VIGO VG15952 Kitchen Workstation Oxford 30 in Stainless Steel Instruction Manual

VIGO VG15952 Kitchen Workstation Oxford 30 in Stainless Steel

VIGO 30-inch Oxford Single Bowl Slotted Apron Front Stainless Steel Farmhouse Kitchen Sink With Accessories.

PACKING LIST

• Sink
• Grid
• Strainer
• Drain Cover
• Cutting Board
• Roll-up Drying Rack

PRODUCT FEATURES

• 16 gauge, stainless steel
• 304 Stainless Steel
• Zero radius corners
• Elegant and functional drain grooves
• Long-lasting, easy-to-clean, satin finish
• Sound-muting insulation
• Rear drain placement

MEASUREMENT

• Exterior Dimensions  30″ (L) × 20 ½” (W) × 9″ (D)
• Interior Dimensions   28″ (L) x 16 1/8″ (W) x 10″ (D)
• Required Cabinet Space   30″
• Drain Opening Center Standard 3 ½ inch

CERTIFICATE & WARRANTY
cUPC certified by IAPMO
All VIGO Kitchen Sinks and accessories are protected by our quality-assured Limited Lifetime Warranty.

QUESTION?
For installation help, and missing or replacement parts, please contact our product specialist for consultation.
+1 866-591-7792 (Option 2) (8:30am – 5:30 pm EST)
techmail@vigoindustries.com

Dimensions

Tools
Be sure to use proper tools and always wear personal safety accessories for your protection.

• Tape Measure
• Pencil
• Silicone Adhesive Sealant
• Rags
• Denatured Alcohol
• Ear Protection
• Eye Protection
• Hacksaw / Jigsaw
• Wood Braces
• Framing Square
• Shims
• Safety Gloves

Read installation and maintenance instructions thoroughly before installation. Inspect your sink for any noticeable damage before installation. Check all local applicable plumbing and building codes. These instructions are based on application to composite material or solid surface countertop installation only; countertop application to stone, marble, granite or butcher block should be referred to an experienced countertop fabricator for custom installation.

VIGO Farmhouse series sinks are individually hand-crafted and VIGO suggests using experienced and professional installers only. For custom cutting of the countertop and installation of the actual sink, on-site installation is also recommended. Acceptable variances are approximately 1/2 of an inch. Alignment to cut-out and precise application and trimming of any adhesive sealant is critical to a superior fit and finished look. Please take extra care in this regard. VIGO Farmhouse series sinks require custom-ordered cabinets. Consult your cabinet dealer. VIGO does ot accept any liability for damage to countertops, sink fixtures, faucets or personal injury during installation. The warranty is void if installation instructions are not followed.

Installation Options

VIGO Farmhouse series sinks offer installation ontions depending on vour design. All installation types need to allow room for faucet installation. Ensure adequate clearance behind the sink for any faucet and backsplash, as well as full range of motion for faucet spouts and handles.

Typical undermount installation with 1/4″ reveal recommended
Contact your retailer if any product is damaged or missing before installation. Never install a damaged sink, as it may void your warranty.

Typical flush mount and above-counter installation

Installation Steps

STEP 1

• Prepare the sink base cabinet
• Farmhouse sinks require custom-ordered sink base cabinets with a front cutout to accommodate a 10″ deep sink.
• Build structural supports on the inside frame of the sink base cabinet.
• The structural supports must support the weight of the sink and any attachments such as garbage disposals.
• When the sink is placed onto the cabinet support, make sure the top of the sink is evenly flush against the bottom of the countertop.
• Allow clearance for water supply lines and drains or garbage disposals, as necessary.

STEP 2

• Make a template and cutout
• Depending on the installation option, make a proper cutout of the countertop.
• VIGO recommends a 1/4″ reveal on 3 sides when installed undermount style.
• For a flush mount or above-counter installation, cut the countertop along with the outside of the sink profile.
• The front end of VIGO Farmhouse sinks are designed to be installed 3/4″ extended out beyond the front end of the countertop. Cut the countertop accordingly.
• No template is provided due to the custom nature of each application and installation. The actual sink is used as the template guide for each installation.
• After centring the sink and allowing for faucets and backsplashes, use a pencil to outline the sinks as your guide for the cutout, allowing for any reveal before the actual cutting.

STEP 3

• Set the sink
• Set the sink on top of the cabinet or into the cabinet front cutout.
• Apply sealant if necessary as a gasket between the sink and cabinet.

STEP 4

• Install the countertop
• Carefully clean the bottom of the countertop and top flange of the sink with denatured alcohol.
• Apply a bead of silicone adhesive (not supplied) around the top edge of the sink.
• Place the countertop onto the sink.
• Remove excess sealant from the lip of any surfaces with a cleaner recommended by the manufacturer of the adhesive sealant.

REGISTER YOUR PRODUCT
To activate your warranty, you must register your product.vigoindustries.com/register

CLEANING RECOMMENDATION FOR VIGO PRODUCTS
Modern faucets and showers consist of very different materials to comply with the needs of the market regarding design and functionality. To avoid damage and reclamations, it is necessary to consider certain criteria when cleaning. Be sure to avoid using abrasive materials while cleaning VIGO products. REGISTER YOUR PRODUCT “NOU MUST SISTER YOUR PRODUCT VIGOINDUSTRIES.COM/REGISTER

CLEANING INSTRUCTIONS FOR FAUCETS AND SHOWERS

Please follow the instructions on your cleaning materials. In addition, pay attention to the following points: The amount of cleaning process needed in Tim region The amount of cleaning product needed and the time the cleaner needs for effective cleaning to take place should be adjusted according to products; cleaning product should not be left on VIGO products longer than necessary. Can tang at to pree; spray trit onto a dol or sponge – never directly spray onto the sanitary tapware as drops could enter openings and gaps and cause damage. After cleaning, rinse thoroughly with clean water to remove any cleaner residue. Recommended cleaning solution for hard water and soap scum is to use 50/50 water and vinegar solution.

CLEANING MATERIAL FOR FAUCETS AND SHOWERS

• Acids are necessary ingredients of cleaning materials for removing lime, however, please pay attention to the following points when cleaning faucets and showers
• Only use cleaning materials that are explicitly provided for this type of application.
• Never use cleaning materials that contain hydrochloric, formic or acetic acid, as they cause considerable damage.
• Phosphoric acid is also restricted as it can cause damage to the finish.
• Never mix any cleaning material with another.
• Never use cleaning materials that have an abrasive effect, such as powdered and industrial cleansers, scouring pads or micro fibre cloths.

KITCHEN SINK LIMITED LIFETIME WARRANTY

VIGO offers the following limited warranty on each of its KITCHEN SINK Products* (the “Product”). This warranty extends only to the original purchaser/end-user for personal household use and is not transferrable. For commercial use, additional limitations apply. VIGO warrants the Product to be free from defects in workmanship and materials under normal household use for the lifetime of the product by the original purchaser/end-user. Subject to the Warranty provisions below, any product reported to VIGO or an authorized dealer as being defective within the warranty period will receive replacement parts and/or troubleshooting assistance to correct the issue. If a replacement unit is deemed necessary by VIGO, the replacement will be made with the same model (or with a product of equal value).

This warranty extends to the original purchaser/end-user and is not transferrable to a subsequent owner. Neither the distributor, authorized dealer, nor any other person has been authorized to make any affirmation, representation, or warranty other than those contained in this warranty. Products sold in “as-is” condition, closeouts, discounted, resale, return purchases or purchases made through non-authorized dealers are not covered under the terms of this warranty. Any affirmation, representation, or warranty other than those contained in this warranty shall not be enforceable against VIGO or any other person. VIGO reserves the right to modify this warranty at any time with the understanding that such modifications will not alter the warranty conditions applicable at the time of sale for the products in question.

LIMITATIONS

This warranty shall not apply to instances of incorrect operating procedures, breakages, or damages caused by fault through improper installation, carelessness, abuse, misuse, misapplication, improper maintenance, or alteration of the Product, as well as damage due to hard water, chemical or natural corrosion, accident, fire, flood, an act of God, or any other casualty. When cleaning, handling, and maintaining the Product, avoid abrasive cleaners, steel wools, and harsh chemicals as these will scratch, damage and/or dull the product and/or finish and void this warranty. The owner/end- user of the Product covered by the present warranty is entirely responsible for all labour costs, proper installation and any applicable plumbing or electrical wiring. VIGO neither installs nor supervises installation, nor hires contractors for this purpose.

VIGO cannot be held responsible for any default, breakage, or damages caused thereby or resulting thereof, either directly or indirectly. The owner/end- user must provide requested images, photos, and videos of the Product as described in the installation guide so that VIGO can properly troubleshoot and execute the warranty specified herein. All repair expenses and labour are the responsibility of the owner/end-user. This warranty does not apply to Products that have not been installed or operated by instructions supplied by VIGO and all applicable rules, regulations, and legislation about such installations.

This warranty does not apply unless the VIGO Product is installed by a fully insured, licensed professional. VIGO strongly recommends that such licensed professionals have experience in the installation of bathroom and kitchen products. Installation of certain products, including but not limited to glass products (i.e. shower doors and glass sinks) by an inexperienced person may result in glass breakage and consequently may cause personal injury or death. VIGO is not liable for personal injuries or deaths to any persons or for any direct special, incidental or consequential damage, loss of time, loss of profits, inconvenience, incidental expenses, labour or material charges, or other costs resulting from the use of the Product or equipment about the application of the present warranty, or resulting from the removal or replacement of any product or element or part covered by this warranty.

EXCEPT AS OTHERWISE PROVIDED ABOVE, VIGO MAKES NO WARRANTIES, EXPRESSED OR IMPLIED, INCLUDING WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURCHASE OR COMPLIANCE WITH ANY CODE. VIGO cannot be held liable for any amount over and above the purchase price paid for the Product by the owner /end-user, contractor, builder, or other installation professional. COMMERCIAL LIMITATIONS Ventures is one a year trying initial date of purchase by the o felines, cs orator, or builder trial an authorized dealing coo is cut placed in display This warrant giVes tie owner/tsar See it eat rice is The one religion-lay, hay also have other rights which may vary ft is one state or province to another.

WARRANTY CONDITIONS
To obtain the warranty provided, please contact the VIGO Product Support Department during normal business hours at 866-591-7792, option 2 or via email at SUPPORT@VIGOINDUSTRIES.COM. VIGO will assist with troubleshooting and provide replacement parts as described above when the following conditions have been met: the failure is of the nature or type covered by the warranty; the user has informed VIGO of the nature of the problem during the warranty period; conclusive evidence (e.g. proof of purchase and images, video, etc.) is provided to the foregoing by the user proving that the failure occurred or was discovered within the warranty period. VIGO’s warranty obligation shall be discharged upon tender of replacement parts or product replacement. The customer’s refusal to accept the tender terminates VIGO’s warranty obligations.

VIGO 866 591-7792
vigoindustries.com

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>