HUDORA 65760 Fantastic Complete Max 300 Trampoline Instruction Manual

: October 30, 2023
: hudora

Table of Contents

HUDORA 65760 Fantastic Complete Max 300 Trampoline
Product Information
Product Technical Specifications
Product Usage Instructions
TECHNICAL SPECIFICATIONS
SAFETY INSTRUCTIONS
PARTLIST
INSTRUCTIONS ON ASSEMBLY
MAINTENANCE AND STORAGE
SERVICE
SAFE USE
Basic jumps for beginners
References
Read User Manual Online (PDF format)
Download This Manual (PDF format)

HUDORA 65760 Fantastic Complete Max 300 Trampoline

Product Information

The product is a HUDORA Trampoline Fantastic Complete Max 300designed for jumping in a private area. The item number is 65760 and the maximum set-up dimensions are 3.30m x 3.30m x 2.67m.

The product comes with a user manual containing instructions onassembly and use, along with technical specifications.

Product Technical Specifications

Item: HUDORA Trampoline Fantastic Complete Max 300
Item number: 65760
Purpose: Trampoline for jumping in a private area
Maximum set-up dimensions: 3.30m x 3.30m x 2.67m

Product Usage Instructions

Before using the product, it is important to read the instructions carefully. The illustrations provided in the manualare intended to provide an overview during assembly.

Assembly:

Spread out the jumping mat with the printed side facing upwards in the frame.
Attach two springs to a pair of the twelve grey-coloured mateye straps.
Select two punched holes in the frame that are directly next toa leg socket. Attach the first two springs to the frame there.
Attach the other pairs of springs to the frame and to the remaining grey mat eye straps of the jumping mat. Proceed in a criss-cross pattern.
Use the special spring vice to attach the spring to the jumpingmat and hook the spring into the frame if you need more tension than with the first springs.
Attach another spring in the middle of each quadrant of theframe. Now you can attach the remaining springs in any order.

Product Usage The product is designed for jumping in a private area. The usercan perform various jumping techniques like basic-jumps, knee jumps, and jump seat. The user needs to follow the instructions carefully for safe usage.

CONGRATULATIONS ON PURCHASING THIS PRODUCT!
Warning! Please read these instructions carefully.
The texts provide you with comprehensive advice and information, whereas the illustrations are intended to provide you with a good overview during the assembly.
The instructions are an integral component of the product. Therefore, please store them and the packaging carefully in case questions arise in the future. Please always include these instructions when handing on the product to a third party. This product must be assembled by an adult. This product is designed for private / domestic use only. This product is not designed for commercial/industrial use. The use of the product requires certain capabili- ties and skills. Always adjust according to the age of the user and use for the purpose it has been designed for.

TECHNICAL SPECIFICATIONS

Item: HUDORA Trampoline Fantastic Complete Max 300
Item number: 65760
Maximum set-up dimensions: 3,30 m x 3,30 m x 2,67 m
Purpose: Trampoline for jumping in a private area.

SAFETY INSTRUCTIONS

WARNINGS! SPECIAL SAFETY INSTRUCTIONS

Max. 120 kg
For outdoor use only.
The trampoline shall be assembled by an adult in accordance with the assembly instructions and thereafter checked before the first use.
Only one user. Collision hazard.
Always close the net opening before jumping.
Jump without shoes.
Do not use the mat when it is wet.
Empty pockets and hands before jumping.
Always jump in the middle of the mat.
Do not eat while jumping.
Do not exit by a jump.
Limit the time of continuous usage (make regular stops).
Do not use in strong wind conditions and secure the trampoline.
Only for domestic use.
Follow the measures under „Maintenance and Storage“ as well as the in-structions under „Safe Use“. Non-observance of the aforementioned points can lead to serious hazards for the user.
Sufficient clearance above the trampoline must be ensured. A minimum of 2 m is recommended. Remove all cables, branches and other potential hazards. The trampoline must be set up only on a firm and level ground.
The trampoline requires sufficient horizontal distance from things around it. Set up the trampoline away from obstructions such as walls, buildings, electri-cal lines, fences and play areas. Ensure a free space of 2 m around its diameter.
Do not eat and drink while using the trampoline.
The net should be replaced every 3 years.
WARNING! Not suitable for children under 36 months due to long cords!Strangulation Hazard.
WARNING! Not suitable for children under 36 months due to lack of abil-ities. Risk of injury!
Please replace the self securing nuts after loosening them as the self se-curing structure will be damaged.
In certain countries during winter period, the snow load and the very low temperature can damage the trampoline. It is recommended to remove the snow and store the mat and the enclosure indoors.

SAFETY INSTRUCTIONS

Keep young children away while assembling to prevent any risk of stran-gulation from long cords or of asphyxiation from small parts! For this reason, cut off cord ends to a maximum of 5 cm after the assembly.
Position the trampoline on a level surface before using it.
Use appropriate lighting in dark places.
Do not place the trampoline on a concrete floor, a hard ground (rocky surface) or a slippery surface. We recommend placing it on a lawn.
Do not leave any object on the trampoline and remove anything that can hit the person jumping on it.
Used rain covers must be kept outside of the reach of children (choking hazard).
Improper use or misuse of the trampoline is dangerous and can cause a serious injury!
The person owning the trampoline and the person supervising the people on the mat are responsible for making the techniques and warnings men-tioned in the user manual known to all users.
The trampoline must only be used in the presence of an experienced su-pervisor with relevant expertise. Make sure that your children are always within sight while using the trampoline.
The trampoline must be mounted and dismounted by climbing up and down.
Get on and off the trampoline through the inlet in the safety net. Access and exit the trampoline by thereby climbing up and down respectively. Do not attempt to enter the trampoline by crawling under the safety net.
In order to mount the trampoline correctly, hold the frame with your hands and climb up or roll on to the frame, over the springs and on to the mat. Always make sure that you hold the frame with your hands while climbing up or down. Do not immediately climb on to the frame padding and do not hold on to the frame padding. In order to dismount correctly, get to the edge of the trampoline, hold the frame with your hands and climb down from the mat on the floor.
Do not allow pets on the mat to protect it from cuts and damages.
Do not wear clothing having drawstrings, loops and hooks. Buckles, if any, should not be hard or have a rough surface.
Do not use the trampoline under the influence of alcohol or drugs.
Wind or air movements should be calm or slight when jumping. In the event of strong or stormy winds the trampoline should not be used.
The mat must not come in contact with sharp or pointed objects.
Ensure that there is no one under the trampoline.
Landing on head or neck can cause paralysis or death! Somersaults are not recommended as they increase the risk of landing on head or neck.
Not suitable for pregnant women.
Make sure that the warning messages printed on the trampoline are read-able when the user enters through the safety net entrance.
The trampoline is neither intended nor suitable to be buried into the ground.
Recommendation for supervisors: Take care that the user frequently takes a break to avoid exhaustion and ensure full body control.
When permanently irradiated with UV light, the material ages significantly faster. To avoid premature ageing and thereby extend the service life, you should always store the frame covering/frame padding and jumping mat in a dry and dark place when not in use. Do not permanently expose the frame covering/frame padding and jumping mat to wind, moisture, ex-treme temperatures or sunlight.

PARTLIST

INSTRUCTIONS ON ASSEMBLY

Our special spring extender, delivered with this product, is required to set up the trampoline. When you are not using the trampoline, it should be disman- tled and stored away in its original packaging. Please read both instructions on assembly once before assembling this product. You should perform the assembly in pairs. In the upper left corner you can always see the necessary materials or the steps that were necessary previously and how often the respective step has to be repeated. Materials without part numbers are not included in the scope of delivery. In the lower left corner, you can always see what the result of the respective assembly step must look like.

BEFORE ASSEMBLY
Some assembly steps vary depending on the size of the trampoline or are done at different frequencies . Make sure that you have all the parts listed in the parts list. If you are missing parts, please contact our service depart-ment. Before connecting, you should spray or lightly grease all connections with contact spray. This extends the service life as well as eases the assem-bly and subsequent disassembly. A rubber mallet and safety goggles should be kept ready. Please use gloves to protect your hands.

STEP A – C: ASSEMBLING THE SUPPORTS AND FRAME
Follow steps A to C as shown in the illustration. Make sure that all steel tubes are fitted into the respective counterpart up to the stop. If necessary, use a rubber mallet for this. The frame part (3) is initially only fitted onto the support leg (4). The elements are screwed together later in step H. STEP D – E: ASSEMBLING THE JUMPING MAT
CAUTION – When attaching the springs, the pipe connections can pinch due to the tension of the trampoline.

a) Spread out the jumping mat (1) with the printed side facing upwards in the frame. Attach two springs to a pair of the twelve grey-coloured mat eye straps.
b) On the frame tube, select two punched holes in the frame that are directly next to a leg socket. Attach the first two springs (6) to the frame there.
c) Attach the other pairs of springs to the frame and to the remaining grey mat eye straps of the jumping mat. Proceed in a criss-cross pattern.
d) Use the special spring vice (7) to attach the spring to the jumping mat and hook the spring into the frame if you need more tension than with the first springs. Hook in the spring until it snaps into place and press it down further if the hook is not fully seated in the hole.
e) Attach another spring in the middle of each quadrant of the frame. Now you can attach the remaining springs in any order. If you notice that you have skipped a hole and an eyelet, remove and reattach the springs so that the holes on the frame match the eyelets again.

STEP F – G: ASSEMBLING THE FRAME PADDING
Place the frame padding (2) on the trampoline so that the springs and the steel frame are covered. Make sure that the frame padding covers the whole frame, the bars and the springs. Attach the edge cover to the jumping mat (1) using the zip fastener. Mount the elastic straps with hooks to the eyelets of the edge cover. Tie the elastic straps of the edge cover to the appropriate mat eyelets.

STEP H: ASSEMBLING THE BOTTOM NET POLES
Make sure to insert the longer screw (14) through the upper hole and the shorter screw (13) through the lower hole. Only tighten the screw connec-tions hand-tight. Make sure that the foam tube sits above the trampoline frame. STEP I: FASTENING THE NET
Place the safety net on the jumping mat before following the assembly steps. This is important for step J. Attach the safety net (12) by inserting the top ring rods (10) into the adapters (11) so that their holes overlap and you can tighten the adapter screw. Note that the adapter should be outside the safety net. Finally, insert the top net post (8) into the adapter from below until the spring bolt audibly clicks into place.

STEP J – K: ASSEMBLING THE NET POLES
Align the entrance so that it is between two feet (5). Align the net seam with a pole. Attach the upper and lower net rods (8 + 9) together. Make sure that the safety bolt clicks into place. Bring the pads of the net poles together. Align them with the upper end of the net poles! Fasten the elastic straps of the frame padding (see step G) by passing them around the outside of the frame and through a spring eyelet on the net and finally hooking them into the loops at the lower end of the net.

STEP L – M: FASTENING THE GROUND SAFETY NET
The ground safety net (24) is used to keep the area under the jumping mat free of obstacles. It especially keeps pets and small children from getting under the mat. Please note that children could also see this area under the mat as a hiding place. For this reason, it is important to check the area under the mat before using the trampoline to ensure that the area is clear. Align the ground safety net so that the sewn-on pockets and the holes for the ladder are directly at the entrance of the net. Attach the ground safety net gradually around the frame to the safety net (12) using the zips. Attach the loops and straps to the frame and the feet. Close the zip on the leg to the right of the entrance. STEP N: ASSEMBLING THE LADDER
The nuts for the screw connection are already inserted in the ladder steps. Make sure not to overtighten the screws (21)!

STEP O – Q: FASTENING THE LADDER,
PEGS, FOOT MAT AND GROUND ANCHORS
When setting up the ladder, make sure that it goes through the openings provided in the ground safety net. The two flattened ends of the ladder must be hooked over the frame tube. The ladder rail must rest on the ground over its entire width at the bottom end. The ladder must not wobble when in use. Secure the sections of the ground safety net between two feet with two pegs each (25). The floor mat is attached to the bottom of the ladder using the hook and loop fastener. To preserve your lawn, hang the foot mat on the top rung of the ladder when the trampoline is not in use. Ground anchors reduce the risk of wind blowing the trampoline away. However, they will not completely eliminate this risk. Depending on the condition of the soil and temporary weather conditions, ground anchors may not provide sufficient anchoring even at medium wind speeds. If in doubt, consult experts in re- gional gardening and landscaping. The ground anchors (22) should be in-serted into the ground in the middle of the trampoline base about 5 to 10 cm outside the base of the trampoline until only the eyelet protrudes from the ground. Then fasten the longer end of the tensioning strap (23) around the foot and frame and secure the end of the strap twice as shown. After that, lash the short part of the tensioning strap through the ground anchor eyelet.
Important note! Tighten the nuts firmly as a last step.

MOVING THE TRAMPOLINE
In order to move the trampoline you should have as many helpers as the trampoline has feet. Prior to lifting, all used fasteners (stakes, etc.) should be removed. Caution! Due to the spring tension there is a possible risk that the frame can be twisted into a figure „8“ as a result of uneven lifting! You and your helpers should therefore be respectively positioned between two feet of the trampoline and you should then all lift the trampoline at the same time. Lift the trampoline off the ground slightly and keep it horizontal with the floor. To move the trampoline in a different way, disassemble it com- pletely. To disassemble, follow instructions for assembly backwards.

MAINTENANCE AND STORAGE

Use a dry or damp cloth only to clean the product; do not use special cleaning agents! Check the product for damage or traces of wear and tear before and after each use. Do not make any structural changes. For your own safety, please use original spare parts only. These can be sourced from HUDORA. If parts become damaged or if sharp edges or corners should develop, the product may not be used any more. If in any doubt, please contact our service team (http://www.hudora.de/). Store the product in a safe place where it is protected from the elements, cannot be damaged, and cannot injure anyone.

Check that jumping mat, frame padding and safety net are without defects and can withstand load. Sunlight, rain, snow and extreme temperatures will make these parts loose strength. Replace jumping mat, frame padding and safety net after 36 month use.
Check the product regularly – especially before and after use! – for damage and wear marks. Not servicing the product regularly can lead to dangerous consequences for the user.
Verify prior to each use that the trampoline mat is not worn and parts are not loose or missing. In particular, check all spring and bolt connections and tighten them if necessary, so that they do not loosen during use.
The trampoline can be blown over, when exposed to strong winds. In the event that you expect windy weather, the trampoline must be transferred to a protected area and where expedient also disassembled. Another possibility is to ensure that the frame of the trampoline is securely lashed with the help of ropes and stakes. In order to ensure safety, the trampoline has to be pegged to the ground over at least three points. Ensure that the frame of the trampoline is not exclusively only securely lashed over a foot part of the trampoline, as this may lead to a tearing apart of the frame connections.
Keep the trampoline safe from impermissible access when not in use. For trampoline with ladders, the supervisor must remove the ladder when leaving the place so that unsupervised children under 6 years do not get on the trampoline.
Make sure that the padding for the trampoline frame is attached securely and is at the right place.
In order to keep the risk of an injury to the minimum, always check the trampoline for worn, defective or missing parts before use.
Always inspect the safety net to find out if it is worn out or damaged before the trampoline is used. Make sure that the safety net is properly attached, its straps are securely fastened and the safety net itself is not damaged.
Do not make any technical modifications. The trampoline and its safety net should be dismantled or secured against use until necessary corrections have been made, if a fault or an abnormality which is potentially dangerous to the user has been detected.
Do not use the trampoline if it is damaged or unsafe!
After moving the trampoline, check each point of the “Special Safety Instruc- tions” and “Safety Instructions” once again.

WATCH OUT FOR THE FOLLOWING

Tears, holes or rips
Loose jumping mat
Pulled seams or other closure problems
Bent or broken framework, i.e. legs
Damaged or loose screws
Broken, missing or damaged springs
Damaged, missing or unsecured frame padding
Protruding objects of any kind (especially sharp edges) on the frame, springs or the mat
Safe functioning of the locking bolt.

DISPOSAL ADVICE
At the end of the product’s life, please dispose of it at an appropriate collection point provided in your area. Local waste management companies will be able to answer your questions on this.

SERVICE

We make every effort to deliver faultless products. If faults do arise however, we put just as much effort into rectifying them. Therefore, you can find numerous information on the product, replacement parts, solutions to problems and lost assembly manuals at http://www.hudora.de/.

SAFE USE

Be aware of the fact that a trampoline’s connecting springs can generate tremendous elasticity and propel the person on the mat to surprising heights and cause the body to move in a variety of extreme and unusual directions. Use the trampoline only if you are physically fit. In case of a doubt, consult a doctor before using the product.
Stop jumping if you have moved more than 30 cm from the logo. Get back to the centre of the mat and on the logo to resume jumping.
To stop jumping, bend your knees when your feet come in contact with the mat. Master this technique before trying newer ones.
Master basic jumps before trying advanced skills. You can combine these basic moves in a variety of combinations with or without straight intermediate jumps to carry out various sequences on the trampoline.
Avoid jumping too high. Keep your jumps low till you have sufficient control on your jumps and always land on the middle of the trampoline. Controlled jumping is more important than height. Keep your eyes on the trampoline as it helps to control the jumps.
Do not jump from balconies, trees or other such high places on to the trampoline. Do not use the trampoline as a springboard. Jumps should never be higher than the safety net.
Do not jump deliberately or bounce off the safety net. Do not hang from the top of the safety net or try to climb it. Remove all jewellery as it may get caught or cut through the safety net.
Contact an authorised trampoline coach for information on advanced skills.

THE TRAINING ON THE TRAMPOLINE (SEE P. 31)
Before you ‘let it rip’, we recommend some basic practise exercises on the trampoline. We have collected a few suitable exercises here and recommend you to do them one after the other (warming up) and do them again after your training for cooling down to support muscle regeneration and enhance blood circulation after the training. Light stretching exercises after the training will also be helpful.
Basic exercises on the trampoline
for the warm-up and cool-down phase:
We recommend that each exercise shown here is performed 10 times in a row.

Contact bounce (Fig. A.1)
Stand on the trampoline with your feet about a shoulder-width apart, bend your knees slightly. With the hands placed on the hips. Start with slight hops, so that your feet are „just about“ in the air. This exercise is also especially suitable for a beginner as an aid to becoming a bit familiar with the new sport device.

Foot tap (Fig. A.2)
Position yourself on the trampoline in the same manner as described in the „Contact Bounce“. Now shift your weight alternatingly from one side to the other, while respectively shortly lifting the unburdened foot and tap it on the side („tap“). Then return to the basic position and shift the weight to the other side, again „tap“, etc.

Hamstring curls (Fig. A.3)
While performing the „Contact Bounce“, shift your weight to one side. Then always touch the trampoline only with one foot while slightly bending the knee of the other leg backwards.

Side to side (Fig. A.4)
In this exercise, position yourself as shown with both feet together on one side and then jump to the other side, where you again land with both feet together, etc.

Basic jumps for beginners

The basic jump (Fig. B.1)

Start while standing still then bob up and down a bit.
Swing your arms sideways and upwards away from the body to pull up the body.
Keep the feet together while in the air.
Swing the arms back down again and land with both feet on the mat.

Knee jump (Fig. B.2)

Start with low height basic-jumps.
Land on your knees, however keep your back straight. Use your arms to keep balance.
Jump back to the starting position by pulling your arms upwards.

Jump seat (Fig. B.3)