Westfalia Km 3300 Mini Kitchener With Rotisserie And Circulating Air Instruction Manual

Km 3300 Mini Kitchener With Rotisserie And Circulating Air
Instruction Manual

KM 3300
Mini kitchener with rotisserie & circulating air

Product description

1. large heating plate, 180 mm Ø

2. small heating plate, 145 mm Ø

3. oven chamber

4. control panel

5. screws for fi xation of inner glass plate

6. oven door with handle

7. removable inner glass plate

8. heating elements

9. insertion levels

10. support for rotisserie spit

11. drive shaft for rotisserie spit
    

12. grill grid

13. roasting/baking tray

14. crumb tray

15. rotisserie spit with fi xing brackets and screws

16. handle for rotisserie spit

17. handle for roasting/baking tray and grill grid

Control panel

oven

A. rotary knob for temperature setting
B. temperature pilot lamp for oven
C. rotary knob for function setting

cooktop

D. step switch for large heating plate
E. operation pilot lamp for heating plates
F. step switch for small heating plate

Introduction

We are pleased you decided in favour of this versatile mini kitchener and would like to thank you for your confi dence. Its easy operation and wide range of applications will  certainly fi ll you with enthusiasm as well. To make sure you can enjoy using this appliance for a long time, please read through the following notes carefully and observe  them. Keep this instruction manual safely. Hand out all documents to third persons when passing on the appliance. Thank you very much.
Intended use
The appliance is designed to be used in the household and similar areas, like for example:
– staff kitchens in shops, offi ces and other small commercial areas,
– agricultural holdings,
– by guests in hotels, motels, breakfast pensions and further similar living environments.
Other uses or modifi cations of the appliance are not intended and may constitute considerable risks of accident. For damage arising from any improper use, the manufacturer does not assume liability.
The appliance is designed for preparing dishes (domestic use only). It is qualifi ed for cooking, baking, roasting, defrosting, crisping up, rewarming, melting, gratinating and  grilling food (in the kitchen, in the offi ce etc.).
Other uses or modifi cations of the appliance are not intended and harbour considerable risks. For damage arising from not intended use, the manufacturer does not assume  liability. The appliance is not designed for commercial use.

Technical data
Only connect the appliance to an isolated ground receptacle installed according to regulations. The rated voltage must comply with the details on the rating label. Only  connect to alternating current!

Scope of supply
Check the scope of supply for completeness as well as the soundness of the product and all components (see product description page 2) immediately after unpacking.
Packing material
Do not simply throw the packing material away but recycle it.
Deliver paper, cardboard and corrugated cardboard packing to collecting facilities.
Also put plastic packing material and foils into the intended collecting basins.

In the examples for the plastic marking PE stands for polyethylene, the code fi gure 02 for PE-HD, 04 for PE-LD, PP for polypropylene, PS for polystyrene

Disposal/recycling
This marking indicates that this product should not be disposed with other household wastes throughout the EU. To prevent possible harm to the environment or human  health from uncontrolled waste disposal, recycle it responsibly to promote the sustainable reuse of material resources.
To return your used device, please use the return and collection systems or contact the retailer where the product was purchased. They can take this product for  environmental safe recycling.

For your safety

CAUTION: Read all safety advices and instructions!
Non-observance of the safety advices and instructions may cause electric shock, fire and/or bad injuries and burns!
General safety advices

• Keep the appliance and its cord out of reach of children less than 8 years.

• This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and  knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Never leave the  appliance unattended during operation.

• Cleaning and user maintenance shall not be made by children unless they are older than 8 and supervised.

• Children shall not play with the appliance.

• Packing material like e. g. foil bags should be kept away from children.

• The appliances are not intended to be operated by means of an external timer or separate remote-control system.

• Prior to each use, check the appliance and the accessories for soundness. It must not be operated if it has been dropped or shows visible damage. In these cases, the  power supply must be disconnected and the appliance has to be checked by a specialist.

• When laying the power cord, make sure that no one can get entangled or stumble over it in order to avoid that the appliance is pulled down accidentally.

• Keep the power cord away from hot surfaces, sharp edges and mechanical forces. Check the power cord regularly for damage and deteriorations.
  Damaged or entangled cords increase the risk of an electric shock.

• Only disconnect the unit by pulling the plug, not the power cord!

• Never immerse the appliance, power cord and power plug in water for cleaning.

• Do not store the appliance outside or in wet rooms.

• This electrical appliance complies with the relevant safety standards. In case of signs of damage to the appliance or the power cord, unplug the appliance immediately.  Repairs may be executed by authorised specialist shops only.
  Improper repairs may result in considerable dangers for the user.

• If the supply cord is damaged, the manufacturer or its service agent or a similarly qualified person in order to avoid a hazard must replace it.

• Improper use and disregard of the instruction manual void all warranty claims.

Safety advices for using the appliance
CAUTION: Hazard of injury and burns!

• The temperature of the door or the outer surface may be high when the appliance is operating.

• Hot surfaces firstly stay hot after switch-off!
  Thus, act with caution:

• We recommend using the enclosed handle as well as pot cloths and appropriate grill cutlery!

• Do not use the appliance’s upper side as depositing rack or working top as it will get hot when operating the appliance! As protection against fire, do generally not put  objects made of paper, plastic, fabric or other inflammable material on hot surfaces!

• Do not cover the bottom of the oven chamber and the heating elements with aluminium foil!

• Fat and oil can ignite when overheated. Therefore, food containing fats and oils may only be prepared under supervision!

• Only use convenient pots and pans of suitable diameter (also fireproof glass or ceramic) on the heating plates.

• If the bottom of the cooking vessel is too small or uneven, you will waste energy and do not use the maximum heat output.

• Please ensure that the heating plates, the oven and the accessories are clean and dry before operating!

• Only use heat-resistant containers made of metal, fireproof glass, ceramic or silicone material for roasting and baking in the oven!

• Caution! Hazard of fire! Always put food from which fat may drip on the roasting/baking tray to avoid that the fat inflames at the heating element.
  Bread toasted too long can also inflame!

• Never splash cold water on the hot oven door!

• When opening the oven door, hot steam may escape!

• Appliance and accessories must have cooled completely before cleaning or moving them!

• The appliance may only be operated with a door completely assembled!

• Use original accessory parts only.

• Do not use the appliance as space heater.

• Observe the following when setting up the appliance:
  ° Place the appliance with its rear to the wall. Leave a ventilation distance of 4 cm.
  ° Place the appliance on a heat-resistant, stable and even surface (no varnished surfaces, no table cloths etc.).
  ° Place it beyond children’s reach.
  ° Leave a ventilation distance of at least 4 cm to all sides and 1 m above the appliance to avoid damage by heat or fat splatters and to grant an unobstructed work area.  Unhindered air supply has to be ensured.
  ° Do not operate the appliance in the vicinity of sources of heat (oven, gas flame etc.) or in explosive environments, where inflammable liquids or gases are located.
  ° Caution! Hazard of fire! This appliance is not qualified for installation.

• Pull the power plug after each use for safe switch-off.

Prior to initial use

For a start, please clean the appliance as well as all accessory parts. For information that is more detailed please refer to chapter “Cleaning and maintenance”. Moreover, it is  necessary to heat up the heating plates resp. the heating elements for a short time to ensure the proper functioning.
Heating-up the heating plates:

• Heat up the heating plates without a pot at maximum setting for approx. 5 minutes. This will give the coating its optimal protection effect.
• After the appliance has cooled down, please clean the heating plates with a moist cloth. Heating-up the oven:
• Please clean all removable accessory parts in warm water with some dishwashing detergent.
• Prior to initial use, heat up the oven chamber for about 15 minutes with setting “upper and lower heat with circulating air” at maximum temperature (230 °C) in order to  burn in the protective coating of the heating elements.
• After the appliance has cooled down, clean the interior oven with a moist cloth.
  NOTE: Please do not be bothered by the slight, harmless smoke and smell that will be generated for a short while when starting the appliance for the first time. Make  sure that the room is well-aerated during this time.

Operating the appliance

CAUTION: Hazard of injury and burns!

• Prior to operation, ensure that the crumb tray is inserted below the lower heating element!
• Heating plates, surfaces of the casing, trays, grid, crumb tray and accessory parts are getting hot during use!
• Hot surfaces firstly stay hot after switch-off!
• Make sure the food touches neither the upper, nor the lower heating rod when inserting it!
• On the heating plates, only use cooking vessels of suitable diameter!

Connecting the appliance to the power supply
ATTENTION: Before connecting the appliance to the power supply, make sure that all rotary knobs are in position „0“!

• Connect the power plug with an adequately protected power socket.
• The appliance is now ready for operation.

Operating the heating plates
a. Switching the heating plates ON/OFF

• Each heating plate is equipped with a 4-step switch:
  Level 0: Off
  Level 1: Cooking small quantities, warming-up, keeping warm
  Level 2: Cooking larger quantities, roasting, stewing
  Level 3: Full power to start cooking

Nominal consumption:| Large heating plate 180 mm Ø| Small heating plate 145 mm Ø
---|---|---
level 1|  400 W| 300 W
level 2|  600 W| 450 W
level 3|  1000 W| 750 W
| • The selection of the function for the large heating plate is done via the third rotary knob (D) from above.
• Select the desired level by turning the switch to the right.
• The selection of the function for the small heating plate is done via the fourth rotary knob (F) from above.
• Select the desired level by turning the switch to the right.
• Turn the rotary knob to position ”0“ once the cooking process is finished!
NOTE: The appliance is equipped with a pilot lamp (E). Once both heating plates are switched on, the  pilot lamp glows permanently. The pilot lamp goes out when both plates are switched off.
---|---

Operation of the oven
a. Insert the crumb tray into the oven
• Before operating the oven, make sure, that the crumb tray is inserted below the lower heating element.
b. Preparing the oven for use
• Open the oven door (do not use the open door as storage place!).
• Place the prepared food on the grill grid or roasting/baking tray and insert it in the provided insertion levels of the oven chamber. Close the oven door.
NOTE for using the grill grid: The special shape of the insertion levels in the front area prevents the grid from being pulled too far out of the appliance by mistake.
Insert the grill grid with the grill bars upwards into one of the insertion levels. After approx. 10 cm, the „removal lock“ must be overcome by slightly lifting or angling the grill grid.

c. Setting the oven temperature

| • Set the desired oven temperature by means of the upper rotary knob (A).
• Turn the rotary knob (A) to position ”MIN“ once the baking process is finished!
---|---

d. Setting the oven function – switching ON/OFF

| • Set the desired oven function by means of the second rotary knob (C) from above.
• Select the desired function by turning the knob to the left or to the right.
• The interior illumination of the oven lights up and the oven starts operation.
• Turn the rotary knob to position ”0“ once the baking process is fi nished!
NOTE: The appliance is equipped with a pilot lamp (B). Once one of the functions is selected,  the pilot lamp glows permanently. The pilot lamp is only deactivated when the oven is switched off.
---|---

Upper and lower heat with circulating air
For baking and roasting on an insertion level, where heating is provided evenly from above and below. It is particularly suitable for baking cake, cheesecake and biscuit cake,  for preparing casseroles, roasts, game and fi sh as well as for all classic recipes.
A switched-on fan distributes the heat evenly in the oven chamber.
Upper heat with circulating air
For preparing of casseroles and gratins, which should have a crispy surface.
For grilling barbecue foods (e.g. steaks, sausages, roll roast, chicken, etc.) as well as for grilling. A switched-on fan distributes the heat evenly in the oven chamber. When  grilling, we recommend fi lling half of the roasting/baking tray with water and sliding it into the lowest insertion level as a drip tray. Dripping grease is absorbed, the appliance remains clean and the rising steam will make your barbecue food especially tender and juicy.
Upper/lower heat
For baking and roasting on an insertion level, where heating is provided evenly from above and below. It is particularly suitable for baking cake, cheesecake and biscuit cake,  for preparing casseroles, roasts, game and fi sh as well as for all classic recipes.
Upper heat with rotisserie function
This function is suitable for grilling meat, fi sh, vegetables as well as rotisserie grilling of chicken, spit roast, etc .; Proceed as described under point „Grilling with rotisserie  function „described.
Important! Slide the roasting/baking tray into the lowest insertion level as a drip tray.
Dripping grease is absorbed and the appliance remains clean. We also recommend filling half of the roasting/baking tray with water; the rising steam will make your barbecue  food especially tender and juicy.
Lower heat with circulating air (pizza function)
This function is particularly suitable for anything that should be crispy from the bottom, such as pizza, tarte fl ambé, French fries etc. We recommend using the function  “upper and lower heat” (with or without circulating air) fi rst and switch to this function for the last 5 minutes. A switched-on fan distributes the heat evenly in the oven  chamber.

e. Taking out the cooked food

• Open the oven door (do not use the open door as storage place!).
• Take the ready food out of the oven chamber. If you want to take the roasting/baking tray, the grill grid or the rotisserie spit out of the oven in hot condition, use the  included handle or protect your hands with potholders or a grill glove. Close the oven door.
  NOTE for using the grill grid: The special shape of the insertion levels in the front area prevents the grid from being pulled too far out of the appliance by mistake.
  Remove the grill grid as described above. Overcome the „removal lock“ by slightly lifting or angling and remove the grill grid.

Completely switching off the appliance

| • For switching off the appliance turn both rotary knobs of the heating plates as well as  the rotary knob for temperature and function of the oven to position „0“ or respectively „MIN“.
• For a safe switch off disconnect the power plug after each use!
---|---

Temperature pilot lamp for oven

The appliance is equipped with a temperature pilot lamp (B) for the oven. When the pilot lamp goes off, the set temperature is reached. Cycling on and off during operation,  the pilot lamp shows the thermostatic regulation of the temperature.
ATTENTION: This means that the pilot lamp does not glow for some time, although the oven is  switched on. Therefore, make sure that all the knobs have been set back  to “0” once the baking procedure is finished.

Grilling with rotisserie function

The rotisserie spit allows preparing delicious grilled chicken and other kinds of spit-roast (e. g. pork knuckles). For this, proceed as follows:

• It is important to defrost frozen chicken completely before grilling. Then wash and pat them dry.

• Depending on the recipe and your personal taste, rub the food to be grilled with oil and spices.
  Tip: Always mix paprika and curry with some oil or season the meat at the end of the grilling time, as these spices burn easily and taste bitter then.

• Slide one of the fixing brackets on the spit and tighten it with the screw. Now skewer the prepared meat onto the spit centrally until it is pushed firmly into the first fixing bracket. Then slide the second fixing bracket on the spit and push it firmly into the roast. Also, tighten this screw.

• Check that the food to be grilled is properly centred on the spit.

• To prevent protruding chicken parts from burning, the joints and wings must be bond together with a heatproof and food safe string (e. g. natural cotton string).
  Tip: To avoid a too fast browning of prominent parts, you may wrap delicate areas with unsalted rashers.

• Important! Insert the roasting/baking tray into the lowest level. In this way, any grease dripping down will be collected and the oven’s bottom stays clean.
  Tip: We recommend filling half of the roasting/baking tray with water; the rising steam makes your grill food especially tender. However, should you prefer your chicken  crispy outside, do not fill any water into the roasting/baking tray.

• By means of the rotisserie handle, you can now lift the rotisserie assembly into the oven. Firstly, insert the spit with one end in the hole on the right hand side of the  interior oven and then place it in the support provided on the left hand side.

• Before closing the oven door, make sure the spit with the chicken/s is positioned correctly.
  Caution! Hazard of fire! Make sure that the meat to be grilled is rotating properly and that it does not touch the heating elements – otherwise the meat might catch fire.

• Select the function: ‘Upper heat with rotisserie spit’ (position “I”) at maximum temperature.

• Per each kilogram chicken, you may reckon with a grilling time of about 60 minutes.
  Tip: A spit-roast chicken is ready when piercing the drumstick with a needle (no knife!) only clear meat juice comes out, without any signs of blood.

• In case the skin of the chicken is getting blisters, reduce the temperature and paint the blisters with some oil.

• After the grilling time has been finished, it is easy to remove the rotisserie spit from the oven by lifting it out using the special handle for the spit and to place it on a large chopping board then.

Interior illumination of the oven

This product contains a light source of energy efficency class G. The lamp glows during the whole operation time of the oven. Once the operating time is over, the lamp turns out automatically.

How to change the oven light

| • ATTENTION: Always unplug the power cord before changing the lamp!
• ATTENTION: Before changing the lamp, always allow the appliance to cool down!
---|---

• Carefully unscrew the lamp cover, unscrew the defective illuminant.
• Insert a new bulb (heat resistant – 220-240 V ~ 25 W, E14, T 300 ° C) into the thread and screw it in by hand.
• Then insert the lamp cover into the thread and screw in hand-tight.

Disassembling and assembling the oven door

The oven door is designed in such a way that, under normal conditions of use, there is no impurity between the glass plates of the double glazing. The oven door should only  be disassembled and cleaned if heavily soiled. Proceed as follows:

Disassembling of the oven door

| • ATTENTION: Always unplug the power cord before assembling the oven door!
• ATTENTIOPN: The appliance may be operated only with completely assembled door!
---|---

• Dry the glass plates and seal thoroughly before installation!

• Place the glass plate on a soft surface. Make sure, that the larger side of the two plastic hulls is up.

• Position the gasket properly around the glass. Make sure the fl at and narrow side of the gasket is up.

• Place the glass plate with gasket on the oven door.
  Make sure that the larger side of the two plastic hulls is up. The glass plate has to be fl ush over the two screw fi xings.

• Check the gasket all around for correct seating and readjust if necessary.

• Insert the two screws and hand-tighten clockwise.

• Close the oven door.

Cleaning and maintenance

• Before cleaning, always unplug the appliance and let all parts cool down!
• Never immerse appliance, power cord and plug in water or clean them under running water!
• Due to its non-stick coating the oven is very easy to clean. Wipe the casing, the oven chamber and the oven door with a moist cloth and wipe dry.
• The crumb tray can be taken out and cleaned with hot dishwater.
• The accessories can be cleaned in warm water with some dishwashing detergent or in the dishwasher.
• Always keep heating plates dry since dampness and steam will result in rust formation. Special care products are available in specialist shops.
• Make sure no steam or water can infi ltrate the underside.
• Do not use abrasives or dissolvents or sharp objects!
• Do not use steel wool or scouring pads!
• Never use oven sprays!
• Never use a steam jet appliance for cleaning the appliance and the accessories!

Tips and notes

• Always pre-heat the oven until the desired temperature has been reached before you put in the food to be cooked and place the food in the middle of the roasting/baking tray.
• The best cooking results are achieved if you turn the roasting/baking tray after about half of the cooking time, so that the food from the rear gets shifted to the front.

References

• Startseite - ROMMELSBACHER ElektroHausgeräte GmbH

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>