Char-Griller 2190 Legacy Charcoal Grill Owner’s Manual

Char-Griller 2190 Legacy Charcoal Grill

Keep your receipt with this manual for Warranty. CUSTOMER SERVICE 1-912-638-4724 Service@CharGriller.comContents of this manual are Trademarked and Copyrighted by Char-Griller | A&J Manufacturing. Using the information contained in this manual without consent of Char-Griller and/or A&J Manufacturing is strictly prohibited.

IMPORTANT SAFETY WARNINGS

READ ALL SAFETY WARNINGS AND INSTRUCTIONS CAREFULLY BEFORE ASSEMBLING AND OPERATING YOUR GRILL

Read the following instructions carefully and be sure your appliance is properly assembled, installed, and maintained. Failure to follow these instructions may result in serious bodily injury and/or property damage. If you have any questions concerning assembly or operation, call 912-638-4724.

• Grill is for use outdoors and in well-ventilated areas, only.
• Use caution when assembling and operating your grill to avoid scrapes or cuts from sharp edges.
• Do not use gasoline, kerosene, or alcohol to light charcoal. Use of any of these or similar products could cause an explosion possibly leading to severe bodily injury.
• Do not leave a lit grill unattended. Keep children and pets away from the grill at all times.
• Use caution when moving the grill to prevent strains.
• Keep the grill at least 15 feet from any combustible material (decks, buildings, fences, trees, bushes, etc).
• When adding charcoal and/or wood, use extreme caution.
• Never move the grill when it is in use or when it contains hot coals or ashes.
• Do not place the grill near flammable liquids, gases, or where flammable vapors may be present.
• Use caution since fl ames can fl are-up when fresh air suddenly comes in contact with fi re.
• When opening the lid, keep hands, face, and body safe from hot steam and fl ame fl are-ups.
• WARNING: To avoid injuries gloves or other protective articles should be used when touching the ash pan hangers.
• Do not exceed a temperature of 400°F.
• Do not allow charcoal and/ or wood to rest on the walls of the grill. Doing so will greatly reduce the life of the grill.
• Always wear oven mitts to protect your hands from burns. Avoid touching hot surfaces.
• CAUTION: Exposed metal dampers on air vents and/or metal handles are hot during usage. Again, always wear oven mitts when adjusting air fl ow to protect hands from burns.

WARNING: FUELS USED IN WOOD OR CHARCOAL BURNING APPLIANCES, AND THE PRODUCTS OF COMBUSTION OF SUCH FUELS, CAN EXPOSE YOU TO CHEMICALS INCLUDING CARBON BLACK, WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND CARBON MONOXIDE, WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. For more information go to: www.P65Warnings.ca.gov.

• When opening lid, make sure it is pushed all the way back so it rests against the lid support brackets. Use extreme caution as the hood could fall back to a closed position and cause bodily injury.
• Close the lid and all dampers to help suffocate fl ame.
• Always hold an open lid from the handle to prevent it from closing unexpectedly.
• Never leave coals and ashes unattended. Before grill can be left unattended, coals and ashes must be removed. Use caution to protect yourself and your property.
• Carefully place the remaining coals and ashes in a noncombustible metal container and saturate them completely with water. Allow coals and water to remain in a metal container 24 hours prior to disposal.
• To protect against bacteria that could cause illness, keep all meats refrigerated and thaw in the refrigerator or microwave. Keep raw meats separate from other foods, and wash everything that comes in contact with raw meat.
• Cook meat thoroughly, and refrigerate leftovers immediately.
• Use a calibrated food thermometer and the USDA guidelines to ensure that meat, poultry, seafood, and other cooked foods reach a safe minimum internal temperature.
• Always have a fi re-extinguisher nearby at all times. Maintain and check your fi re-extinguisher regularly.

THESE WARNINGS ALSO APPLY TO THE SIDE FIREBOX.

REGISTER YOUR GRILL:
To take full advantage of the Char-Griller warranty be sure to register your grill by visiting www.CharGriller.com/Register or calling Customer Service at 1-912-638-4724.
Registration provides important protections:

1. In the extremely unlikely event of a product recall, Char-Griller can easily contact you and rectify the issue.
2. If a warrantied part is broken or missing we can send you the needed parts promptly.

NOTE: You will need your model #, serial number, and a copy of the original sales receipt when registering.

Do NOT Return Product to Store.
This grill has been made according to the highest of quality standards. If you have any questions that are not addressed in this manual or if you need parts please call our Customer Service Department at 1-912-638-4724 (USA) or email Char- Griller at: Service@CharGriller.com and have your serial number handy.

Document Your Grill Model and Serial Numbers HERE:
(Model and Serial number are located on the back of the grill body or on the leg.)

WARRANTY INFORMATION

A COPY OF THE DATED PROOF OF PURCHASE (RECEIPT) IS REQUIRED WHEN REGISTERING OR SUBMITTING A WARRANTY* CLAIM. PLEASE RETAIN A COPY OF THE RECEIPT FOR YOUR RECORDS. Char-Griller will replace any defective part of its grillers/smokers, under warranty, as outlined below. PLEASE READ THIS INFORMATION IN DETAIL AND IF YOU HAVE ANY QUESTIONS CONTACT CUSTOMER SERVICE AT 912-638-4724 OR SERVICE@CHARGRILLER.COM.

Charcoal / Pellet / Kamado Grills

Grill – Hood AND Bottom (excludes removable Ash Pan)| 5 years from date of purchase for rust through / burn-through
Ash Pan AND Defective Parts| 1 year from date of purchase

Gas Grills|
Grill Hood (TOP half) AND Main Burner Tubes (excludes Side Burner)| 5 years from the date of purchase for rust-through / burn-through
Grill Body (BOTTOM half) AND Side Burner

AND Defective Parts

| 1 year from date of purchase

Dual Fuel Grills (Gas & Charcoal)|
Charcoal Grill – Hood AND Bottom AND Gas Grill Hood (TOP half) AND Main Burner Tubes (excludes Ash Pan and Side Burner)| 5 years from date of purchase for rust-through / burn-through
Ash Pan AND Defective Parts AND Gas Grill Body (BOTTOM half) AND Side Burner| 1 year from the date of purchase

Parts, Accessories, and Grill Covers| 1 year from the date of purchase (seam tears only for covers)

SURFACE RUST IS NOT CONSIDERED A MANUFACTURING OR MATERIALS DEFECT
Char-Griller grills are made of steel and if exposed to the elements rust will occur naturally. Please refer to the section entitled, “Usage” to review how to care for your grill properly. Surface issues such as scratches, dents, corrosion or discoloring by heat, abrasive and chemical clearers, surface rust or the discoloration of steel surfaces are NOT covered under these warranties. Warranties are for the replacement of defective parts only. Char-Griller is not responsible for damage resulting from accident, alteration, misuse, abuse, hostile environments, improper installation, and installation not in accordance with local codes of service of unit.

Excluded Under ALL Warranties
Paint; Surface Rust; Heat Damage; Incorrect Parts ordered by customer, including shipping; Worn Parts; Missing or damaged parts not reported within two (2) months of purchase date; Defective parts not reported within one (1) year of purchase date; Fading grill cover.

NOTE: For warranty claims, photos and prepaid return of the item in question may be required. Misuse, abuse or commercial use nullifies all warranties.

ASSEMBLY INSTRUCTIONS

PARTS LIST

Model 2190

Item| 2190

QTY

| Part Name
---|---|---
1| 1| GRILL HOOD
2| 1| WARMING RACK
3| 2| HOOD HINGES
4| 3| COOKGRATE
5| 1| CHARCOAL TRAY
6| 1| PLATE, FILLER
7| 1| GRILL BODY
8| 1| RIGHT DAMPER
9| 2| SIDE SHELF
10| 2| RIGHT SIDE SHELF BRACKET
11| 2| LEFT SIDE SHELF BRACKET
12| 2| WIRE HANDLE KNOB
13| 2| DAMPER WIRE HANDLE
14| 1| CRANK HANDLE INDICATOR SPIN
15| 1| CRANK HANDLE
16| 2| RIGHT LEG
17| 1| BOTTOM SHELF
18| 2| CASTER, 3”
19| 1| AXLE ROD
20| 2| 8” WHEEL
21| 2| HUB CAP
22| 2| LEFT LEG
23| 1| GREASE TRAY HANDLE
24| 1| GREASE TRAY
25| 1| FRONT DOOR HANDLE
26| 1| FRONT DOOR, CAST IRON
27| 1| FRONT DOOR PLATE
28| 1| FRONT DOOR PIN, HINGE
29| 1| BOTTLE OPENER
30| 1| FRONT DOOR FRAME
31| 3| UTENSIL HOOK
32| 1| LEFT DAMPER
33| 2| LOWER ARM LIFTER, CRANK
34| 1| LIFTER ARM, CRANK, ASSEMBLY
35| 1| HOOD HANDLE
36| 2| HANDLE BEZEL
37| 1| LOGO PLATE
38| 1| THERMOMETER BEZEL
39| 1| THERMOMETER
40| 1| GRIP, HANDLE, SMOKESTACK
41| 1| SMOKESTACK

HARDWARE AND TOOLS NEEDED

Assembly: Requires 2 people. Get another person to help. Tools Needed: Pliers, Phillips Head Screwdriver and a 7/16” Nut Driver.

NOTE: Do Not tighten any bolts unless instructed to do so. Tightening too soon may prohibit parts from fitting together. All Hex Nuts should be on the inside of the grill unless stated otherwise. Unpack all contents in a well- cleared and padded area.

• Estimated Assembly Time: 45 minutes
• STOP! Do Not Return to Store. If you are missing parts or need assistance please email us at Service@CharGriller.com or call 912-638-4724.

Hardware Pack: 551066

ASSEMBLY

Step 1
Attach the LEFT LEG and RIGHT LEG to GRILL BODY using eight (8) ¼-20 x ½” HEX BOLTS.

Step 2
Attach BOTTOM SHELF to LEGS using four (4) ¼-20 x ½” HEX BOLTS.

Step 3
Install one (1) FLAT WASHER, one (1) COTTER PIN, and one (1) HUB CAP onto AXLE, then slide AXLE through WHEELS and LEFT LEGS, as shown below. Finish by attaching 2nd FLAT WASHER, COTTER PIN, and HUB CAP. Attach two (2) CASTERS to RIGHT LEGS, as shown below.

Step 4
Attach two (2) ¼-20 x ½” HEX BOLTS to SIDE FIREBOX SUPPORT BRACKET.

Step 5
Attach FRONT DOOR HANDLE using one (1) ¼-20 x ½” HEX BOLT.

Step 6
Attach LEFT and RIGHT DAMPERS to GRILL BODY using eight (8) M5 SHOULDER BOLTS. Then attach a DAMPER HANDLE to DAMPER using one (1) COTTER PIN, as shown below. Repeat the process for the second DAMPER.

Step 7
Attach RIGHT SIDE SHELF BRACKET and LEFT SIDE SHELF BRACKET to SIDE SHELF using four (4) ¼-20 x ½” HEX BOLTS. Do the same with the second set.

Step 8
Loosen top two (2) ¼-20 x ½” HEX BOLTS on both sides of GRILL BODY attaching LEFT LEGS and RIGHT LEGS. Attach SIDE SHELVES onto GRILL BODY using four (4) ¼-20 x ½” HEX BOLTS, as shown below.

Step 9
Attach CRANK HANDLE to GRILL BODY using one (1) LARGE COTTER PIN.

Step 10
Attach BOTTLE OPENER to GRILL BODY using two (2) ¼-20 x ½” HEX BOLTS.

Step 11
Assemble GREASE TRAY HANDLE to GREASE TRAY using two (2) ¼-20 x ½” HEX BOLTS. Then install GREASE TRAY/HANDLE ASSEMBLY to GRILL BODY.

Step 12
Assemble HOOD HANDLE and HANDLE BEZELS to GRILL HOOD using two (2) LOCK WASHERS and two (2) WING NUTS. Then attach THERMOMETER and THERMOMETER BEZEL to GRILL HOOD. THERMOMETER inserts through BEZEL and then GRILL HOOD. Secure with FLAT WASHER and WING NUT.

Step 13
Attach SMOKESTACK to GRILL HOOD, using three (3) M5 SCREWS.

Step 14
To install the WARMING RACK fi rst attach the two (2) HEX BOLTS and two (2) HEX NUTS onto GRILL HOOD. Then position the WARMING RACK onto the HEX BOLTS and secure it with two more HEX NUTS. Insert SUPPORT ROD LEGS into designated holes located on the GRILL BODY.

Step 15
Place COOKING GRATES in GRILL BODY then attach UTENSIL HOOKS to SIDE SHELF .

Fully Assembled

Hint: The paper label that is affi xed to the hood is more easily removed when the hood is warm. Any remaining glue residue can be cleaned off with a spray lubricant like WD-40 . Do NOT use any other type of solvent or cleaner because this will damage the fi nish/paint/coating on the grill.

OPERATING INSTRUCTIONS

Setting Up
Set the grill up on a solid, flat surface with adequate wind shelter. Do not move the grill while hot, and do not leave it unattended during operation. This appliance is designed for use outdoors, away from any flammable materials. It is important that there are no overhead obstructions and that there is a minimum distance of 3 feet (90cm) from the side or rear of the appliance. It is important that the ventilation openings of the appliance are not obstructed. The barbecue must be used on a level, stable surface. The appliance should be protected from direct drafts and positioned or protected against direct penetration by any trickling water (e.g. rain).

• PLEASE NOTE: NO RETURNS ON USED GRILLS **

Seasoning and Preparing the Grill
IMPORTANT! BEFORE YOU USE YOUR GRILL FOR THE FIRST TIME YOU MUST SEASON THE CAST IRON COOKING GRATE(S).

Cure grill prior to your initial use to protect the interior and exterior finish, and cooking grates, and to prevent unnatural flavors to your first meals.

1. Lightly coat ALL INTERIOR SURFACES (including grills, grates, and inside of barrel.) with vegetable oil (spray vegetable oil is easiest but do not use near hot coals or fire).
2. Build a medium-sized fire on the fire grate. Always put charcoal on top of the fire grate and not directly into the bottom of the grill.
3. After coals ash over, spread out the coals, replace the cooking grates, close lid, and heat at approximately 250 F for two hours.
4. Remove grates from the grill with oven mitts, allow to cool, then re-coat grates and return to grill at approximately 200° F for two hours.
5. You can lightly coat the exterior of the grill body (while warm) with vegetable oil. This will extend the life of the finish, much like waxing a car. Your grill is now ready for use.

NOTE: Grill will drip oil during this process and for several uses afterwards. This is normal.

NEVER EXCEED 400°F BECAUSE THIS WILL DAMAGE THE FINISH AND CONTRIBUTE TO RUST. PAINT IS NOT WARRANTED AND WILL REQUIRE TOUCH-UP. THIS UNIT IS NOT
WARRANTED AGAINST RUST.

Lighting Instructions

1. To start a charcoal fire, stack 50-60 briquettes in a pyramid and saturate with lighter fluid.
   NOTE: Do not use gasoline, kerosene or alcohol for lighting charcoal. Use of any of these or similar products could cause an explosion possibly leading to severe bodily injury.

2. Light coals in several places

3. After briquettes ash over or turn gray, spread them out and start cooking

4. If one end burns faster, use tongs to move coals from one end to the other for even heat.

Grill Operation & Tips

• Control heat with amount and type of fuel, Dual dampers, and adjustable fire grate. Adjust the grate one end at a time. Wood burns hotter than coals. More airflow is more heat.
• To reduce flare-ups, cook with lid in the down position.
• Add water-soaked hardwood chips for a smoked flavor.
• Ashes left in the bottom too long hold moisture and will rust through any thickness of the steel. This grill is made of steel and cast iron, which WILL RUST, ESPECIALLY IF NOT PROPERLY CARED FOR.
• Do not use self-starting charcoal as it will give an unnatural flavor. Burn lighter fluid completely before closing the lid.
• After each use, coat vegetable oil on the interior grates and bare metal while warm to reduce rust
• On the EXTERIOR, remove dust with a wire brush and touch up with a high-heat paint, available at most hardware/auto stores.
• You may place a coffee can on the bottom shelf under the hole in the grill to catch drippings.
• Heat gauge may obtain moisture, which will steam out during cooking. The gauge can be removed and calibrated in the oven.
• You may fill unwanted holes with Nuts and bolts (Not Provided).

NOTE: Smoke may escape from areas other than the smokestack. This should not affect cooking.

Finishing Up

When your are finished grilling you can shut down your grill by closing both dampers and allowing the fire to suffocate. Be patient. This make take an hour or more. Emptying the Ashes & Ash Pan:

ONLY EMPTY ASHES WHILE GRILL IS NOT IS USE
After the fire is completely extinguished you should wait several hours before emptying the ashes to ensure they are not still hot and a burn hazard.

1. Knock any ashes that did not fall into the ash pan from the fire grate. (If there are pieces of partially burned charcoal on the fire grate you can save them for next time. They are still good).
2. Tap the sides of the fire bowl to knock loose any ash that is on the sides.
3. Unclip the ash pan from the bottom of the grill and slide out towards the front.
4. Give the ash pan a few firm taps to loosen any ash that may be stuck.
5. Place the ashes in a metal container and cover with water to ensure there are no lit coals then you can dispose of the ashes.

IMPORTANT: Charcoal is porous and holds moisture. DO NOT leave charcoal in your grill while you are not using it. Charcoal and ashes left inside the ash pan may reduce the life of your grill.

GRILLING RECIPES

Know Your Cuts of Meat

Direct Heat

• Direct Heat is a high-heat method used to cook foods that take less than 25 minutes to cook. Typically, this means foods that are relatively small or thin such as steaks, chops, boneless chicken breasts, fish fillets, hamburgers, etc.
• Cooking with a MEAT THERMOMETER ensures food is fully cooked. Insert into the thickest part not touching bone, and allow five minutes to register.
• Internal temperatures for FOWL should be 170°F to 180°F.
• Internal temperature for meat should be 140°F for rare, 160°F medium, and 170°F for well done.

STEAK ( & ALL MEATS):

• Cook food on the charcoal side of the unit, directly above coals/heat.
• To grill meats, raise the fire grate to a high position (hot) and sear for one minute on each side with the lid open to seal in flavor and juices. Then lower the fire grate to a medium position with the lid closed and cook to desired doneness.
• Control heat with dual dampers and an adjustable fire grate.

Tip: Place grilled meat back in the marinade for several minutes before serving – it will become tastier and juicier.

CAUTION: Boil extra marinade first to kill bacteria remaining from the raw meat.

MARINATED FLANK STEAK:

• Mix marinade ingredients in a nonmetal dish.
• Let steak stand in the marinade for no less than 4 hours in the refrigerator.
• Brown each side for 5 minutes, but the center should remain rare.
• Cut steak diagonally across the grain into thin slices before serving.
• Grill with fire grate in a high (hot) position with the lid open or closed.

Meat Marinade

• 1/2 cup vegetable or olive oil
• 1/3 cup soy sauce
• 1/4 cup red wine vinegar
• 2 tbsp lemon juice
• 1 tsp dry mustard
• 1 minced clove garlic
• 1 small minced onion
• 1/4 tsp pepper

QUAIL OR DOVES

• Cover birds in Italian dressing (Good Seasons or Kraft Zesty) and marinate overnight.
• Pour remaining dressing and cover with Texas Pete Hot Sauce for 6 hours.
• Wrap birds in thick bacon secured by a toothpick.
• Place on grill. Keep turning until the bacon is black.
• Grill for 20 minutes. Sear with lid open and fire grate in a high (hot) position for 1 minute on each side before lowering the grate and closing lid.
• To SMOKE, place birds in the center of GRID with fire in both ends of FIREBOX.

KABOBS

• Alternating on skewers any combination of meat, onions, tomatoes, green peppers, mushrooms, zucchini, circular slice of corn-on-the-cob, or pineapple. Meat could consist of chunks of shrimp, scallops, lobster, chicken, sausage, pork, beef, etc.
• Marinate the meat in the refrigerator for several hours.
• Grill each side for approximately 7 minutes turning occasionally while basting with marinade. Leave a small amount of room between pieces in order to cook faster.
• Grill with the lid up and the fire grate in the lowest position. See the marinade recipe on the last page.

Kabob Marinade:

• 1 cup soy sauce
• ½ cup brown sugar ½ cup vinegar
• ½ cup pineapple juice 2 tsp salt
• ½ tsp garlic powder
  • Mix all ingredients in a saucepan and bring to boil.
  • Allow the marinade to cool before marinating your meat in it.
  • Marinate beef in a mixture a minimum of 4 hours.

HOT DOGS

• Grill with lid up and fire grate in high (hot) position for approximately 6 minutes.
• Turn every few minutes.

HAMBURGERS:
See Meat Marinade on prior pages. You may also marinate by allowing to stand in the marinade for 1 or 2 hours at room temperature before cooking or let stand in a covered dish in the refrigerator up to 24 hours.

• Bring to room temperature before cooking.
• Mix in chopped onions, green peppers, and salt, and sear 3/4 inch patties on each side with a fire grate in a high position for a few minutes.
• Lower fire grate to medium position and grill with lid down to avoid flare-ups.
• Cook each side 3 to 7 minutes according to the desired doneness.
• Cook ground meat to 150 internally or until juice runs clear (free of blood) for prevention of E. coli.
• Burgers can be basted with marinade when turning and/or other ingredients can be mixed in with the ground beef such as chili sauce or powder.

SHRIMP (Peeled) & CRAYFISH

• Place on skewers.
• Coat with melted butter and garlic salt.
• Grill 4 minutes on each side or until pink. Cocktail sauce is optional.

BAKED POTATOES:

• Rub with butter wrap in foil and cook on the grill with the lid down for 50 minutes.
• Turn after 25 minutes (no need to turn if smoked).
• Squeeze to check for doneness.

SWEET CORN IN HUSKS

• Trim excess silk from the end and soak in cold salted water 1 hour before grilling.
• Grill for 25 minutes – turning several times.

SMOKING RECIPES

Indirect Heat

Pan is not included. A disposable bread pan is recommended. SMOKE BY COOKING SLOWLY (See chart above).

1. Place the water/drip pan on the left side of the fire grate.
2. Place hot coals on the right side (damper end) of fire grate. The charcoal basket accessory helps confine coals to one side.
3. Place meat above the water pan.
4. Place the fire grate in a low position.
5. Close the lid & control heat with dampers & adjustable grate.

• You may want to sear certain foods before smoking by placing meat directly above coals with LID open and FIRE GRATE in a high (hot) position for several minutes. Add flavor-soaked wood chips to the fire and add 1 part marinade, beer, or wine to 3 parts water to the drip pan.
• OPENING THE SMOKING CHAMBER WILL EXTEND COOKING TIME. Cooking with a meat thermometer ensures food is fully cooked. Insert the thermometer into the thickest part not touching bone, and allow five minutes to register. Internal temperature for birds should be 170°F to 180°F or when leg moves easily in the joint. Meat should be cooked to an internal temperature of 140°F for rate, 160°F for medium and 170°F for well done. Check the water level when cooking for more than 4 hours or when you can’t hear the water simmering. Add water by moving the meat over and pouring water through GRILL into WATER PAN.
• IF THE SMOKE IS WHITE, THE FIRE’S RIGHT. IF THE SMOKE IS BLACK, ADD SOME DRAFT.

SMOKED TURKEY

• Empty the cavity rinse and pat dry with a paper towel.
• Tuck wing tips under the back and tie the legs together.
• Place in the center of the cooking grid directly above foil drip pan of water.
• Smoke for 12 minutes per pound. Allow several extra minutes per pound if stuffed to allow for expansion.
• Use a meat thermometer for best results (190F internal).

SMOKED BAKED HAM:
You can smoke fully cooked canned ham or smoked and cured whole ham or shank or butt portion.

Glaze

• 1 cup of light brown sugar, firmly packed
• 1/2 cup orange juice
• 1/2 cup honey
  • Combine sugar, juice, and honey. Let the glaze sit for at least 4 hours.
  • Place the fire grate in the lowest position and a drip pan under the meat.
  • Remove the rind and score fat diagonally to give a diamond effect.
  • Insert a whole clove into the center of every diamond.
  • Place ham with fat side up in the center of the cooking grid directly above the drip pan. Close lid.
  • About 9 minutes per pound is suggested for fully cooked hams. Smoked or cured ham, which is not fully cooked, should be cooked to an internal temperature of 160°F.
• Baste with ham glaze 3 or 4 times during the last 30 minutes of cooking time.
• Garnish with pineapple rings about 15 minutes before the end of cooking time.

SMOKED HOT DOGS STUFFED

• Slit hot dogs lengthwise, within 1/4 inch of each end.
• Stuff hot dogs with cheese and relish and wrap in bacon.
• Place on cooking grid over drip pan and smoke 15-20 minutes or until bacon is crisp.

SMOKED CHICKEN PARTS AND HALVES:

• Rinse pieces in cold water and pat dry with paper towels.
• Brush each piece with vegetable oil and season to taste with salt and pepper.
• Brown pieces directly above coals with the lid open and grate in a high or medium position for several minutes.
• Then place pieces on the cooking grate directly above the drip pan.
• With the grate in the low position, cook with the lid down for 55 to 60 minutes or until done. Do not use vegetable oil or salt and pepper if using marinade.

SMOKED VENISON:

Venison Marinade:

• 1 cup Balsamic or wine vinegar 1 cup olive oil
• 2 oz. Worcestershire
• 1/2 oz. Tabasco
• 2 tbsp. Season All
• 1-2 chopped jalapenos
• 3 oz. soy sauce

Bacon Marinade

• 2 oz. wine vinegar
• 2 oz. Worcestershire
• 4 dashes Tabasco
  • Place the leg of venison in a container or “hefty bag” and marinate for 2-4 days, turning daily. Marinate bacon overnight in its marinade.
  • Remove the roast from the refrigerator for at least an hour before cooking.
  • Season generously with seasoned salt and coarse ground black pepper.
  • Wrap 1 lb. Bacon over the top of the roast, and smoke 20/25 minutes per pound, or until tender. Do not overcook.

SMOKED SHRIMP & CRAYFISH

• Mix in a foil pan 1/2 cup butter, two cloves of crushed garlic, Tabasco, sliced green pepper, 1 tablespoon each of minced onions, salt, and juices from one lemon.
• Add shrimp and/ or crayfish and smoke for 45 minutes.

SMOKED VEGETABLES

•  Turnips, potatoes, carrots, okra, mushrooms, peeled onions, zucchini, squash, etc.
   Put in pan cover with water and cook for several hours while cooking the meat. Place vegetables on the grill and smoke for 50 minutes, either wrapped in foil or not.

SMOKED FISH

• Marinate in brine (1/4 cup dissolved in 1 qt of water) or marinate fish in 1 cup white wine, 1 cup soy sauce mixed with 1 cup lemon juice.
• Marinate overnight in a covered dish in the refrigerator.
• Let air on rack 20 minutes before placing on Pam-sprayed grill.
• Smoke for 25 minutes.

SMOKED SPARE/BACK RIBS:

• Peel off a tough layer of skin on the backside.
• Rub all surfaces with seasoning.
• Place ribs in the center of the grid above the drip pan and smoke for approximately 1 1/2 hours or until meat pulls away from the bone.
• Baste with barbecue sauce during the last 30 minutes.

CHICKEN MARINADE:

Combine

• 1/2 cup soy sauce
• 1/4 cup vegetable oil
• 1/4 cup red wine vinegar
• 1 teaspoon oregano
• 1/2 teaspoon sweet basil
• 1/2 teaspoon garlic powder with parsley 1/4 teaspoon pepper
  • Pour over chicken pieces into a non-metal dish
  • Cover and refrigerate overnight, turning occasionally. Use marinade to baste chicken while cooking.

MEAT MARINADE: (For steaks, chops, and burgers) Combine

• ¼ cup soy sauce
• 2 coarsely chopped large onions
• 2 cloves garlic (halved)
  • Combine ingredients in an electric blender, cover, and process at high speed 1 minute or until mixture is very smooth.
• Stir in 1/4 cup bottle gravy coloring (Kitchen Bouquet and Gravy Master) and 2 teaspoons Beau Monde seasoning (or substitute 1 teaspoon MSG and 1 teaspoon seasoned salt).
• Allow meat to stand in marinade at room temperature for 2 hours or refrigerate up to 24 hours in a covered dish.
• Bring meat to room temperature before cooking.

SHISH KABOB MARINADE:

Mix

• 1 cup soy sauce
• 1/2 cup brown sugar
• 1/2 cup vinegar
• 1/2 cup pineapple juice
• 2 teaspoons salt
  • Mix ingredients and bring to a boil.
  • Marinate beef in mixture for a minimum of 4 hours 1/2 teaspoon garlic powder

ACCESSORIES

For pricing or to order accessories visit:

• www.CharGriller.com
• CALL: 912-638-4724

P.O. Box 30864 Sea Island, GA 31561 912-638-4724 www.CharGriller.com Service@CharGriller.com

References

• Char-Griller BBQ Grills and Smokers
• P65Warnings.ca.gov

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>