POLAR CR711 Stainless Steel Counter Fridge Instruction Manual

POLAR CR711 Stainless Steel Counter Fridge

Safety Instructions

• Position on a flat, stable surface.
• A service agent/qualified technician should carry out installation and any repairs if required. Do not remove any components or service panels on this product.
• Consult Local and National Standards to comply with the following:
  • Health and Safety at Work Legislation
  • BS EN Codes of Practice
  • Fire Precautions
  • IEE Wiring Regulations
  • Building Regulations
• DO NOT use jet/pressure washers to clean the appliance.
• DO NOT use the appliance outside.
• DO NOT use this appliance to store medical supplies.
• DO NOT stand or support yourself on the base, drawers, or doors.
• DO NOT allow oil or fat to come into contact with the plastic components or door seal. Clean immediately if contact occurs.
• Bottles that contain a high percentage of alcohol must be sealed and placed vertically in the refrigerator.
• Always carry, store, and handle the appliance in a vertical position and move by holding the base of the appliance.
• Always switch off and disconnect the power supply to the unit before cleaning.
• Keep all packaging away from children. Dispose of the packaging according to the regulations of local authorities.
• If the power cord is damaged, it must be replaced by a POLAR agent or a recommended qualified technician to avoid a hazard.
• This appliance is not intended for use by persons (including children) with reduced physical, sensory o, or mental capabilities, or lack of experience or knowledge, unless they have been given supervision or instruction concerning the use of the appliance by a person responsible for their safety.
• Polar recommends that this appliance should be periodically tested (at least annually) by a Competent Person. Testing should include, but not be limited to: Visual Inspection, Polarity Test, Earth Continuity, Insulation Continuity, and Functional Testing.
• Polar recommends that this product be connected to a circuit protected by an appropriate RCD (Residual Current Device).

Caution: Risk of Fire

• Do not store explosive substances such as aerosol cans with a flammable propellant in this appliance.
  • Warning: Keep all ventilation openings clear of obstruction. The unit should not be boxed in without adequate ventilation.
• Warning: Do not use mechanical devices or other means to accelerate the defrosting process, other than those recommended by the manufacturer.
• Warning: Do not damage the refrigerant circuit.
• Warning: Do not use electrical appliances inside the food storage compartments of the appliance.

Product Description

• CR711 – Polar G-Series Six Drawer Counter Fridge

Introduction

Please take a few moments to carefully read through this manual. Correct maintenance and operation of this machine will provide the best possible performance from your POLAR product.

Pack Contents

The following is included:

• POLAR Refrigerator
• Instruction manual

POLAR prides itself on quality and service, ensuring that at the time of unpacking the contents are supplied fully functional and free of damage. Should you find any damage as a result of transit, please contact your POLAR dealer immediately.

Installation

Note:
Not for use in vans or trailers, food trucks, or similar vehicles. If the unit has not been stored or moved in an upright position, let it stand upright for approximately 12 hours before operation. If in doubt allow to stand.

1. Remove the appliance from the packaging. Make sure that all protective plastic film and coatings are thoroughly removed from all surfaces.
2. To optimize performance and longevity, ensure a minimum clearance of 2.5cm is maintained between the unit and walls and other objects, with a minimum 20cm clearance on the top. NEVER LOCATE NEXT TO A HEAT SOURCE.
   • Note: Before using the appliance for the first time, clean the interior with soapy water then dry well.
3. Level the appliance by adjusting the screw feet.

Operation

Storing Food
To get the best results from your POLAR appliance, follow these instructions:

• Only store foodstuffs in the appliance when it has reached the correct operating temperature.
• Do not place uncovered items as below inside the appliance, as this can lead to a damaged and leaking evaporator, and thus void your warranty: hot food, hot liquids, acidic fluids, and acidic products.
• Wrap or cover food where possible.
• Do not obstruct the fans inside the appliance.
• Avoid opening the doors for prolonged periods.

Turn On

1. Close the door(s) of the appliance.
2. Ensure the power switch is set to [O] and turn on at the socket.
3. Switch on the Power [I]. The current temperature within the appliance is displayed.

Control Panel

Set the Operating Temperature

1. Press the SET button. The display will flash.
2. Press the or buttons to display the required temperature.
3. Press the SET button to store the temperature.

Manual Defrost
Press and hold the defrost button “aux” for 2 seconds to begin a manual defrost. The defrost light illuminates.

Cleaning, Care & Maintenance

• Switch off and disconnect from the power supply before cleaning.
• Clean the interior of the appliance as often as possible.
• Do not use abrasive cleaning agents. These can leave harmful residues.
• Clean the door seal with warm soapy water.
• Always wipe dry after cleaning.
• Do not allow water used in cleaning to run through the drain hole into the evaporation pan.
• Take care when cleaning the rear of the appliance. Sharp edges can be cut.

Condensation and ice will form with frequent and prolonged opening of the doors. Operating outside of the recommended temperature range and placing it next to a heat source will also increase the amount of ice and condensation. Excessive ice will result in longer running times that will increase energy consumption and increase the deterioration of components.

Cleaning the Condenser Filter

• The condenser is part of the refrigeration system. The condenser filter requires monthly cleaning.
• Always disconnect the power supply before carrying out Routine Maintenance.
• Failure to clean the condenser filter will reduce the performance and life of your Polar unit and may invalidate your warranty.
• This model has a removable filter which can be cleaned with a vacuum cleaner.

Troubleshooting

A qualified technician must carry out repairs if required.

Fault

| Probable Cause|

Solution

---|---|---
The appliance is not working| The unit is not switched on| Check the unit is plugged in correctly and switched on
Plug or lead is damaged| Replace Plug or lead
The fuse in the plug has blown| Replace the fuse
The mains power supply fault| Check the mains power supply
The appliance turns on, but the temperature is too high/low| Too much ice on the evaporator| Defrost the appliance
Condenser blocked with dust| Clean the Condenser
Doors are not shut properly| Check doors are shut and seals are not damaged
Appliance is located near a heat source or airflow to the condenser is being interrupted| Move the refrigerator to a more suitable location
The appliance turns on, but the temperature is too high/low| The ambient temperature is too high| Increase ventilation or move the appliance to a cooler position
---|---|---
Unsuitable foodstuffs are being stored in the appliance| Remove any excessive hot foodstuffs or blockages to the fan
Appliance is overloaded| Reduce the amount of food stored in the appliance
The appliance is leaking water| The appliance is not properly leveled| Adjust the screw feet to level the appliance (if applicable)
The discharge outlet is blocked| Clear the discharge outlet
Movement of water to the drain is obstructed| Clear the floor of the appliance (if applicable)
The water container is damaged| Replace the water container
The drip tray is overflowing| Empty the drip tray (if applicable)
The appliance is unusually loud| Loose nut/screw| Check and tighten all nuts and screws
The appliance has not been installed in a level or stable position| Check installation position and change if necessary

Technical Specifications

Note:
Due to our continuing program of research and development, the specifications herein may be subject to change without notice.

Model| Voltage| Power| Current| Temperature Range| Refrigerant| Dimensions H x W x D mm| Weight (kg)
---|---|---|---|---|---|---|---
CR711| 220-240V~ 50Hz| 235W| 1.3A| 2°C – 8°C| R600a| 870 x 1370 x 700| 140kg
Model| Capacity| Net usable capacity (L)
---|---|---
CR711| 6 x 1/1GN| 132

Note:
For optimal product performance and efficiency, please ensure the net usable capacity (load limit) when filling.

Electrical Wiring

POLAR appliances are supplied with a 3-pin BS1363 plug and lead. The plug is to be connected to a suitable main socket.

POLAR appliances are wired as follows:

• This appliance must be earthed.
• If in doubt consult a qualified electrician.
• Electrical isolation points must be kept clear of any obstructions. In the event of any emergency disconnection being required, they must be readily accessible.

Disposal

• EU regulations require refrigeration products to be disposed of by specialist companies who remove or recycle all gasses, metal, and plastic components.
• Consult your local waste collection authority regarding the disposal of your appliance. Local authorities are not obliged to dispose of commercial refrigeration equipment but may be able to offer advice on how to dispose of the equipment locally.
• Alternatively, call the POLAR helpline for details of national disposal companies within the EU.

Compliance

The WEEE logo on this product or its documentation indicates that the product must not be disposed of as household waste. To help prevent possible harm to human health and/or the environment, the product must be disposed of in an approved and environmentally safe recycling process. For further information on how to dispose of this product correctly, contact the product supplier, or the local authority responsible for waste disposal in your area.

• POLAR parts have undergone strict product testing to comply with regulatory standards and specifications set by international, independent, and federal authorities.
• POLAR products have been approved to carry the following symbol:

All rights reserved. No part of these instructions may be produced or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, without the prior written permission of POLAR. Every effort is made to ensure all details are correct at the time of going to press, however, POLAR reserves the right to change specifications without notice.

DECLARATION OF CONFORMITY

Equipment Type

|

Model

---|---
G-Series Six Drawer Counter Fridge G-Series Six Drawer Counter Fridge| CR711 (-E) GH226-A
Application of Territory Legislation &| Machinery Directive 2006/42/EC| Electrical Safety
Council Directives(s)| Supply of Machinery (Safety) Regulations 2008| AS/NZS 60335.1:2011 +A1:2012 +A2:2014
Toepassing van Europese Richtlijn(en) •| EN 60335-1:2012 +A11:2014 +A13:2017| +A3:2015 +A4:2017 +A5:2019
| EN 60335-2-89:2010 +A1:2016 +A2:2017| AS/NZS 60335.2.89:2010 +A1:2013
| EN 62233:2008| +A2:2016
| |
| Electro-Magnetic Compatibility (EMC) Directive| Electromagnetic Compatibility
| 2014/30/EU – recast of 2004/108/EC| EN 55014-1: 2017
| Electromagnetic Compatibility Regulations 2016| EN 55014-2:2015
| (S.I. 2016/1091)| EN 61000-3-2: 2014
| EN 55014-1: 2017| EN 61000-3-3:2013
| EN 55014-2:2015|
| EN 61000-3-2: 2014|
| EN 61000-3-3:2013|
| Regulation (EU) 2015/1095 – Ecodesign|
| professional refrigerators|
| Restriction of Hazardous Substances Directive|
| (RoHS) 2015/863 amending Annex II to Directive|
| 2011/65/EU|
| Restriction of the Use of Certain Hazardous|
| Substances in Electrical and Electronic|
| Equipment Regulations 2012 (S.I. 2012/3032)|
Producer Name| Polar

I, the undersigned, hereby declare that the equipment specified above conforms to the above Territory Legislation, Directive(s), and Standard(s).

Eire
NL| 040 – 2628080
FR| 01 60 34 28 80
BE-NL| 0800-29129
BE-FR| 0800-29229
DE| 0800 – 1860806
IT| N/A
ES| 901-100 133

http://www.polar-refrigerator.com

Read User Manual Online (PDF format)

Download This Manual (PDF format)

Download this manual  >>