baby trend Expedition 2 In 1 Stroller Wagon Instruction Manual
- October 30, 2023
- baby trend
Table of Contents
Read all instructions BEFORE assembly and USE of product.
KEEP INSTRUCTIONS FOR FUTURE USE.
Expedition® 2-in-1 Stroller Wagon
Instruction Manual
CW01XXX
WARRANTY
DO NOT RETURN YOUR PRODUCT TO THE STORE. PLEASE CONTACT BABY TREND® FOR
REPLACEMENT PARTS, SERVICE AND REPAIR. The Baby Trend® warranty covers
workmanship defects within 1 year of purchase. Any product which has been
subjected to misuse, abuse, abnormal use, excessive wear and tear, improper
assembly, negligence, environmental exposure, alteration or accident, or has
had its serial number altered or removed invalidates all claims against the
manufacturer. Any damage to property during installation is the sole
responsibility of the end user.
Customer Service Department can be contacted at 1 (800) 328-7363 Monday
through Friday between 8:00 a.m. and 4:30 p.m. (PST). Return Authorizations
are required prior to returning product(s) to Baby Trend®. Please visit
http://babytrend.com/pages/limited-warranty for complete warranty details.
PARTS
Check that you have all the parts for this model before assembling the stroller.
BABY TREND® CUSTOMER SERVICE
The Customer Service Department can be contacted at 1 (800) 328-7363 Monday
through Friday between 8:00 a.m. and 4:30 p.m. (PST). Return Authorizations
are required prior to returning product(s) to Baby Trend®.
WARNING
WARNING: Please follow all of these instructions to ensure the safety of
your child. Keep these instructions for future reference.
WARNING: Failure to follow these instructions could result in serious
injury or death. Avoid serious injury from falling or sliding out, always use
the safety harness and ensure that the children are properly positioned
according to these instructions.
WARNING: Never leave children unattended.
WARNING: Care must be taken when folding and unfolding the stroller to
prevent finger entrapment.
- CAUTION: NEVER run or jog with this stroller. This stroller is designed for up to 2 children only. Use with more than 2 children may cause an unbalanced condition which can injure/harm your child. Children must be at least 6 month old and be able to sit upright unassisted.
- Purses, shopping bags, parcels, diaper bags or accessory items may change the balance of the stroller and cause a hazardous, unstable condition.
- Be certain the stroller is completely opened and locked in place before allowing a child near the stroller.
- The maximum weight that can be carried in the child tray is 5 lbs (2.26 kg).
- The maximum weight that can be carried in the soft parent organizer is 2 lbs (0.90 kg).
- The maximum weight capacity of the stroller is 55 lb (24.94 kg) for each child. The maximum weight capacity of the stroller in combination with any accessories is 110 lbs (49.89 kg) total. Exceeding the weight limit will cause excessive wear and stress on the stroller and may cause a hazardous unstable condition to exist.
- NEVER use the stroller on stairways or escalators.
- NEVER use the stroller with roller skates, in-line skates, skateboards or bicycles.
- NEVER allow your stroller to be used as a toy.
- To clean use only mild household soap or detergent and warm water on a sponge or clean cloth.
- Check your stroller for loose screws, worn parts, torn material or stitching on a regular basis. Replace or repair parts as needed.
- Discontinue use of stroller should it malfunction or become damaged.
ASSEMBLY ASSEMBLAGE
IMPORTANT ! To ensure safe operation of your product, please follow these
instructions carefully. Please keep these instructions for future reference.
IMPORTANT ! Before assembly and each use, inspect this product for
damaged hardware, loose joints, missing parts or sharp edges. NEVER use if any
parts are missing or broken.
IMPORTANT ! Adult assembly is required.
**WARNING: Care must be taken when unfolding the stroller to prevent
finger entrapment.
CAUTION:** Do not allow children near stroller while unfolding.
FRAME SETUP
To attach the wheels, unfold stroller as described in the following
section:
- • Release the fold latch (Fig. 1a).
• Unfold the stroller frame by pulling the stroller handle upward until it clicks into locked position (Fig. 1b).
• The RED indicator on the handle will not be visible when stroller is fully open. If RED indicator are visible check open position lock is engaged before continuing. (Fig. 1c).
FRONT WHEELS
- • Insert front wheel axle pin into the wheel hub until the wheel locks
firmly into place. Repeat on other side. (Fig. 2a).
NOTE: Pull on the wheel assembly to ensure that it is securely attached to the stroller.
REAR AXLE-WHEELS
Attach the rear axle assembly and wheels as follows:
- • Position stroller with rear leg tubes facing upward. Place the rear axle
with wheels over the rear legs and apply downward pressure on both sides.
Ensure both sides lock into place (Fig. 3a).
NOTE: NEVER use stroller if wheels do not lock into place. If you need assistance, please contact our customer service department at 1-800-328-7363, M-F, between 8am and 4:30pm, PST.
SOFT PARENT ORGANIZER
WARNING: Do not place hot liquids or more than 2 lb. (0.90kg) pounds in the
parent tray. Serious burns or unstable conditions can result.
4) • Strap In The Soft Parent Organizer:
Use the hook and loop to hang the soft parent organizer onto the stroller
handle. Follow illustrations 1-3 (Fig. 4a). Be sure to fasten tightly.
CHILD TRAY
**WARNING:** Do not place hot liquids or more than 5 pounds in the child tray. Serious burns or unstable conditions could result.
- • Attach child tray by lining up the corresponding slots located on
stroller frame. Slide down into position until locked into place (Fig. 5a).
NOTE: Check to make sure the child tray is secure before using.
CANOPY
- • To install the canopy: Add the canopy frame into the designated slots
located on the child tray (Fig. 6a).
• To open the canopy: Behind the main fold mechanism use the strap and snap closure to anchor the canopy. Firmly spread out both sides of the canopy (Fig 6b).
• Install mosquito net: Unzip and pull out the net from the storage pocket. Stretch the net around the top edge of the frame and hook each corner to the the circle tabs. Repeat for the other side and ensure to hook the net to all 4 tabs (Fig. 6c).
• To store away the mosquito net: Lift the mosquito net at the elastic end and start to roll toward canopy. Locate the zipper attached to canopy end and connect zipper to track. Continue to tuck canopy into pocket while zipping pocket closed (Fig. 6d).
NOTE: Tuck and Zip in sections.
• To remove the canopy: Press the tab on each end of the canopy, and lift up
the entire canopy from the bottom ends slots of the child tray (Fig. 6e).
• To remove the child tray: push the tabs outward and pull out the child tray
(Fig. 6f). NOTE: The canopy may also be installed without the child tray.
Insert the ends into holes.
PULL HANDLE STORAGE
- • TO USE THE HANDLE: Locate the handle underneath the frame and press the
release button to unlatch. Pull the bar completely out of the frame (Fig. 7a).
Rotate up to desired position (Fig. 7b).
• TO PUT IT AWAY: Reverse step (Fig. 7a) ensure to push the handle completely
in until it clicks into position.
NOTE: Ensure the handle is resting on the storage hooks (Fig. 7c).
FOLD PLIER
TO FOLD STROLLER
**WARNING: Care must be taken when folding the stroller to prevent
finger entrapment.
CAUTION:** Do not allow children near stroller while folding.
- • Close the canopy by reversing (Fig. 6b).
• To use the double lock feature: (1) push the safety lock up. (2) Lift up the trigger to hold the safety lock into place. (3) Pull both triggers together (Fig. 8a).
• Push down on the stroller handle until the stroller is completely folded.
• Ensure the fold latch clicks and secures the stroller closed (Fig. 8b).
TO UNFOLD STROLLER
9) • Release the fold latch (Fig. 9a). Unfold the stroller frame by pulling
the stroller handle upward until it clicks into locked position (Fig. 9b). The
RED indicator on the handle will not be visible when stroller is fully open.
If RED indicator are visible check open position lock is engaged before
continuing.
SAFETY
TO USE THE SAFETY HARNESS
WARNING: Avoid serious injury from falling or sliding out. Always use the
safety harness.
STRANGULATION HAZARD:
Child can strangle in loose straps. Never leave child in seat when straps are
loose or undone.
- • The child tray is not designed to hold the child in the stroller. Stay
near and watch child during use. NEVER leave child unattended.
• Place the crotch strap between your child’s legs. Insert the Harness Buckles into the Center Clasp with the Button.
• Adjust waist straps for your child’s comfort and safety by sliding buckles in either direction. Safety straps are to fit snug around your child (Fig. 10a).
TO RELEASE SAFETY BELT
- • Push Button on Center Clasp, the two Harness Buckles will pop free (Fig. 11a).
MAINTENANCE
BRAKES
WARNING: Always set brakes when the stroller is not being pushed so that
the stroller will not roll away. NEVER leave stroller unattended on a hill or
incline as the stroller may slide down the hill.
- • To engage brakes, apply light downward pressure to the brake lever
located on each rear wheel. The stroller may require slight forward or
rearward movement in order to line up the teeth on the brake with each wheel
brake cluster (Fig. 12a).
NOTE: Check that the stroller will not move and that both brakes are properly applied.
• To release, gently lift up on the brake lever.
WAGON FABRIC
- • To detach the fabric: for cleaning or replacement, unzip from the front
and rear of the wagon frame (Fig. 13a).
• Through the pocket opening, remove the D-Rings straps from the fabric near the bottom front and rear frames to unthread the harness straps (Fig. 13b). Remove the screws on the underside of the frame (Fig. 13c).
• To reattach the fabric: ensure that the fabric is realigned to the corresponding front and rear end frames.
• Through the pocket opening, Insert the D-Ring straps through the slots. The straps must be secured completely with the D-Ring. Refer to (Fig. 13b).
• To ensure the fabric is securley attatched, the zippers should be zipped and the hook and loop fasteners are attatched (Fig. 13a).
NOTE: Check for worn parts, torn material, or stitching on a
regular basis. Replace or repair parts as needed.
REAR AXLE WHEEL REMOVAL
Attach the rear axle assembly and wheels as follows:
14) • To release the entire rear wheel assembly, push in the rear wheel
release. The wheel easily detaches from the bushing (Fig. 14a).
• If replacing the rear axle, press the pin on each side behind the wheel hub.
Pull the rear axle out from the hub (Fig. 14b).
NOTE: NEVER use stroller if wheels do not lock into place. If you need assistance, please contact our customer service department at 1-800-328-7363, M-F, between 8am and 4:30pm, PST.
CARE AND MAINTENANCE
- Cleaning Seat Pad: Spot clean only – Surface wash small spots with mild solution of soap and water. Rinse with water to remove soap solution. Wipe or air dry.
- Cleaning Stroller: Surface wash stroller frame, plastic parts and fabric with mild solution of soap and water. Wipe surfaces with water to remove soap solution. Wipe or air dry.
- Check your stroller for loose screws, worn parts, torn material or stitching on a regular basis. Replace or repair parts as needed.
Baby Trend, Inc.
13048 Valley Blvd.
Fontana CA 92335
1-800-328-7363
(8:00 a.m. ~ 4:30 p.m. PST)
www.babytrend.com
Copyright © 2023, Baby Trend Inc., All Rights Reserved. Tous droits réservés.
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>