ECHOMASTER CL-FT2 Wiring Harness for Cargo Lighting 2020-2021 Ford Transit Van Instruction Manual
- June 9, 2024
- Echomaster
Table of Contents
ECHOMASTER CL-FT2 Wiring Harness for Cargo Lighting 2020-2021 Ford
Transit Van
Thank you for purchasing the CL-FT2.
WHAT’S INCLUDED
- Vehicle Specific Wire Harness (CL-FT2)
COMPATIBLE ACCESSORIES
- LED Dome Lamp (STL40489-2)
- 1100mm Roof Bow Harness (P-HARRB1)
- 1570mm Roof Bow Harness (P-HARRB2)
- 2570mm Roof Bow Harness (P-HARRB3)
- 3470mm Roof Bow Harness (P-HARRB4)
TOOLS REQUIRED
- Diagonal Cutters
- Phillips #2 Drill Bit
- Drill
INSTALLATION INSTRUCTIONS
- STEP 1: Remove the plastic covers that cover the OEM wire harnesses on the driver’s side of the vehicle.
- Note: The recommended method for removing the covers is to slide them off.
- Note: The recommended method for removing the covers is to slide them off.
- STEP 2: Locate the OEM Cargo Lamp connection that is behind the vehicle’s first roof bow on the driver’s side of the vehicle.
- STEP 3: Unplug the OEM Cargo Lamp connectors and install the CL-FT2 harness between the two connectors.
- STEP 4: Install the STL40489-2 lights onto the center of each roof bow; leave the light connector exposed
- Peel the red adhesive liners off of the STL40489-2 and stick the light in place
- Use the provided 3/4” screws to secure the light to the roof rib
- STEP 5: Connect the appropriate P-HARRBx roof bow harness to each installed STL40489-2 light.
- Refer to the diagram on page 8 to confirm proper P-HARRBx for each roof bow.
- STEP 6: Use the fir tree cable ties that are packaged with each P-HARRBx to secure the harness to the vehicle’s roof bow. Trim off excess cable tie material after harness is secure.
- STEP 7: Route all P-HARRBx roof bow harnesses alongside the OEM wire harnesses.
- Tuck the harnesses into place; behind the black plastic clips
- STEP 8: Plug all installed P-HARRBx harnesses into the mating connectors on the CL-FT2 harness.
- Confirm all installed STL40489-2 lights are operational
- Re-install the plastic covers that go over the OEM wire harnesses
Vehicle Sizes
| Vehicle | Roof Bow 1 | Roof Bow 2 | Roof Bow 3 | Roof Bow 4 |
|---|---|---|---|---|
| Transit – Med Roof 130″ WB | P-HARRB1 | P-HARRB2 | P-HARRB3 | N/A |
| Transit – Med Roof 148″ WB | P-HARRB1 | P-HARRB2 | P-HARRB3 | P-HARRB4 |
| Transit – High Roof (Jumbo) | P-HARRB2 | P-HARRB2 | P-HARRB3 | P-HARRB4 |
CONTACT
- Phone: 866-931-8021 (option 3)
- E-Mail: [email protected].
- EchoMaster.com
References
Read User Manual Online (PDF format)
Loading......