DJO DONJOY X-ROM Op Knee Brace Instruction Manual

: June 17, 2024
: DJO

Table of Contents

DJO DONJOY X-ROM Op Knee Brace
Product Information
Product Usage Instructions
FAQ
Using Instructions
APPLICATION INFORMATION
CLEANING INSTRUCTIONS
WARRANTY
CONTACT
References
Read User Manual Online (PDF format)
Download This Manual (PDF format)

DJO DONJOY X-ROM Op Knee Brace

DJO-DONJOY-X-ROM-Op-Knee-Brace-product

Product Information

Specifications

Product Name	ACL/PCL/LCL/MCL Brace
Intended Use	To aid in immobilization and protected range of motion

associated with ACL, PCL, LCL, and MCL surgeries and meniscal
repairs
Size| Adjustable to fit various leg sizes

Product Usage Instructions

Before Using the Device

Before using the device, please read the following instructions completely and carefully. Correct application is vital to the proper functioning of the device.

FAQ

Q: What is the intended use of this product?
The intended use of this product is to aid in immobilization and protected range of motion associated with ACL, PCL, LCL, and MCL surgeries and meniscal repairs.
Q: How should I determine the range of motion settings?
The range of motion settings, frequency, and duration of use should be determined by your prescribing healthcare professional. Please consult them for specific instructions.
Q: What should I do if I experience pain or unusual reactions while using the product?
If you experience any pain, swelling, sensation changes, or any unusual reactions while using this product, consult your medical professional immediately.

BEFORE USING THE DEVICE, PLEASE READ THE FOLLOWING INSTRUCTIONS COMPLETELY AND CAREFULLY. CORRECT APPLICATION IS VITAL TO THE PROPER FUNCTIONING OF THE DEVICE.

Using Instructions

DJO-DONJOY-X-ROM-Op-Knee-Brace-fig-1 DJO-
DONJOY-X-ROM-Op-Knee-Brace-fig-2

INTENDED USE/INDICATIONS: To aid in immobilization and protected range of motion associated with ACL, PCL, LCL, and MCL surgeries and meniscal repairs. This product was designed to help complement the variety of medical treatments common to the above afflictions. The range of motion settings, frequency and duration of use should be determined by your prescribing healthcare professional.

CONTRAINDICATIONS: None
WARNINGS AND CAUTIONS: If you experience any pain, swelling, sensation changes, or any unusual reactions while using this product, consult your medical professional immediately.

APPLICATION INFORMATION

Unfasten the strap ends near the black buckles and open the brace flat by pulling both uprights apart.
Place the leg on top of the flat brace. A shorter upright is applied to the thigh. Adjust the brace until each upright is aligned to the centerline of the medial and lateral sides of the leg and the centre of the hinge is aligned with the centre of the knee joint.
Telescope sliders by depressing the slider button until the desired length is reached. The top and bottom sliders should be adjusted first, followed by the sliders closest to the knee (note that inner sliders cannot be adjusted until the outer sliders are moved to provide sufficient clearance). Ensure that both bars are equal in length and that each strap slider is indexed to the same position on each upright.
Adjust the strap lengths:
- Ensure the tab is lifted from the strap, allowing the strap to move freely (see arrow position A in Figure 4)
- By pulling the strap away from the body, remove slack from the backside of the brace (see arrow position B in Figure 4)
- Ensure uprights are aligned on the medial and lateral sides of the leg
- Lower the tab and apply pressure to secure the strap
Attach each of the black buckles. Tighten straps by pulling on loose ends. Remove the excess strap and reposition the alligator strap end to a new edge of the strap. Secure strap-end to strap.
A) Adjust the hinge by pulling the Flexion and Extension stops outward and rotating until the desired angle aligns with the button centre. Release stops and ensure they are fully inserted.
- B) Utilize the quick-lock feature at -10, 0, 10, 20, or 30 degrees, by aligning the red arrow with the desired degree and sliding the red quick-lock button inward until the lock is engaged. Ensure uprights do not rotate. If another lock setting is required, see step 6 and ensure both the Flexion and Extension buttons are set at the same angle setting.
To remove the brace, release each buckle. A brace can then be re-applied as a single unit.

OTHER ADJUSTMENTS: The hinge bars may be bent to add varus or valgus contouring. Bend each bar by holding the thigh/calf bar firmly against a solid surface and apply gentle and constant pressure to the hinge in the direction desired. Bend each side bar an equal amount above and below the hinge. For optimal ease of application post-operatively, pre-fit the brace before surgery if possible.
STRAP REPLACEMENT: Should straps require replacement, carefully use scissors to cut away the strap where it connects to the slider. Insert the new strap and secure it. Contact DJO for the X-ROM Replacement Straps Kit.

CLEANING INSTRUCTIONS

Hand wash foam liners in water (30°C) with mild detergent. Rinse thoroughly.
AIR DRY only, do not heat dry.
Regular cleaning of the brace is recommended.
Always consult your physician or therapist before altering the brace.

COMPOSITION: Nylon 50%, Aluminum 40%, Polypropylene 5%, Delrin 3%, Stainless Steel 2%.

WARRANTY

DJO, LLC will repair or replace all or part of the unit and its accessories for material or workmanship defects for six months from the date of sale.

Rx ONLY.

INTENDED FOR SINGLE PATIENT USE.
NOT MADE WITH NATURAL RUBBER LATEX.

NOTICE: WHILE EVERY EFFORT HAS BEEN MADE IN STATE-OF-THE-ART TECHNIQUES TO OBTAIN THE MAXIMUM COMPATIBILITY OF FUNCTION, STRENGTH, DURABILITY AND COMFORT, THIS DEVICE IS ONLY ONE ELEMENT IN THE OVERALL TREATMENT PROGRAM ADMINISTERED BY A MEDICAL PROFESSIONAL. THERE IS NO GUARANTEE THAT INJURY WILL BE PREVENTED THROUGH THE USE OF THIS PRODUCT.

CAUTION: FEDERAL LAW (U.S.A.) RESTRICTS THIS DEVICE TO SALE BY OR ON THE ORDER OF A LICENSED HEALTH CARE PROFESSIONAL.