DELUXE BB90L-2 BBQ Grill Box Instructions
- June 7, 2024
- Deluxe
Table of Contents
DELUXE BBQ Grill Box Instructions
BB90L-2, BB90LS
KEEP FOR FUTURE REFERENCE
FOLLOW ALL INSTRUCTIONS SUPPLIED WITH STOVE WHEN USING THIS ACCESSORY.
IF YOU SMELL GAS
- Disconnect gas to the appliance.
- Extinguish any open flame.
- If odor continues, immediately leave the premises and call your gas supplier or local fire department.
COMBUSTIBLE MATERIALS
During operation of cooker, insure proper clearance from any combustible materials, in relation to the top, sides and back of cooking appliance. For outside use only. Do not use near flammable walls or under eaves or overhangs of homes or garages. Never leave unattended while hot or in use. Allow cooker and accessory to cool before take down and storage. The propane tank must always be stored outdoors in a well ventilated space. Never stand or lean over cooker burner while lighting.
FOR YOUR SAFETY
Follow all safety, set-up, lighting and cooking instructions. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. When using this product with any outdoor appliance use appliance according to manufacturer’s instructions.
WARNING
FOR OUTDOOR USE ONLY
Do not discard these safety and assembly instructions. Follow instructions and
warnings to avoid injury or fires. This BBQ Grill in combination with our
outdoor cookers is intended for outdoor use only. Follow care and cleaning
instructions.
WARNING
- The accessory will be extremely hot while in use.
- Do not attempt to clean or move it until it is completely cool.
- Always use a long match or long nose lighter to light or re-light the cooker through the burner access hole on the front of the outdoor cooker when using this accessory or any other cookware.
- If the flame goes out it is important to turn gas off for 30-60 seconds before you re-light the outdoor cooker.
- Never leave cooker and accessory unattended.
- Place the tank so as to minimize the possibility of someone tripping over the connection hoses while the cooker is set up.
- Never lean over or stand too near the cooker, or allow children or pets near the cooker during use.
WARNING
This product contains chemicals, including lead in the brass of certain component parts, that are known to the State of California to cause cancer, and birth defects, or other reproductive harm.
ASSEMBLY INSTRUCTIONS
- Place the handle on the front panel of the lid with gaskets between handle and lid.
- Place screws through handle holes and into the lid.
- Place the two nuts on the screws inside the lid and securely tighten.
SEASONING
Saturate a clean cloth rag with Camp Chef Cast Iron Conditioner. Coat all surfaces of the cast iron. Place grates in the barbecue grill box and place the box on your outdoor cooker. Heat to 375° – 400°F. Cookware will smoke as the seasoning bakes. As smoking begins to slow remove from heat. Use or let cool and store. This process can also be done in your home oven. Note: Do not place the grates directly over the burners of your outdoor cooker. Placing the grates directly over the burners could result in cracked or broken cast iron.
MAINTAINING SEASONING
After each use, apply a small amount of Camp Chef Cast Iron Conditioner, and thinly coat all surfaces of the cast iron. Over time, this will make your cast iron black, creating a finish called a “patina.” This enhances your cast iron by creating a glass-like finish, giving it a nonstick surface. Additional seasoning ideas can be found online at: www.campchef.com. Store your cookware in a dry, clean area with a light coating of Cast Iron Conditioner. Your cast iron will be ready for use the next time you retrieve it. Avoid any locations with widely fluctuating temperature conditions. If your cast iron becomes rusty, soak the area in cola to remove the rust and then re-season.
CLEANING
When cool, wash your cast iron thoroughly with a noncitrus based soap and water. Be sure to rinse and dry completely. (Note: Soap can remove the seasoning of your cast iron if you don’t restore it after cleaning.)
COOKING TIPS
Wash cast iron in hot water and dry thoroughly. Wipe cooking surface with cooking oil to help prevent sticking. Frozen food should be completely thawed before cooking. Use naturally lean meats and poultry. Trim excess fat from all meat, this will reduce flare-ups. If flare-ups occur, use lid to assist in putting the flame out by simply replacing it on the grill. Use tongs or spatula instead of a fork or knife when turning meats. Some of the meats juices will be lost if pierced. Marinating meats for several hours will break down the cellular structure generally tenderizing and flavoring the meat and will also reduce cooking time. OPTION: Instead of long hours of marinating use a marinade injector kit and fill the meat instantly full of flavor. Injector kits can be found at most grocery stores or kitchen supply stores
SMOKING TIPS
To obtain a “smoke” flavor, use wood chips or chunks such as hickory, mesquite, apple or cherry wood. Any fruit or nut tree wood may be used for flavoring. Do not use resinous woods such as pine, they produce an unpleasant taste. Soak wood chips in water according to directions for flavor smoking. Soaking the chips will cause them to smoke for a longer period of time rather than burning up quickly. Place wood chips under the cast iron cooking grate. The amount of chips used will determine how intense or subtle the flavor will be. Smoke cooked food may still look a little pink when fully cooked. Close attention is advised to prevent over-cooking
**BB90-2 PARTS LIST
**
LIMITED WARRANTY
To activate warranty, register on-line at: www.CampChef.com
The manufacturer warrants stove components (except paint and finish) to be free from defect in materials and workmanship for 1 year from the date of purchase. All accessories (included with stove or purchased separately) are warranted from defect in materials and workmanship for 90 days from the original purchasing date. Within these periods, the manufacturer will replace or repair defective parts deemed unusable from its original intent by making available the parts thereof FOB Hyde Park, UT 84318. Product paint and finish is not warranted. The exterior finish of the product will wear down over time. Clean the unit after each use to maintain the finish and prolong the life of your product. Wipe away all grease and ashes. Keep metal products free of moisture, salts, acids and harsh fluctuations in temperatures. Warranty does not cover normal wear of parts or damage caused by misuse, abuse, overheating and alteration. Repairs or alterations made by anyone other than Camp Chef are not covered in this Warranty. Manufacturer will not be held liable for any losses due to neglectful operation. Furthermore, this Warranty does not cover damaged caused by natural disasters such as earthquakes, hurricanes, tornadoes, floods, lightning, fires, etc. Upon the expiration of this warranty all such liability will terminate. No other warranties are expressed or implied. Keep all original sales receipts. Proof of purchase is required to obtain Warranty services. Prior written approval and a Return Authorization Number must be obtained and accepted for repair or replacement only. Returns must be shipped prepaid. Collect shipment or shipments without a Return Authorization Number will not be accepted.
To obtain Warranty services call 1.800.650.2433.
*Warranty applies to the contiguous US states only.
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>