OPUS OP13 Hybrid Caravans User Manual

OPUS OP13 Hybrid Caravans User Manual

My OP13 Hybrid Caravan

CLAIM: By receiving this handbook, you confirm that you will/have read and agree to all the terms and conditions contained within and that you understand the correct way to use, maintain and care for your OP13.

IMPORTANT: Please go to https://www.opuscamper.com.au/warranty/ to register and activate your warranty before you read on.

VEHICLE IDENTIFICATION NUMBER (VIN)

About Your Vehicle Identifpication Number
Every OPUS@ has a Vehicle Identification Number (VIN). The VIN Plate can be found on the exterior of your OPUS@ to the left of the door secured, to the draw bar. We recommend making a note of your VIN in the template below. This will be required by insurance companies.

SPECIFICATIONS – OP13

DIMENSIONS – OP13

HITCHING & TRAILER ELECTRICS

BRAKE SET UP

Setting Up your Caravan

Awning Setup

Water System

Hot water is provided via the hot water system on the driver side underneath the king bed.

The OPUS® is fitted with a grey water tank. All external kitchen, internal sink and the ensuite are directly connected to grey water tank. Grey water tank gauge is located in the main switch board. Drain for the grey water tank located in the driver side as shown below.

Hot Water Service

Gas System

The outlet on the driver’s side is a gas BBQ (not supplied) while the outlet on the passenger side is to supply the 4 burner cook top in the slide-out kitchen. This hose is fitted to the cook top and is located under the sink. Both points should have the protective plugs inserted when not in use.

When the gas is not in use the shut off valve and gas bottle should be in the off/closed position. Gas fumes inside a caravan could result in unconsciousness, brain damage or even death. Follow safe operating procedures with gas at all times:

• Ensure good ventilation throughout, at ALL times
• Do not use any other gas systems than those provided with the OPUS®
• Always turn off the shut off valve IMMEDIATELY after use.

240 Volt Mains Power

12 Volt Power

• The main switch board is located near the door. On the panel you will find the main 12V switch. There are separate switches for the:

• The control panel has a battery volt-meter that will provide an indication of the remaining charge of the leisure battery and amp draw display in real time. A full battery will be indicated by the Battery Level Indicator.

• There are also two water tank gauges which will display the water level when pressed. The battery condition is displayed with a voltage/amp digital reading and a level gauge. There is also a standard 12V socket.

• All switches have their own resettable fuse next to each of the switches.
  In the battery compartment the large resettable fuse is wired to the 50amp Anderson plug fitted at the drawbar.

• The internal 12V sockets and external 12V socket, fridge and lighting will operate on 12V power from the leisure battery; heavy usage and power hungry appliances will deplete the battery’s charge.

• It is recommended to have the mains 240V connected to a suitable supply if available, even if appliances are run on 12V only.

• The trailer lights and electric brakes are wired to a standard 7 pin trailer plug. The OPUS® is fitted with electric brakes.

IMPORTANT
Your towing vehicle will need an in-car electric brake controller installed.

The battery charger is fully automatic and will recharge the lithium battery if the OPUS® is connected to an 240V electric power supply via the 15amp power inlet.

While in transit if the tow vehicle has the Anderson Plug connected this will also be topping up the batteries via DC-DC charger.

Regular battery maintenance checks (charge once a month) will prolong the life of your battery.

Refer to battery charge instruction manual for further details.

TIP:

Monitor your batteries closely! Charge or discharge the battery to approximately 50% of capacity before storage. Charge the battery to approximately 50% of capacity at least once every six months.

Care & Maintenance

IMPORTANT THE OPUS® CAMPER MUST NOT BE STORED WET/DAMP

STORAGE
It is strongly advised that you purchase a storage cover for your OPUS® if it is to be stored in an uncovered location. The storage cover is advised for an extended period of storage to keep your caravan in pristine condition.

Clean off dirt and grime on the unit from travelling/terrain to keep your caravan in good condition and maximise its longevity.

Regular battery maintenance checks (charge once a month) will prolong the life of your battery.

Ensure the water tanks are emptied after use and contain no liquids when being stored.

Return to the Road

• Ensure that your caravan and accessories are fit for the road and you adhere to all local laws.
• Check the wheels and tyres and ensure they are in good condition with the wheel nuts correctly torqued (125NM).
• Check the tyre pressure before driving (50PSI when cold).
• Check that DO35 coupling (receiving hitch) is tight.
• Check the lights and fittings and ensure they are functioning correctly.
• The chassis/running gear and the gas installation of your OPUS® caravan should be checked on an annual basis by a qualified service centre.

External care for your OPUS®

• Inspect the outside panels of your caravan including the roof (bed lids) for any damage or cracks.
• Inspect the sealant around the panels to verify that there is adequate bonding around the body panels and exterior features. This is especially important after an impact/accident to the caravan to ensure the integrity of the body’s resistance to water ingress.
• Keep the body and the roof of the caravan clean, it is best to clean any mud and dirt off the caravan immediately or after every journey to maintain its clean finish.
• Prolonged exposure to UV, mud, dirt, and salt may deteriorate the finish of the caravan.
• The body of the caravan can be washed with soap and water using a soft sponge. Rinse the caravan thoroughly after washing.
• A damp cloth may be preferred especially for small spots and dirt. Specialist products such as Care-avan Waterless Wash & Shine may be used where/when adequate water is not readily available. Read and follow the instructions carefully and it is advisable to try any product to be used on the caravan on a small inconspicuous spot to ensure/verify it is suitable before full use.
• Any form of damage or scratch to the paint work or finish of the caravan on the body may be repaired or cleaned by using a suitable ‘touch up’ stick/paint. Contact your dealer or OPUS® caravan directly for further information.

Internal Features

Storage

Warranty

INTRODUCTION

The following information relates to warranties offered by OPUS. Please read all the information carefully, and should you have any questions relating to any aspect of this section, please contact OPUS. By purchasing an item from OPUS, you hereby agree to all terms and conditions of warranty as set out herein.

OPUS will always deal with warranty claims reasonably and in go od faith. We offer a 12 month warranty on all fittings and fixtures, plus the following s pecific warranties:

OPUS warranties apply for the use of your OPUS on any road or t rack that is trafficable to normal four-wheel-drive vehicles.

VALIDITY OF CLAIMS

• Warranties are valid to the original purchaser of the item in question and apply from the original date of purchase.
• Warranties apply to items sold as “new” and do not extend to items sold via auction, or deemed to be “factory seconds”, “ex-demonstration” or “damaged” unless specifically stated otherwise by OPUS® in writing. (See details later in this document.)
• Warranties are not transferable. Also, if the original purchaser sells an item to a third party, the original purchaser cannot make any claims on behalf of the new owner.
• Warranties do not apply to products used in hire schemes or as rentals.
• OPUS® does not cover damage due to unauthorised modifications, m isuse, abuse, incorrect assembly, improper and irregular maintenance, or accident or collision.
• Any work performed under an authorised warranty claim approved by OPUS® must be performed by OPUS®, or an authorised representative of OPUS®, and only with the express written permission of OPUS®.
• Affiliates, representatives, associates, agents, suppliers, resellers or similar of OPUS® shall have no authority to authorise or deny warranty claims on behalf of OPUS®.
• OPUS® shall not be liable (in part or whole) for any warranties, either express or implied, made by agents or resellers on behalf of OPUS® without the knowledge or express written permission of OPUS®. Such unauthorised claims shall be the responsibility of the agent or reseller only.

Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a replacement or refund for a major failure and for compensation for any other reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure.

OPUS® Caravans are designed for use on any road or track that is trafficable to normal four-wheel-drive vehicles.

OPUS® Caravans can be exposed to water crossings where the water is below body floor level, but never where the water is at, or above, body floor lev el.

THE FOLLOWING ITEMS ARE NOT COVERED UNDER THE OPUS® WARRANTY:

• Impact or stone damage to body, chassis or running gear.
• Soiling of fabrics and internal fitments from dust and other air borne substances.
• Water damage due to water crossings.
• Movement or damage caused by dislodgment of appliances and fittings resulting from hard impact or heavy landings or severely rutted roads or tracks.
• General damage arising from misuse.
• Rust
• Wheels and Tyres
• Paint
• Faults to canvas when stored wet.
• Mould
• General consumables such as bearings, light fittings, batteries etc.
• Wear and tear when the trailer is used for permanent living purposes.

OPUS® includes equipment and fittings, such as accessory brand cookers or pumps, which are separately warranted by their manufacturer and not covered by the OPUS® Warranty. If necessary, OPUS® will help an owner make a warranty claim to these manufacturers.

In addition to the express OPUS® warranty, the consumer may also be covered by other rights and remedies of the Australian Consumer Law in relation to the goods and or services to which this warranty relates.

FACTORY SECONDS, EX-DEMONSTRATION AND DAMAGED GOODS

From time to time, OPUS® may offer for sale items deemed to be “factory seconds”, “ex-demonstration”, or “damaged”. Any such items are sold on an “as is” basis.

There are no warranties, refunds, credits, exchanges or similar associated with such items. In the sale of such items, OPUS® will attempt to provide all relevant information regarding the item, including faults, defects, or similar, however, there may be instances where minor defects or imperfections have been overlooked. This is purely unintentional and in no way alters the nature of the sale.

Due to the nature of such items, being “ex-demonstration”, “factory seconds” or “damaged”, it is reasonable to expect that some imperfections or flaws may exist even where it is not initially apparent. By purchasing such an item, you agree to this statement and accept that there are no warranties implied or expressed.

LODGING A CLAIM
All warranty claims should be lodged by contacting your dealer directly.

CONTACT
If you have any further questions relating to warranties, or are unsure about any aspect of this section, please visit www.opuscamper.com.au/warranty or contact OPUS.
Phone: (03) 9588 2959
Email: enquiries@opuscaravan.com.au

Service Schedule

Torque guide

PURPLE LINE PTY LTD
13 INDIAN DRIVE
KEYSBOROUGH
VIC 3172
AUSTRALIA
WEB: WWW.PURPLELINE.COM.AU
TEL: 03 9588 2959
EMAIL: ENQUIRIES@PURPLELINE.COM.AU

FIND US ON FACEBOOK INSTAGRAM & YOUTUBE

Read More About This Manual & Download PDF:

References

• Camper Trailers | Off Road Camper Trailer Manufacturers - OPUS® Camper
• Warranty - OPUS® Camper
• Buy Electric & Motorised Caravan Movers Online | Purple Line
• Warranty - OPUS® Camper

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>