HESTAN AEAD Series 24″ Steeletto Single Access Door Instruction Manual
- June 3, 2024
- HESTAN
Table of Contents
HESTAN AEAD Series 24″ Steeletto Single Access Door
IMPORTANT – READ ALL INSTRUCTIONS BEFORE YOU BEGIN
INSTALLER SHOULD LEAVE THESE INSTRUCTIONS WITH THE HOMEOWNER
Some parts have sharp edges. Care must be taken when handling the various components to avoid personal injury. Wear gloves when handling.
TOOLS REQUIRED
- Work gloves
- Safety glasses
- Electric drill with assorted bits for mounting hardware, masonry anchors,
- etc. where needed
- Phillips screwdriver
- Flat-blade screwdriver
- Level
- Tape measure
- Shims for installing frames in opening
Inspect the product to verify that there is no shipping damage. If any damage
is detected, call the shipper and initiate a damage claim. Hestan Commercial
Corp. is not responsible for shipping damage. DO NOT discard any packing
material (box, pallet, straps) until the unit has been inspected.
Remove all exterior packaging materials, banding, tape, etc. Remove all
protective film from the inside of your cabinets. You may leave any exterior
protective film on until after installation is complete.
CABINET DOOR INSTALLATION (AEAD, AESDR, AEDR)
-
Your new Aspire cabinets come with doors pre-installed in their frames. It will be necessary to detach them before installing the frame in your island structure. As shown below, pinch the back of the hinge to un-clip it from the mounting base. The door may now be removed.
-
Consult the table at the end of this instruction manual to determine the appropriate cutout dimensions for the Aspire Outdoor cabinet product you are installing. The cutouts should be square at all corners for proper fitment of the cabinet. The installer will have to build up any internal structural elements or supports in the island in order to secure the cabinet in place. Stainless steel hardware (not included) is highly recommended.
-
Slide the frame into the opening and check for proper alignment (AEAD36 shown). Secure the frame to the structural members of your island using the various available mounting holes in the frame. Use at least 2 screws per side. Shim between the frame and opening as needed to avoid distorting the frame when securing the screws.
-
To re-install the door, follow the instructions shown below.
-
Aspire cabinet doors feature 3-way adjustable hinges. It is recommended to do the height adjustment first. Loosen (but do not remove) the top & bottom screw on each mounting base, and adjust the door’s vertical position in the frame. Tighten the top and bottom screws when done.
-
The side and depth adjustment of the doors are shown below. Make small adjustments and close and open the door between each attempt to see how the door looks relative to the frame opening and adjacent door.
DRAWER INSTALLATION (AEDR / AESDR)
-
Your new Aspire cabinet drawers come pre-installed in their drawer boxes. It will be necessary to remove them before installing the box in your island structure. Press the release lever (shown below) on each side of the drawer to disengage the slide (up on the left, down on the right), then pull the drawer all the way out.
-
Consult the table at the end of this instruction manual to determine the appropriate cutout dimensions for the drawer you are installing. The cutouts should be square at all corners for proper fitment of the cabinet. The installer will have to build up any internal structural elements or supports in the island in order to secure the drawer box in place. Stainless steel hardware (not included) is highly recommended.
-
Slide the drawer box into the opening and check for proper alignment. Secure the box to the structural members of your island using the various available mounting holes inside the box. Use at least 2 screws per side. Shim between the frame and opening as needed to avoid distorting the frame when securing the screws. Reinstall the drawer by aligning the slides on either side and push the drawer back into the opening. You will hear the release levers click. Open and close the drawer a few times to check for proper function and alignment.
CUTOUT DIMENSIONS
Model Number
|
Description
|
W (in.)
|
D (in.)
|
H (in.)
---|---|---|---|---
AEADL18| Single Access Door, Hinge Left, 18″|
15-7/8
|
n/a
|
19
AEADR18| Single Access Door, Hinge Right, 18″|
15-7/8
|
n/a
|
19
AEADL24| Single Access Door, Hinge Left, 24″|
21-7/8
|
n/a
|
19
AEADR24| Single Access Door, Hinge Right, 24″|
21-7/8
|
n/a
|
19
AEAD30| Double Access Doors, 30″|
27-7/8
|
n/a
|
19
AEAD36| Double Access Doors, 36″|
33-7/8
|
n/a
|
19
AEAD42| Double Access Doors, 42″|
39-7/8
|
n/a
|
19
AEDR16| Double Drawers, 16″|
13-15/16
|
23-1/2
|
19-1/4
AESDR30| Double Drawer and Storage Door Combination, 30″|
28-1/8
|
23-3/8
|
19-1/4
AESDR36| Double Drawer and Storage Door Combination, 36″|
34-1/8
|
23-3/8
|
19-1/4
AESDR42| Double Drawer and Storage Door Combination, 42″|
40-1/8
|
23-3/8
|
19-1/4
PARTS LIST
Please visit the Hestan website to access the parts list for your Hestan Outdoor product: www.hestanaspire.com.
SERVICE
All warranty and non-warranty repairs should be performed by qualified service personnel. To locate an authorized service agent in your area, contact your Hestan dealer, local representative, or the manufacturer. Before you call, please have the model number information ready. This information is shown on a sticker affixed to one of the inside vertical surfaces of your product.
Hestan Commercial Corporation
3375 E. La Palma Avenue
Anaheim, CA 92806
888-905-7463
OUTDOOR GAS PRODUCT LIMITED WARRANTY
WHAT THIS LIMITED WARRANTY COVERS
Hestan Commercial Corporation (“HCC”) warrants to the original consumer purchaser of an Aspire by Hestan outdoor gas product (the “Product”) from an HCC authorized dealer that the Product is free from defective materials or workmanship for a period of one (1) year from the date of original retail purchase or closing date for new construction, whichever period is longer (“Limited Warranty Period”). HCC agrees to repair or replace, at HCC’s sole option, any part or component of the Product that fails due to defective materials or workmanship during the Limited Warranty Period. This Limited Warranty is not transferable and does not extend to anyone beyond the original consumer purchaser (“Purchaser”). This Limited Warranty is valid only on Products purchased and received from an HCC authorized dealer in the fifty United States, the District of Columbia and Canada. This Limited Warranty applies only to Products in non-commercial use and does not extend to Products used in commercial applications.
HOW TO OBTAIN WARRANTY SERVICE
If the Product fails during the Limited Warranty Period for reasons covered by
this Limited Warranty, the Purchaser must immediately contact the dealer from
whom the Product was purchased or HCC at 888.905.7463.
Purchaser is responsible for making the Product reasonably accessible for
service or for paying the cost to make the Product reasonably accessible for
service. Service is to be provided during normal business hours of the
authorized Hestan Commercial Service Provider. To the extent Purchaser
requests service outside of the normal business hours of the authorized Hestan
Commercial Service Provider, Purchaser will pay the difference between regular
rates and overtime or premium rates. Purchaser is required to pay all travel
costs for travel beyond 50 miles (one way) from the nearest authorized Hestan
Commercial Service Provider.
EXTENSIONS TO ONE YEAR LIMITED WARRANTY PERIOD:
In addition to the One-Year Limited Warranty, the following components have extended warranty coverage as specifically set forth below:
- The Product’s stainless steel grill body, stainless tubular grill burners, Sear burners and rotisserie infrared burner (where applicable) are warranted to be free from defects in material and workmanship under normal non-commercial use and service for the lifetime of the original Purchaser. This excludes surface corrosion, scratches, and discoloration which may occur during normal use and is limited to replacement of the defective part(s), with the Purchaser paying all other costs, including labor, shipping and handling, as applicable.
- The Product’s cooking grates and warming rack are warranted to be free from defects in material and workmanship under normal non-commercial use and service, for a period of ten (10) years from the original date of purchase. This excludes surface corrosion, scratches, and discoloration which may occur during normal use and is limited to replacement of the defective part(s), with the Purchaser paying all other costs, including labor, shipping and handling, as applicable.
- The Product’s spit rod, briquette trays, manifolds, gas valves and sealed burner assemblies (where applicable) are warranted to be free from defects in material and workmanship, under normal non commercial use and service, for a period of five (5) years from the original date of purchase. This is limited to replacement of the defective parts, with the Purchaser paying all other costs, including labor, shipping, and handling, as applicable.
- All other grill components are warranted to be free from defects in material and workmanship, under normal non-commercial use and service, for a period of two (2) years from the original date of purchase. This is limited to replacement of the defective parts, with the Purchaser paying all other costs, including labor, shipping, and handling, as applicable.
WHAT THIS LIMITED WARRANTY DOES NOT COVER:
This Limited Warranty does not cover and HCC will not be responsible for and will not pay for: damage to or defects in any Product not purchased from an HCC authorized dealer; color variations in color finishes or other cosmetic damage; failure or damage from abuse, misuse, accident, fire, natural disaster, commercial use of the Product, or loss of electrical power or gas supply to the Product; damage from alteration, improper installation, or improper operation of the Product; damage from improper or unauthorized repair or replacement of any part or component of the Product; damage from service by someone other than an authorized agent or representative of the Hestan Commercial Service Network; normal wear and tear; damage from exposure of the Product to a corrosive atmosphere containing chlorine, fluorine, or any other damaging chemicals; damage resulting from the failure to provide normal care and maintenance to the Product; damage HCC was not notified of within the Limited Warranty Period; and incidental and consequential damages caused by any defective material or workmanship
ARBITRATION
This Limited Warranty is governed by the Federal Arbitration Act. Any dispute between Purchaser and HCC regarding or related to the Product or to this Limited Warranty shall be resolved by binding arbitration only on an individual basis with Purchaser. Arbitration will be conducted by the American Arbitration Association (“AAA”) in accordance with its Consumer Arbitration Rules or by JAMS. The arbitration hearing shall be before one arbitrator appointed by the AAA or JAMS. The arbitrator shall not conduct class arbitration and Purchaser shall not bring any claims against HCC in a representative capacity on behalf of others.
LIMITATION OF LIABILITY
This Limited Warranty is the final, complete and exclusive agreement between HCC and Purchaser regarding the Product.
THERE ARE NO EXPRESS WARRANTIES OTHER THAN THOSE LISTED AND DESCRIBED ABOVE.
NO WARRANTIES WHETHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, ANY
IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE
SHALL APPLY AFTER THE LIMITED WARRANTY PERIOD STATED ABOVE. NO OTHER EXPRESS
WARRANTY OR GUARANTY GIVEN BY ANY PERSON, FIRM OR CORPORATION WITH RESPECT TO
THIS PRODUCT SHALL BE BINDING ON HCC. HCC ASSUMES NO RESPONSIBILITY THAT THE
PRODUCT WILL BE FIT FOR ANY PARTICULAR PURPOSE, EXCEPT AS OTHERWISE PROVIDED
BY APPLICABLE LAW.
HCC SHALL NOT BE LIABLE FOR LOSS OF REVENUE OR PROFITS, FAILURE TO REALIZE
SAVINGS OR OTHER BENEFITS, OR ANY OTHER SPECIAL, INCIDENTAL OR CONSEQUENTIAL
DAMAGES CAUSED BY THE USE, MISUSE OR INABILITY TO USE THE PRODUCT, REGARDLESS
OF THE LEGAL THEORY ON WHICH THE CLAIM IS BASED, AND EVEN IF HCC HAS BEEN
ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. NO RECOVERY OF ANY KIND AGAINST
HCC SHALL BE GREATER IN AMOUNT THAN THE PURCHASE PRICE OF THE PRODUCT.
WITHOUT LIMITING THE FOREGOING, YOU ASSUME ALL RISK AND LIABILITY FOR LOSS,
DAMAGE OR INJURY TO YOU AND YOUR PROPERTY AND TO OTHERS AND THEIR PROPERTY
ARISING OUT OF THE USE, MISUSE OR INABILITY TO USE THE PRODUCT NOT CAUSED
DIRECTLY BY THE NEGLIGENCE OF HCC. THIS LIMITED WARRANTY STATES YOUR EXCLUSIVE
REMEDY
No oral or written representation or commitment given by anyone, including but not limited to, an employee, representative or agent of HCC will create a warranty or in any way increase the scope of this express Limited One Year Warranty. If there is any inconsistency between this Limited Warranty and any other agreement or statement included with or relating to the Product, this Limited Warranty shall govern. If any provision of this Limited Warranty is found invalid or unenforceable, it shall be deemed modified to the minimum extent necessary to make it enforceable and the remainder of the Limited Warranty shall remain valid and enforceable according to its terms
INTERACTION OF LAWS WITH THIS LIMITED WARRANTY
Some states, provinces or territories may not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages, so the above limitations or exclusions may not apply to you. Some states, provinces or territories may provide for additional warranty rights and remedies, and the provisions contained in this Limited Warranty are not intended to limit, modify, take away from, disclaim or exclude any mandatory warranty requirements provided by states, provinces or territories, including certain implied warranties. This warranty gives you specific legal rights, and you may also have other rights which vary depending on location.
Any questions about this Limited Warranty may be directed to
Hestan Commercial Corporation at
888-905-7463
Hestan Commercial Corporation
3375 E. La Palma Ave.
Anaheim, CA 92806
888-905-7463
