HESTAN Refreshment Center / Insulated Sink Installation Guide
- June 7, 2024
- HESTAN
Table of Contents
REFRESHMENT CENTER /INSULATED SINK
Installation Instructions
GRC / GRCHS / GIS / GISHS / AGIB
IMPORTANT – READ ALL INSTRUCTIONS BEFORE YOU BEGIN
INSTALLER SHOULD LEAVE THESE INSTRUCTIONS WITH THE HOMEOWNER
Some parts have sharp edges. Care must be taken when handling the various components to avoid personal injury. Wear gloves when handling. The unit is heavy and awkward to move around. Two people should work together to lift the unit into the cutout on your island.
TOOLS REQUIRED:
Work gloves
Safety glasses
Phillips screwdriver
Flat-blade screwdriver
7/16” wrench
Level
Tape measure
Plumbing tools for installation of Faucet & Drains
Inspect the product to verify that there is no shipping damage. If any damage is detected, call the shipper and initiate a damage claim. Hestan Commercial Corp. is not responsible for shipping damage. DO NOT discard any packing material (box, pallet, straps) until the unit has been inspected. Remove all exterior packaging materials, banding, tape, etc. Remove all protective film from the inside of your product. You may leave any exterior protective film on until after the installation is complete.
CONFIGURATIONS
Your new Hestan Refreshment Center / Insulated Sink is offered in 4 different
configurations, as well as a separate Ice Bin accessory. Other accessories are
available for purchase to further customize your product. Please visit the
Hestan website (www.hestanhome.com), or contact
your Hestan dealer for more information.
INSTALLATION
1. Consult the end of this instruction manual to determine the appropriate cutout dimensions for your product. The Hestan Refreshment Center / Insulated Sink is designed for outdoor use and features corrosion-resistant stainless steel construction. The faucet (GRC & GRCHS models) is also made of stainless steel and is outdoor-rated.
Some provisions must be made in the island for fresh water supply and proper drainage of the sink. It is recommended that the product be installed by a qualified technician or plumber in accordance with all local building and plumbing codes.
As seen in this typical installation, Hestan Access Doors are mounted
underneath the Refreshment Center & Ice Bin to allow access to the plumbing
underneath. This is not a requirement and your professional outdoor equipment
designer or installer may find another way to access this area.
2. Installation instructions for the faucet are packed in the carton with the faucet itself. It may be easier to mount the faucet before installing the sink. The large 3-1/2” hole in the sink can accommodate a standard basket strainer (not included), or a food-waste disposer (not included). Your qualified technician or plumber should install this item before mounting the sink.
INSTALLATION (continued)
3. If your unit includes a high shelf, install it and secure with 2 hex bolts
from underneath, and 2 screws on either side. Carefully lower the sink into
the cutout of your island countertop. Push the sink into position and apply a
small bead of clear silicone sealant around the perimeter of the outer frame
to your countertop. Your qualified technician or plumber may now assemble the
water and drain connections in accordance with local codes. In the absence of
local codes, the Uniform Plumbing Code should be followed.
4. Installation of the remaining components is detailed in the image
below.
MODEL GRCHS30 SHOWN
PARTS LIST
Please visit the Hestan website to access the parts list for your Hestan Outdoor product: www.hestanome.com.
SERVICE
All warranty and non-warranty repairs should be performed by qualified service
personnel. To locate an authorized service agent in your area, contact your
Hestan dealer, local representative, or manufacturer. Before you call, please
have the model number information ready. This information is shown on a
sticker affixed to one of the inside vertical surfaces of your product.
Hestan Commercial Corporation
3375 E. La Palma Avenue
Anaheim, CA 92806
888-905-7463
LIMITED WARRANTY
WHAT THIS LIMITED WARRANTY COVERS
Hestan Commercial Corporation (“HCC”) warrants to the original consumer purchaser of a Hestan outdoor product (the “Product”) from an HCC authorized dealer that the Product is free from defective materials or workmanship for a period of one (1) year from the date of original retail purchase or closing date for new construction, whichever period is longer (“Limited Warranty Period”). HCC agrees to repair or replace, at HCC’s sole option, any part or component of the Product that fails due to defective materials or workmanship during the Limited Warranty Period. This Limited Warranty is not transferable and does not extend to anyone beyond the original consumer purchaser (“Purchaser”). This Limited Warranty is valid only on Products purchased and received from an HCC authorized dealer in the fifty United States, the District of Columbia, and Canada. This Limited Warranty applies only to Products in non-commercial use and does not extend to Products used in commercial applications.
HOW TO OBTAIN WARRANTY SERVICE
If the Product fails during the Limited Warranty Period for reasons covered by
this Limited Warranty, the Purchaser must immediately contact the dealer from
whom the Product was purchased or HCC at 888.905.7463.
Purchaser is responsible for making the Product reasonably accessible for
service or for paying the cost to make the Product reasonably accessible for
service. Service is to be provided during normal business hours of the
authorized Hestan Commercial Service Provider. To the extent Purchaser
requests service outside of the normal business hours of the authorized Hestan
Commercial Service Provider, Purchaser will pay the difference between regular
rates and overtime or premium rates. Purchaser is required to pay all travel
costs for travel beyond 50 miles (one way) from the nearest authorized Hestan
Commercial Service Provider.
EXTENSIONS TO ONE YEAR LIMITED WARRANTY PERIOD:
In addition to the One-Year Limited Warranty, the following components have
extended warranty coverage as specifically set forth below:
- The Product is warranted to be free from defects in material and workmanship under normal noncommercial use and service for the lifetime of the Original Purchaser. This excludes surface corrosion, scratches, and discoloration which may occur during normal use and is limited to replacement of the defective part(s), with the Purchaser paying all other costs, including labor, shipping, and handling, as applicable.
- Where applicable, the stainless steel faucet carries its own warranty. Please review the warranty included in the packaging with the faucet.
WHAT THIS LIMITED WARRANTY DOES NOT COVER:
This Limited Warranty does not cover and HCC will not be responsible for and
will not pay for damage to or defects in any Product not purchased from an HCC
authorized dealer; color variations in color finishes or other cosmetic
damage; failure or damage from abuse, misuse, accident, fire, natural
disaster, commercial use of the Product, or loss of electrical power or gas
supply to the Product; damage from alteration, improper installation, or
improper operation of the Product; damage from improper or unauthorized repair
or replacement of any part or component of the Product; damage from service by
someone other than an authorized agent or representative of the Hestan
Commercial Service Network; normal wear and tear; damage from exposure of the
Product to a corrosive an atmosphere containing chlorine, fluorine, or any
other damaging chemicals; damage resulting from the failure to provide normal
care and maintenance to the Product; damage HCC was not notified of within the
Limited Warranty Period; and incidental and consequential damages caused by
any defective material or workmanship.
ARBITRATION:
This Limited Warranty is governed by the Federal Arbitration Act. Any dispute
between Purchaser and HCC regarding or related to the Product or to this
Limited Warranty shall be resolved by binding arbitration only on an
individual basis with Purchaser. The arbitration will be conducted by the
American Arbitration Association (“AAA”) in accordance with its Consumer
Arbitration Rules or by JAMS. The arbitration hearing shall be before one
arbitrator appointed by the AAA or JAMS. The arbitrator shall not conduct
class arbitration and Purchaser shall not bring any claims against HCC in a
representative capacity on behalf of others.
LIMITATION OF LIABILITY:
This Limited Warranty is the final, complete and exclusive agreement
between HCC and Purchaser regarding the Product.
THERE ARE NO EXPRESS WARRANTIES OTHER THAN THOSE LISTED AND DESCRIBED ABOVE. NO WARRANTIES WHETHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE SHALL APPLY AFTER THE LIMITED WARRANTY PERIOD STATED ABOVE. NO OTHER EXPRESS WARRANTY OR GUARANTY GIVEN BY ANY PERSON, FIRM OR CORPORATION WITH RESPECT TO THIS PRODUCT SHALL BE BINDING ON HCC. HCC ASSUMES NO RESPONSIBILITY THAT THE PRODUCT WILL BE FIT FOR ANY PARTICULAR PURPOSE, EXCEPT AS OTHERWISE PROVIDED BY APPLICABLE LAW.
HCC SHALL NOT BE LIABLE FOR LOSS OF REVENUE OR PROFITS, FAILURE TO REALIZE SAVINGS OR OTHER BENEFITS, OR ANY OTHER SPECIAL INCIDENTAL OR CONSEQUENTIAL DAMAGES CAUSED BY THE USE, MISUSE OR INABILITY TO USE THE PRODUCT, REGARDLESS OF THE LEGAL THEORY ON WHICH THE CLAIM IS BASED, AND EVEN IF HCC HAS BEEN ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. NO RECOVERY OF ANY KIND AGAINST HCC SHALL BE GREATER IN AMOUNT THAN THE PURCHASE PRICE OF THE PRODUCT.
WITHOUT LIMITING THE FOREGOING, YOU ASSUME ALL RISK AND LIABILITY FOR LOSS, DAMAGE OR INJURY TO YOU AND YOUR PROPERTY AND TO OTHERS AND THEIR PROPERTY ARISING OUT OF THE USE, MISUSE OR INABILITY TO USE THE PRODUCT NOT CAUSED DIRECTLY BY THE NEGLIGENCE OF HCC. THIS LIMITED WARRANTY STATES YOUR EXCLUSIVE REMEDY.
No oral or written representation or commitment given by anyone, including but not limited to, an employee, representative or agent of HCC will create a warranty or in any way increase the scope of this express Limited One Year Warranty. If there is any inconsistency between this Limited Warranty and any other agreement or statement included with or relating to the Product, this Limited Warranty shall govern. If any provision of this Limited Warranty is found invalid or unenforceable, it shall be deemed modified to the minimum extent necessary to make it enforceable and the remainder of the Limited Warranty shall remain valid and enforceable according to its terms.
INTERACTION OF LAWS WITH THIS LIMITED WARRANTY:
Some states, provinces or territories may not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages, so the above limitations or exclusions may not apply to you. Some states, provinces or territories may provide for additional warranty rights and remedies, and the provisions contained in this Limited Warranty are not intended to limit, modify, take away from, disclaim or exclude any mandatory warranty requirements provided by states, provinces or territories, including certain implied warranties. This warranty gives you specific legal rights, and you may also have other rights which vary depending on location.
Any questions about this Limited Warranty may be directed to
Hestan Commercial Corporation at
888-905-7463
RETAIN THIS MANUAL FOR FUTURE REFERENCE
Hestan Commercial Corporation
3375 E. La Palma Ave.
Anaheim, CA 92806
888-905-7463
©2020 Hestan Commercial Corporation P/N 015456 REV C
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>