee period is 2 years, valid from the invoice date.
• The wearing parts of the filter are not covered by the warranty.
• The damage caused by improper use is excluded from the warranty.

Usage

This filter includes a UV sterilizer (except CBG-500S/800S), which helps reduce floating algae and bacteria in the aquarium. Please do not expose the UV light to your skin or eyes. Do not use the UV sterilizer if the outer case is broken, and avoid using the filter for other purposes than in the aquarium. The filter uses biological and mechanical filtration to clean the aquarium water. Please pay attention to the following:Use in water temperature between 4·c to 35″C (39F to 95F).

1. Use in aquarium only.
2.  Must comply with technical data.
3.  Do not use with liquids other than water.
4.  Do not run dry.
5.  it is prohibited for commercial or industrial purposes.
6.  it is prohibited to use together with chemicals, food, inflammable and explosive articles.

Safety instructions

1. Electrical installations must meet the national regulations.
2.  The unit may only be connected when the electrical data of the unit and power supply meet.
3. Never operate the unit if either the electrical cables or the housing are defective.
4. Do not carry or pull the unit by its electrical cable.
5. Never open the unit housing or its attendant components, unless this is explicitly required in the operating instruction.
6. Only use original spare parts and accessories for the unit.

Instructions

1. Take out the filter from the packaging, wash the filter pads, carbons and ceramic balls.
2. Put the telescopic tube and intake cover into the intake tube.
3. Put the filter pads, carbons and ceramic balls into the filter body (fig 3-1).
4. • Adjust the filter to glass holder so the filter is level (fig3-2).
5. Fill the filter body with tank water before usage. Plug in the power.
6. Adjust the water flow dial to limit the water intake. The dial on the side can adjust the intake for the surface skimmer. Please turn down the surface skimmer if you surface skimmer is sucking in too much air.
7. UV sterilizer can be turn on and off if needed.

Cleaning and changing part

1. Unplug the power, and pour out the water.
2.  Pull out the motor from the filter body.
3. Clean the impeller and change the UV bulb if necessary.
4.  Take out the quartz tube, and clean the surface.
5. Check the quartz tube and O-ring are in good condition. Change if necessary.
6. Put everything back together.

Replacement parts

1. UV bulb (suggest changing after 8000 hours of usage)
2. Filter pads and media
3. O-ring

Troubleshooting

Dirty Water

| 1.     Beneficial bacteria not establish in the new filter.

2.    Not the right size.

3.    Too many livestock

4.    Dirty filter pads

5.    Dirty quartz tube

6.    Water extremely dirty

| 1. Dose some bacteria into the filter and tank. (Learn more about Nitrogen Cycle in Aquarium Online).
2.Upgrade to a larger filter.3.    For reference only: 1 inch of fish per gallon of tank water.4. Clean the filter pads.

5. Clean the quartz tube.

6. Do 50% water change.

UV Light Not On

| 1.  Filter not plug into power.

2.  UV bulb burn out.

3.  On / Off switch on Off position.

| 1.  Plug filter to power outlet.

2.  Replace 5W UV bulb.

3.  Push the switch to On position.

No Water Come Out

| 1.  No water in filter body.

2.  Filter not plug into power.

3.  lntake cover is clogged.

| 4.   Put tank water in filter body.

5.   Plug filterto power outlet.

6.     Clean intake cover

Storage

In order to prevent frost, the equipment must stop using, drain the water, clean and be checked. Then store in a dry place.

Technical parameter

Product diagram

Note: Due to the differences between models, the produc diagram only for reference. Please refer to the actual parts.

Disposal

Regulations for waste disposal:

The Waste Electrical and Electronic Equipment Directive (WEEE Directive, 2012/19/EU) of the EU was implemented in the German law related to electrical and electronic equipment and appliances.

Disposal of used electrical and electronic devices (in- intended for use in the countries of the European Union and other European countries with a separate waste collection system for these devices).
The symbol on the packaging or the product itself indicates that this product must not be treated as normal domestic waste but must be disposed of at a recycling collection station for electrical and electronic waste.

By disposing of this product correctly, you contribute to the protection of the environment and the health of your fellow people. Inappropriate disposal threatens the environment and health.
Material recycling helps to reduce the consumption of raw materials. Additional information about the recycling of this product can be provided by your local commune, the municipal waste disposal facilities, or the store where you purchased the product.

www.aquaristikwelt24.de

References

• aquaristikwelt24
• aquaristikwelt24

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>