MOWEO 46.5 Li SP Petrol Lawn Mower
Instruction Manual

MOWEO 46.5 Li SP Petrol Lawn Mower

|
---|---

ABOUT THIS HANDBOOK

• Read this documentation before starting up the machine. This is a precondition for safe working and flawless operation.
• Observe the safety warnings in this documentation and on the product.
• This documentation is a permanent integral part of the product described and must be passed on to the new owner if the product is sold.

Explanation of symbols
CAUTION!
Following these safety warnings carefully can prevent personal injury and/or material damage.
Special instructions for greater ease of understanding and improved handling.

PRODUCT DESCRIPTION

This document describes the battery-operated lawn mower with catcher.
Intended use
This appliance is intended for mowing laws in the private sector.
Any other use is deemed as being not in accordance with its intended use.
Possible misuse

• This lawn mower is not intended for use in public grounds, parks, sporting arenas as well as in agriculture and forestry
• The fitted safety devices must not be removed or bypassed, e.g. by tying the safety bar to the handle bar
• Do not use the mower during rain and/or on a wet lawn
• The mower must not be used commercially

Safety and protective equipment
CAUTION!
Risk of injury!
Safety and protective devices should not be disabled.
Safety bar
The mower is fitted with a safety bar. Simply release it in case of danger. Motor and cutting blade are then stopped.
Baffle
The baffle protects against objects flying out.
Safety key
To prevent the mower from being switched on unintentionally it has been fitted with a safety key. Switch the mower off before doing maintenance work and always pull out the safety key.

Product overview

Symbols on the machine
Attention!
Special care required during use!
** Read the instructions before start-up!
Attention!
Keep other persons away from the danger area!
Attention!
Keep hands and feet away from the cutter area!
Keep a distance from the danger area!
Always remove the safety key prior to working on the mower.
Attention!**
Risk of electric shock!

SAFETY INSTRUCTIONS

The lawn mower operator or user is responsible for accidents involving other persons and their property.
CAUTION!
Risk of injury!
Safety and protective devices should not be disabled.
Electrical safety

• The mains voltage must match the mains voltage specifications of the charger with regard to the technical data, do not use a different mains voltage
• Do not open the appliance. Danger of short circuit.

Safety notes for battery and charger
CAUTION!

• Danger – risk of fire and explosion!
• Do not throw the battery into an open fire
• Only use the battery and charger in areas that are protected against rain or moisture.
• Protect the battery against heat and direct sunlight
• Do not short-circuit the battery
• Protect the mower, battery and charger against moisture
• Use only original batteries and chargers from the manufacturer.
• Under abusive conditions, liquid may be ejected fromthe battery; avoid contact. If contact accidentally occurs,flush with water. If liquid contacts eyes, additionallyseek medical help.

Safety instructions for operation
CAUTION!
Danger – risk of injury!
Unintentional start-up can lead to severe injuries. To prevent injuries always remove the safety key after switching the mower off!

• Remove the safety key when:
  • Leaving the mower unattended
  • Inspecting, cleaning or servicing the mower
  • Inserting the battery
  • Faults or unusual vibrations occur on the mower
  • Releasing blockages
  • Removing clogging
  • There is danger of coming into contact with foreign objects
• Children, or other people who are not familiar with the operating instructions, are not allowed to use the machine
• Observe local regulations regarding minimum age requirements for operating the machine.
• The equipment should be used only if in good order and condition
• The machine must not be operated if the operator is under the influence of alcohol, drugs or medication.
• Prior to each use check the mower and battery for damage and have the damaged parts replaced
• Remove all foreign objects from the lawn prior to mowing
• Wear suitable work clothing:
  • Long trousers
  • Firm and antislip footwear
• Always ensure stability when working.
• Keep others away from dangerous areas.
• Keep body and clothing away from cutting parts.
• Work only when there is adequate daylight or artificial lighting.
• Always push the mower forward, never move backwards

After contact with foreign objects inspect the mower for damage. In case of serious damage take the mower to a ALKO service center.

• Never pull the mower toward the body
• Do not mow over obstacles (e.g. branches, roots of trees).
• Remove grass cuttings only when the motor has stopped and the safety key has been removed
• Switch the motor off when an area other than the area to be mowed is crossed
• Never lift or carry the mower while the motor is running
• Never leave the mower unattended when it is ready for operation

ASSEMBLY

Assemble according to enclosed assembly instructions.
CAUTION!
The mower must only be operated after it has been fully assembled!

STARTUP

Charging the battery (1)
The battery is supplied partially charged! Fully charge the battery before the first use.
The battery can be charged in any charge level. Interrupting charging does not damage the battery.
CAUTION!
**** When pulling out the battery, press and hold the engagement button on the underside of the battery so the battery will be unlocked.

1. Push the battery into the charger and connect the charger to the mains. Charging starts, and is indicated by the green light-emitting diode (LED) flashing.
2. The battery is fully charged when the LED of the charger lights up green without flashing.
3. Disconnect the plug from the mains.
4. Pull the battery out of the charger.

The temperature range for the charging process should between -5 °C and +60° C.
The maximum time for a full charge is 1.5 hours. If the operating period of the battery is greatly reduced in spite of a full charge, the battery is worn out and should be replaced with a new original battery.
Inserting the battery (2, 3)

OPERATION

Adjusting the cutting height
CAUTION!
Risk of injury
Adjust the cutting height only while motor is switched off and the cutting blade has stopped!
ADVICE

• Always adjust all wheels to the same cutting height.
• Cutting height adjustment depends on the model.

Individual wheel quick adjustment or axle adjustment (4, 5)

• To unlock, press the lever to the side and hold.
• Slide the lever to the left or right in the desired cutting height.
• Allow the lever to engage.
• Make sure all wheels engage at the same position.

Switching on the motor (6)
Start the lawn mower only on level ground, and not in high grass. The ground must be free from foreign objects, such as stones. Do not lift or tilt the lawn mower to start it.

1. Insert the safety key again and turn it (3B).
2. Keep the start button pressed (6A).
3. Pull the safety bar toward the handle bar and hold it there (6B).
4. Release the start button.

Mowing with grass catcher (7)
CAUTION!
Risk of injury
Remove or replace the grass catcher only while the motor is switched off and the cutting blade has stopped.

1. Lift up the baffle plate and hang the grass catcher into the holders.

Fill level indicator
The level indicator is pressed upwards by the air stream during mowing (8A). When the grass cat- cher is full, the level indicator rests against the catcher (8B). The grass catcher needs to be emptied.

Emptying the grass catcher (7)

1. Lift the baffle plate.
2. Unhook the grass catcher and remove it to the rear.
3. Empty grass catcher.
4. Lift up the baffle plate and hang the grass catcher back into the holders.

Switching off the motor (9)

1. Release the safety bar.
2. Wait until the cutter blade stops.
3. Remove the safety key from the mower (3a).

Check the charge level of the battery while mowing the lawn (10)

1. Switching off the motor (9).
2. Open the battery compartment (2A).
3. Press the test button on the battery: If the LED lights up green, there is still charge in battery and you can continue mowing. If the LED lights up red, the battery is discharged and requires recharging (10).

Wheel drive (option)
CAUTION!
Engage the transmission only when the motor is running.
Switching on the wheel drive

1. Press and hold the transmission control lever against the upper handle bar (11A) – the transmission control lever does not engage.
   ➯ Wheel drive is switched on.

Switching off the wheel drive

1. Release the safety bar (11B).
   ➯ Wheel drive is switched off.

INFORMATION ON WORKING

Observe the local regulations on operating lawn mowers.

• Remove foreign objects from the working area.
• Keep others away from dangerous areas.
• Use the mower only if visibility is good
• Guide the machine at walking pace.
• Mow only with a sharp cutting blade
• Do not mow over obstacles (e.g. branches, roots of trees).
• Mow only across slopes. Do not use the mower up or down slopes and not on slopes with more than a slant of 20 degrees.
• Added care must be taken on slopes when changing direction
• The operating period of the lawn mower battery depends on the condition of the battery, the condition of the lawn and the setting of the cutting height. Frequently switching the mower on and off reduces the operating time

• Optimum operating time is obtained by frequent mowing of the lawn and maintaining a short-cut lawn

Aera of cut (battery duration)

• The aera of cut depends of the qualities of the lawn. Factors as the length of the grass, the density of the grass, the chosen height adjustment and damp grass have been influence to the aera of cut.
• Switching the machine on and off frequently during cutting will also reduce the aera of cut as also a not completely charged battery.
• Switching on the traction will also reduce the aera of cut respective the battery duration.
• To optimize the aera of cut it is recommended to mow more often, to enlarge the height adjustment and to mow the grass in adequate step tempo.

Area of cut in m² by 100% battery loading:

• By use of 2 batteries which are included in delivery as well as under permanent switch on the traction.
  To increase the run time an additional battery or higher capacity battery (Wh) can be purchased.
  Mowing tips

  • Constant cutting height 3–5 cm, do not cut more than half the height of the lawn
  • Do not overload the lawn mower! If the motor speed is greatly reduced due to long, heavy grass, raise the cutting height and mow several times
  • Since wind and sun can dry out the lawn after mowing, mow the lawn in the late afternoon

STORING THE BATTERY-OPERATED LAWN MOWER

Storage
Fold the upper handle bar to save space during storage

• Always store the mower with the battery and the safety key removed
• Store the mower in a dry place and inaccessible to children and unauthorized persons

STORING THE BATTERY AND CHARGER
CAUTION!
Risk of fire and/or explosion!
Do not store the machine in the vicinity of naked flames or heat sources.
The battery is protected by a supply voltage against overloading and can therefore remain connected to the mains power for a lengthy period.
The optimum temperature for storing the battery is between 0 °C and 25 °C.

• Store the battery in dry, frost-protected location with an ambient temperature of between 0 °C and +25 °C and in a charged state of approximately 40 – 60%
• Recharge the battery for approximately 1,5 hours after a 3-month storage period
• Do not store the battery near metallic or acidcontaining objects – risk of short-circuiting!

MAINTENANCE AND CARE

CAUTION!
Danger – risk of injury!
Always remove the safety key before carrying out maintenance work! Always wear work gloves when carrying out maintenance on the cutter blade! Non-balanced cutter blades cause serious vibrations and damage the mower! Repairs must only be carried out at ALKO service centers or authorized specia- list firms!

• Regularly check the grass catcher system for correct function and wear

• After mowing, thoroughly clean the mower with a hand broom or a cloth. Contamination left on the underside of the mower can impair its proper function

• Do not hose down the mower with water! Water can damage the switch as well as the battery and the electric motor

• Regularly check the cutter blade for damage. Have the blunt or damaged cutter blades sharpened or replaced only at an AL-KO service center or authorized specialist firm. Resharpened cutter blades must be balanced The tightening torque of the blade screw is 55 Nm +5

• Ensure that all nuts, bolts and screws are tightened and that the machine is in a safe operational state.

• Let the motor cool down before storing the machine in a closed room.
  CAUTION!
  Cutting blade and motor shaft may not be aligned if damaged!

• Professional inspection is necessary:

  • After running onto an obstacle
  • When the motor is blocked
  • When the cutter blade is bent
  • When the motor shaft is bent
  • When the battery is damaged, worn out

Wheel drive (option)
Adjusting the Bowden cable
If the wheel drive can no longer be switched on or off while the motor is running, the corresponding Bowden cable must be readjusted.
CAUTION!
Risk of injury!
Only adjust the Bowden cable when the motor is switched off.

1. Turn the adjustment part on the Bowden cable in the direction of the arrow (12).
2. To check the adjustment, start the motor and switch on the wheel drive.
3. If the wheel drive still does not function, bring the lawn mower to a service centre or an authorized specialist firm.

DISPOSAL

Do not dispose of worn-out machines or spent batteries (including rechargeable batteries) in domestic waste! The packaging, device and accessories are made from recyclable materials, and must be disposed of accordingly.

• Dispose of batteries only in a discharged state The user is obligated to return the batteries and accumulators.

• These can be returned to the points of sale without charge.
  The following options for disposal are available:

  • Specialist supplier
  • A recycling station with the CCR symbol

TRANSPORT

CAUTION!
The power of the supplied batteries is more than 100 Wh!
Please comply with the following transport instructions!
The Li-ion battery contained is subject to the requirements of hazardous substances regulations. The battery can be transported on the road by private users without being subject to additional requirements. Only transport the battery if it is undamaged. The battery must be protected against contact by other objects, short circuit and inadvertent sliding. If transported by third parties (e.g. haulage company or transport by air) then it is necessary to comply with special requirements on the packaging and labelling. Obtain the assistance of a specialist in the transport of hazardous substances in order to prepare for the transport. Only transport batteries if the housing is undamaged. Mask off exposed contacts and pack the battery so it cannot move around inside the packaging.
Please comply with any additional national regulations.

TROUBLESHOOTING

CAUTION!
Wear working gloves during all maintenance work!

AL-KO service center
Battery is missing or is incorrectly seated| Correctly seat battery
Cutter blade blocked| Caution! Do not carry out main- tenance on cutter blade without working gloves!
■ Free the cutter blade from in- terference
■ Start lawn mower on short grass
Reduced motor performance| Battery is empty| Load the battery
Cutter blade is blunt| Have cutter blade sharpened at AL-KO service center
Too much grass in the ejector| Remove grass, clean baffle plate
Motor stops during mowing| Cutter blade is blunt| Have cutter blade sharpened at AL-KO service center
Motor overloaded| Switch off the battery-operated lawn mower and restart on level ground or short grass
Grass catcher does not fill up completely| Lawn is wet| Allow lawn to dry
Grass catcher clogged| Clean the grass catcher grid
Too much grass in the discharge chute or housing| Clean discharge chute / housing Correct cutting height
Cutter blade blunt| Have cutter blade sharpened at AL-KO service center
Battery operating period drops appreciably| Cutting height to low| Raise cutting height
Grass too long or too wet| Improve conditions: allow to dry, raise cutting height
Mowing speed too high| Reduce mowing speed. Clean discharge chute / housing, the cutter blade must turn freely
Fault duringoperation| Possible cause| Solution
---|---|---
Battery does not charge| Grass catcher is full| Empty grass catcher and clean discharge chute
Service life of battery is used up Loading plug or socket is dirty| Replace the battery. Use only original accessories from the manufacturer
Consult AL-KO service center
Battery or charger is defective| Order spare parts according to spare parts list
Battery too hot| Allow to cool battery

If you encounter any malfunctions that are not listed in this table or which you cannot rectify yourself, please contact our responsible customer service.

WARRANTY

We will address claims for any defects in materials and workmanship during the statutory period of limitation by means of repairs or replacements of our choice. The period of limitation is governed by the laws of the country in which the machine was purchased.
Our warranty applies only if:

• The machine has been properly handled
• The operating instructions have been adhered to
• Original replacement parts have been used

The warranty is no longer in effect if:

• Efforts have been made to repair the machine
• Technical modifications have been made to the machine
• The machine has not been used for its intended purpose

The warranty does not cover:

• Damage to paint work through normal use
• Parts subject to wear as indicated in the replacement parts list with a box [xxx xxx (x)]

The warranty period begins with the purchase by the first buyer. The warranty period begins on the date that appears on the original purchase receipt. In the event of a warranty claim, please your contact supplier or the nearest authorised customer service centre with this warranty declaration and the purchase receipt in hand. This warranty does not affect the legal warranty claims by the purchaser against the seller.

AL-KO GERATE GmbH
I Head Quarter I Ichenhauser St r. 14 I 89359 Ketz I Deutschland
Telefon: (+49)8221/203-0 I Telefax: (+49)8221/97-8199 Iwww.al- ko.com
10_2014

Documents / Resources

| AL- KO MOWEO 46.5 Li SP Petrol Lawn Mower [pdf] Instruction Manual
MOWEO 46.5 Li SP, Petrol Lawn Mower, Lawn Mower, Petrol Mower, Mower
---|---

Read User Manual Online (PDF format)

Download This Manual (PDF format)

Download this manual  >>