POLAR GH226-A Stainless Steel Counter Fridge Instruction Manual

POLAR GH226-A Stainless Steel Counter Fridge

Specifications

• Model: GH226-A
• Product: Polar G-Series Six Drawer Counter Fridge
• Material: Stainless Steel
• Telephone Helpline: 1300225960

Product Description
The GH226-A is a Polar G-Series Six Drawer Counter Fridge made of stainless steel, designed for efficient storage and cooling of food items.

Installation

1. Remove all packaging materials and ensure surfaces are clean.
2. Maintain proper clearance around the unit to optimize performance.
3. Clean the interior with soapy water before initial use.
4. Level the appliance using the screw feet.

Operation
Storing Food

1. Close all drawers of the appliance before use.
2. Turn on the appliance using the power switch and socket.

Setting Operating Temperature

1. Hold the SET button for 3 seconds until the display flashes.
2. Adjust the temperature using the arrow buttons.
3. Press SET to save the temperature setting.

Manual Defrost
Press and hold the defrost button for 2 seconds to initiate manual defrost. The cycle will end automatically.

Cleaning, Care & Maintenance
Regularly clean the interior with soapy water and ensure sharp edges are handled carefully. Follow refrigerating tips for optimal performance.

Cleaning the Condenser Filter
Remove and clean the condenser filter periodically to maintain efficiency.

FAQ
Troubleshooting

plugged in correctly and switched on
The temperature is too high/low| Too much ice on the evaporator, Condenser blocked with dust,
Drawers are not shut properly, Appliance is located near a heat
source| Defrost the appliance, Clean the Condenser, Check drawers are
shut and seals are not damaged, Move the refrigerator to a more
suitable location

Safety Instructions

Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product.

• Position on a flat, stable surface.
• A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product.
  • In Queensland the service agent/qualified technician MUST hold a Gas Work Authorisation or License for hydrocarbon refrigerants if the appliance gas system is being opened or charged.
• Consult Local and National Standards to comply with following:
  • Health and Safety at Work Legislation
  • Fire Precautions
  • Wiring Regulations
  • Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT stand or support yourself on the base, drawers or doors.
• DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs.
• Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the refrigerator.
• Always carry, store and handle the appliance in a vertical position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit before cleaning.
• Keep all packaging away from children. Dispose of the packaging in accordance with the regulations of local authorities.
• If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified technician in order to avoid a hazard.
• POLAR recommend that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity and Functional Testing.
• This appliance is not attended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience or knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety.

Caution: Risk of Fire

• Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.

Warning: Keep all ventilation openings clear of obstruction. Unit should not be boxed in without adequate ventilation.

• To comply with AS/NZS 60079.10.1:2009: Ensure there are not sources of ignition in any area where refrigerant could gather in the event of a leak.

• Electrical equipment should not be placed under the vent or where refrigerant could gather in the event of a leak.

• Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
  

• Warning: Do not damage the refrigerant circuit.
  

• Warning: Do not use electrical appliances inside the food storage compartments of the appliance.

Product Description
GH226-A – Polar G-Series Six Drawer Counter Fridge

Pack Contents

The following is included:

• POLAR Refrigerator
• Instruction manual

POLAR prides itself on quality and service, ensuring that at the time of unpacking the contents are supplied fully functional and free of damage. Should you find any damage as a result of transit, please contact your POLAR dealer immediately.

Installation

Note: Not for use in vans or trailers, food trucks or similar vehicles.
If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow to stand.

1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces.

2. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top. NEVER LOCATE NEXT TO A HEAT SOURCE.
   Note: Before using the appliance for the first time, clean the interior with soapy water then dry well.

3. Level the appliance by adjusting the screw feet.

Operation

Storing Food

To get the best results from your POLAR appliance, follow these instructions:

• Only store foodstuffs in the appliance when it has reached the correct operating temperature.
• Do not place uncovered items as below inside the appliance, as this can lead to a damaged and leaking evaporator, and thus void your warranty: hot food, hot liquids, acidic fluids, acidic products.
  • Wrap or cover food where possible.
  • Do not obstruct the fans inside the appliance.
  • Avoid opening the doors for prolonged periods of time.

Turn On

1. Close the drawers of the appliance.
2. Ensure the power switch is set to [O] and turn on at the socket.
3. Switch on the Power [I]. The current temperature within the appliance is displayed.

Control Panel

Set the Operating Temperature

1. Hold the SET button for 3 seconds. The display will flash.
2. Press the ****buttons to display the required temperature.
3. Press the SET button to store the temperature.

Manual Defrost
Press and hold the defrost button “aux” for 2 seconds to begin a manual defrost. The defrost light illuminates.
The defrost cycle will end automatically.

Cleaning, Care & Maintenance

• Switch off and disconnect from the power supply before cleaning.
• Clean the interior of the appliance as often as possible.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• Clean the door seal with warm soapy water.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run through the drain hole into the evaporation pan.
• Take care when cleaning the rear of the appliance. Sharp edges can cut.

Refrigerating tips:

• Condensation and ice will form with frequent and prolonged opening of the doors.
• Operating outside of the recommend temperature range and placing next to a heat source will also increase the amount of ice and internal/external condensation. If external condensation occurs wipe the surface down with a cloth.
• Excessive ice will result in longer running times that will increase energy consumption and increase the deterioration of components.
• If the gasket or seal is damaged or deformed, energy consumption will increase. To restore efficiency, replace gasket.
• Do not obstruct fans and do not exceed max load lines, as doing so will impact air distribution and increase energy usage.

Cleaning the Condenser Filter

• The condenser is part of the refrigeration system. The condenser filter requires monthly cleaning.
• Always disconnect power supply before carrying out Routine Maintenance.
• Failure to clean the condenser will increase energy consumption, reduce the performance and life of your Polar unit, and thus may invalidate your warranty.
• These models have a removable filter which can be cleaned with a vacuum cleaner.

Troubleshooting

A qualified technician must carry out repairs if required.

plugged in correctly and switched on
Plug or lead is damaged| Replace plug or lead
Mains power supply fault| Check mains power supply
The appliance turns on, but the temperature is too high/low| Too much ice on the evaporator| Defrost the appliance
Condenser blocked with dust| Clean the Condenser
Drawers are not shut properly| Check drawers are shut and seals are not damaged
Appliance is located near a heat source or air flow to the condenser is being interrupted| Move the refrigerator to a more suitable location
Ambient temperature is too high| Increase ventilation or move appliance to a cooler position
Unsuitable foodstuffs are being stored in the appliance| Remove any excessive hot foodstuffs or blockages to the fan
Appliance is overloaded| Reduce the amount of food stored in the appliance
The appliance is leaking water| The appliance is not properly levelled| Adjust the screw feet to level the appliance (if applicable)
The discharge outlet is blocked| Clear the discharge outlet
Movement of water to the drain is obstructed| Clear the floor of the appliance (if applicable)
The drip tray is overflowing| Empty the drip tray (if applicable)
The appliance is unusually loud| Loose nut/screw| Check and tighten all nuts and screws
The appliance has not been installed in a level or stable position| Check installation position and change if necessary

Electrical Wiring

The plug is to be connected to a suitable mains socket.

This appliance is wired as follows:

• Live wire (coloured brown) to terminal marked L
• Neutral wire (coloured blue) to terminal marked N
• Earth wire (coloured green/yellow) to terminal marked E

****The appliances must be earthed.
If in doubt consult a qualified electrician.
Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required they must be readily accessible.

Compliance
The product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area. POLAR parts have undergone strict product testing in order to comply with regulatory standards and specifications set by international, independent, and federal authorities.

POLAR products have been approved to carry the following symbol:

All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording or otherwise, without the prior written permission of POLAR. Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserve the right to change specifications without notice.

Information requirements for professional refrigerated storage cabinets

Note: Due to our continuous improvement process, the product specifications are subject to change without notice.

EN| Model(s): [information identifying the model(s) to which the information relates]| GH226-A
---|---|---
EN| Intended use| Storage| | Category – Vertical/counter| Counter
---|---|---|---|---|---
EN| Operating temperature(s) – chilled/frozen/multi-use| Chilled: 2°C ~ 8°C
---|---|---
EN| (where applicable) Heavy-duty/light-duty| Heavy Duty:
This appliance is intended for use in ambient temperatures up to 40°C.
---|---|---
EN| Refrigerant fluid(s): [information to identify the refrigerant fluid(s), including GWP]| R600a/ GWP 3
---|---|---
V / Hz| H x W x D| Kg
---|---|---
220-240V~ 50Hz| 870 x 1370 x 700 mm| 140 kg

Note: For optimal product performance and efficiency, please ensure to mind the net usable capacity (load limit) when filling.

| GH226-A-01| | | |
---|---|---|---|---|---
EN| Annual Energy Consumption AEC (kWh)| 1730.1| | | |
EN| Energy Efficiency Index EEI| 81.3| | | |
EN| Net volume Vn litre (where applicable)| 132L| | | |
EN| Chilled volume Vn Ref litre| 132L| | | |
EN| Frozen volume Vn Frz litre| 0.100kg| | | |
EN| Refrigerant charge x.xx kg| N/A| | | |
EN| Power / Current| 235W/ 1.3A| | | |

DECLARATION OF CONFORMITY

I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s) and Standard(s).

http://www.polar-refrigerator.com/

Documents / Resources

| POLAR GH226-A Stainless Steel Counter Fridge [pdf] Instruction Manual
GH226-A Stainless Steel Counter Fridge, GH226-A, Stainless Steel Counter Fridge, Steel Counter Fridge, Counter Fridge, Fridge
---|---

References

• Polar Refrigeration - Commercial Refrigeration

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>