Brute Deluxe BMT2V Volume Water Heater User Manual
- June 3, 2024
- Brute Deluxe
Table of Contents
Brute Deluxe BMT2V Volume Water Heater
FOR YOUR SAFETY: This product must be installed and serviced by a professional service technician, qualified in boiler installation and maintenance. Improper installation and/or operation could create carbon monoxide gas in flue gases which could cause serious injury, property damage, or death. Improper installation and/or operation will void the warranty.
WARNING
If the information in this manual is not followed exactly, a fire or explosion
may result causing property damage, personal injury or loss of life.
Do not store or use gasoline or other flammable vapors and liquids in the
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
- Do not try to light any appliance.
- Do not touch any electrical switch; do not use any phone in your building.
- Immediately call your gas supplier from a nearby phone. Follow the gas supplier’s instructions.
- If you cannot reach your gas supplier, call the fire department.
- Installation and service must be performed by a qualified installer, service agency, or gas supplier.
Caring For Your Brute Deluxe
Your Brute Deluxe will require very little Maintenance. However, as with any
fine appliance there are certain steps that should be taken to ensure
continuing optimum performance.
General Care
Keep the area around the Brute Deluxe clean and free from combustible
materials, gasoline and other flammable liquids and vapors.
The Brute Deluxe must be completely isolated and protected from any source of
corrosive chemical fumes such as trichlorethylene, perchlorethylene, chlorine,
etc.
Keep grille openings on the boiler free for proper ventilation of interior
components.
Do not obstruct or block a free flow of air to the boiler to ensure proper
ventilation.
If desired, clean the jacket surfaces with a damp cloth and mild detergent. Do
not use flammable cleaning materials.
If sidewall vented, keep the vent terminal clear of obstructions — do not pile
snow against the vent terminal. Clean the air filter(s) often, and then
develop an appropriate maintenance schedule.
Annual Inspection of Flue and Vents
Visually inspect the vent pipe once a year. Should any deterioration exist,
have the affected parts replaced by a qualified service person.
Shutting Down the Brute Deluxe
-
Switch off the main electrical disconnect switch.
-
Close all manual gas valves.
-
If freezing is anticipated, drain the Brute Deluxe and be sure to also protect the building piping from freezing. This step to be performed by a qualified service person.
-
To Restart the Brute Deluxe
If drained, follow the Installation and Operation Manual for proper filling and purging.
- Switch off the main electrical disconnect switch.
- Close all manual gas valves.
- WAIT FIVE (5) MINUTES.
- Set the aquastat or thermostat to its lowest setting.
- Open all manual gas valves.
- Reset all safety switches (low water cut off, manual reset high limit, etc.).
- Set the temperature controller to the desired temperature setting and switch on electrical power.
- Burner will go through a prepurge period and ignitor warm-up period, followed by ignition.
In the Event of a Power Failure
The Brute Deluxe can not be operated during an electrical power outage. If
there is an extended power outage with the danger of freezing, then the Brute
Deluxe (and all other water systems) should be drained completely. When
draining the boiler, turn off the main electrical disconnect switch. When
placing back in service, refer to start-up instructions in the Installation
and Operation Manual for filling and purging. Draining and filling shall only
be done by a qualified service person.
Full Service Every Three (3) Years
In addition to the annual visual inspections, a qualified service agency
should conduct a detailed inspection of all flue product-carrying areas of the
boiler and its venting system.
WARNING
Do not use this boiler if any part has been underwater. Immediately call a
qualified service technician to inspect the boiler and to replace any part of
the control system and any gas control which has been under water.
WARNING
Should overheating occur or the gas supply fail to shut off, do not turn off
or disconnect the electrical supply to the pump. Instead, shut off the gas
supply at a location external to the boiler.
FOR SERVICE
Contact your installing contractor, gas utility, or Bradford White dealer, or
call Bradford White for the nearest authorized representative in your area.
- 200 Lafayette St. Middleville, MI 49333 Warranty:800-531-2111
- www.BradfordWhite.com
- Litho in U.S.A. © Bradford White 1809 Document 1264A
Documents / Resources
|
Brute Deluxe BMT2V Volume Water
Heater
[pdf] User Manual
BMT2V Volume Water Heater, BMT2V, Volume Water Heater, Water Heater, Heater
---|---
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>