SCANCOOL XS701E Commercial Ice Cream Display Freezer User Manual

PLEASE READ THE OPERATION MANUAL BEFORE USING. SAVE THIS MANUAL FOR LATER USE

PARTS AND FEATURES

1. Glass lid
2. Wire
3. Castor
4.  Control panel

CHEST SHOWCASE SAFETY

Your safety and the safety of others are very important.
We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety me-s sages. This is the Safety alert. This alerts you to potential hazards that can kill or injure you and others. All safety messages will follow the Safety Alerts and either the wards
”DANGER”, “WARNING” or “CAUTION”. Danger means that failure to heed this safety statement may result in severe personal injury or death. A warning means that failure to heed this safety statement may result in extensive product damage, serious personal injury, or death.
Caution means that failure to heed this safety statement may result in minor or moderate personal injury, or property or equipment damage. All safety messages will alert you to what the potential hazard is, tell you how to reduce the chance of injury, and let you know what can happen if the instructions are not followed.

IMPORTANT SAFEGUARDS

Before the chest showcase is used, it must be properly positioned and installed as described in this manual, so read the manual carefully. To reduce the risk of fire, electrical shock or injury when using the chest showcase, follow basic precautions, including the following:

• This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety
• Children should be supervised to ensure that they do not play with the appliance.
• DANGER or WARNING: Risk of child entrapment: Child entrapment and suffocation are not problems of the past. Junked or abandoned showcases are still dangerous, even if they will “just sit in the garage a few days.”
• Before you throw away your old showcase: Take off the doors. Leave the shelves in place so that children may not easily climb inside.
• Please according to local regulations disposal of the appliance for its flammable refrigerant and blowing gas
• The showcase must use a separate pin outlet to be connected with the earth correctly, never with the heating pipe and coal gas pipe.
• The showcase shall be positioned so that the plug is accessible
• If the supply cord is damaged, the manufacturer of its service agent or a similarly qualified person must replace it in order to avoid a hazard.
• Do not attempt to repair or replace any part of your chest showcase unless it is specifically recommended in this material. All other servicing should be referred to a qualified technician.
• The chest showcase should not be located next to ovens, grills or other sources of high heat
• Keep ventilation openings, in the appliance enclosure or in the built-in structure, clear of obstruction.
• Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer
• Do not damage the refrigerant circuit.
• Do not use electrical appliances inside the food storage compartments of the appliance, unless they are of the type recommended by the manufacturer.
• Before proceeding with cleaning and maintenance operations, make sure the power line of the unit is disconnected.
• Do not connect or disconnect the electric plug when your hands are wet.
• Do not store or use gasoline or any other flammable vapors and liquids in the vicinity of this or any other showcase. Never clean showcase parts with flammable fluids. The fumes can create a fire hazard or explosion.
• If the voltage is unstable, please choose the suitable auto- Matic, voltage regulator.
• Connection the power to check the showcase before using, the showcase can be used until the temperature decreases obviously after 30 minutes.
• You should adjust the temperature control according to the requested temperature and quantity of the stored food and the environmental temperature.
• Before putting the stuff into the showcase please adjust the temperature control to the lowest point and let it work till the temperature of the inner cabinet decreases to -18℃ and then put the stuff in, after 12 hours adjust the temperature control to the normal point.
• Never put hot food in the showcase directly only after it has been cooled naturally outside.
• The stuff should be put into the showcase partially, each lot will not be more than the figure which is equal to the capacity(L) divided by 20.
• Not full the showcase and make it crowded, big meat should be divided into several small parts. There should be reasonable space between the foods for better freezing.
• If a power cut-off is needed, you should wait for at least 5 minutes before turn on again to avoid damage to the compressor.
• The stuff stored should be packed in a plastic bag well to avoid smell-mixed and moisture-lost, and reduce the frost at the small time
• Beer, beverages, fresh water, medicine, and injections can not be put into the showcase.
• Please make the temperature control to the lowest point if you want to store ice cream or other uneasy-frozen food.
• We have a policy of continuous improvement on our products and reserve the right to change materials and specifica- tions without notice. To confirm, the specific parameters, please according to the rated label on the product
• Shall, when the product scrap/recovered by professional scrap/recycling locations to deal with.
• This product application environment temperature is up to 43°C.

TRANSPORTATION AND INSTALLATION INSTRUCTIONS

1. When you transport the showcase, the angle between the compartment body and the ground should be no more than 45° and you should never place the showcase upside down.
2. Do not use any of the external parts as loading points, for example, the condenser on the back, or the door.
3. When the showcase is installed or used, all the packages (including board and foam plastic) should be got rid of.
4. Keeping the showcase stable to avoid vibration and noise
5. The showcase should be installed in a place with good ventilation, a space of at least 10cm should be allowed between the surrounding walls and the cabinet wall for air conditioning.
6. It should be placed far from the heating resources and not under direct sunshine to avoid a decrease of the efficiency of refrigeration
7. Install the showcase in a dry place so as to prevent rust on the compartmebody, which may affect the electric insulation.

OPERATING YOUR SHOWCASE THE FUNCTION OF THE CONTROL PANEL:

Mechanical Thermostat:

1. The figure on the temperature control 1~7 only means the temperature level from high to low, not mean the specific temperature, turn the knob clockwise, the temperature inside will go down, turn the knob to the other direction, and the temperature will go up.
2. The green light is a power indicator, when it is on, the power is connected.
3. When you turn the knob anticlockwise to “off” or “0” the freezer will not be supplied power.

Do not turn the knob from “7” to “off” or “0”!
Electronic Thermostat:

1. The EMC is the electronic controller.
2. If the control panel has a green light, it’s a power indicator, when it is on, the power in connected.

DEFROST:

1. Defrost when the frost thickness on the wall of the cabinet reaches 5mm to optimize the freezing capacity.
2. Turn the temperature control to the lowest point for 5-6 hours before defrosting.
3. Cut off the power and take out the food, use the defrost removal, and do not apply sharp tools.
4. After defrosting, clean the wall with a dry cloth, and then power it on.

THE FOLLOWING PHENOMENA ARE NORMAL:

1. There will be a sound of flowing water when the refrigerant is running.
2. The frozen food do not melt even if a long time power off.
3. When the environment humidity is too high, there will be dew condensed on the surface of the showcase.
4. When the machine is running, the condenser and compressor will be hot.

CARE AND MAINTENANCE

MAINTENANCE AND CLEANNESS:

1. Do not open the door frequently and for too long to save energy.
2. Never leave heavy or hot stuff on the top of the showcase to avoid deforming.
3. Cut off the power before cleaning.
4. To clean the showcase, please use a soft cloth dampened in some moderate detergent and hot water.
5. Use warm water to clean oil or fruit juice stains on the magnetic gasket in order to keep its elasticity. Apply some talcum powder to it to prolong its service life.
6. The showcase should not be left unused for a long time, to stop using the showcase, disconnect the main power first, then clean the inside and leave the door open for 2~3 days to dry it.

Correct Disposal of this product
This marking indicates that this product should not be disposed of with other household wastes throughout the EU. To prevent possible harm to the environment or human health from uncontrolled waste disposal, recycle it responsibly to promote the sustainable reuse of material resources. To return your used device, please use the return and collection systems or contact the retailer where the product was purchased. They can take this product for environmentally safe recycling.

TECHNICAL DATA:

Model ……………………………….. XS 701E
Classification of anti-electric shock ……………………………………. I
Capacity, (L) …………………………………………………. 670
Effective Volume, (L) …………………………………………. 501
Net Weight, (kg) ………………………………………………….. 105
Overall Dimension (mm) …………………………….. 1865x814x850

TROUBLE SHOOTING:

Unfreezing

• Temperature control is on the highest point – Adjust the temperature

• Plug and outlet not connected well – Make the two connect well

• Fuse broken off – Change the fuse
  Compressor can not stop working

• Temperature control is on the lowest point – Adjust the temperature control

• Too much stuff stored in one time – Reduce the quantity

• Thick frost – Defrost

• Too many times of door-opening – Reduce the times of door-opening

• Too near the wall – Far from the wall

• Near the hot source or sun – Change the place
  Big noise

• Ground is not flat – Change the place

• Refrigerating tubes connected – Separate them
  REMARK: If you can not solve the troubles according to the a-bo ve-mentioned ways, please contact the after-sale service, do not handle it yourself.

DK

Adgang til professionel reparation, såsom internetsider, dresser, kontaktoplysninger
Model nr: XS 701 E
Liste over eftersalgsservicestationer:

Relevant information for ordering spare parts, directly or through other channels provided by the manufacturer, importer or authorized representative;| Scandomestic A/S
The minimum period during which spare parts, necessary for the repair of the appliance, are available;| 8 years
Instruction on how to find the model information in the product database, as defined in Regulation (EU) 2019/2024 by means of a web link that links to the model information as stored in the product database or a link to the product database and information on how to find the model identifier on the product.)| www.scandomestic.dk

Note: The address or contact phone number of the service site is subject to change without prior notice. Please confirm whether the service station is directly affiliated with one of our companies when requiring services.

EU DECLARATION OF CONFORMITY

Re f. Ares In accordance with EN ISO 17050-1:2004

Scandomestic Ws Unavej 20
8600 Silkeborg
Denmark
This declaration of conformity is issued under the sole responsibility of the manufacturer (or installer):| Scandomestic A/5 Unavej 20
8600 Silkeborg
Denmark
Object of the declaration (identification of product allowing traceability. It may include a colour image of suffideM clarity to enable the identification of the product, where appropriate.) Product: Ice Cream Freezer Brand: Scancool
Colour: White Model name: XS 701 E|
The object of the declaration described in point 4 is in conformity with the relevant Union harmonization legislation:| EN 61000-3-2
References to the relevant harmonized standards used, or references to the specifications in relation to which conformity is declared:| MD 2006/42/EC with amendment 2009/127/EC, 2011/65/EU, 2014/30/EU, EN 60335-2- 89:2010+A1:2016+A2:2017, EN 60335- 1:2012+AC:2014+A11:2014+A13:2017 41:2019+A14:2019+A2:2019, EN 6223:2008, 55014-1:2017, EN 55014-2:2015, EN IEC 610003-2:2019, EN 61000-3-3:2013+A1:2019, EN ISO 23953-1:2015, EN  150 23953-2:2015, 2017/1369, 2019/2018, 2019/2024, IEC 60335-289:2010+A1:2012, IEC 60335-1:2010+A1:2013
Where applicable: the notified body … (name, number)… performed … (description of intervention)… and issued the certificate:| RoH5 2011/65/EU
Additional information:| Commercial Box

Scandomestic A/S
DK-8600 Silkeborg
Tel.: + 45 7242 5571
www.scandomestic.dk

Documents / Resources

| SCANCOOL XS701E Commercial Ice Cream Display Freezer [pdf] User Manual
XS701E, Commercial Ice Cream Display Freezer, XS701E Commercial Ice Cream Display Freezer
---|---

References

• Scandomestic | Scandomestic.dk
• Scandomestic | scandomestic.dk

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>