ROPOX Swing Washbasin Height Adjustable User Manual
- June 9, 2024
- ROPOX
Table of Contents
Swing Washbasin Height Adjustable
Ropox Swing Wash Basin
Fixed height or manual height adjustment
User Manual & Mounting Instructions
Keep this folder with product at all times!
TF 200.01.0036_eng / Date 26-07-2022
Table of content
1. SYMBOLS USED IN THIS MANUAL …………………………………………………………………………………. 3 2. GENERAL
SAFETY………………………………………………………………………………………………………… 3
2.1 Product Unit label …………………………………………………………………………………………………. 5 3. GENERAL
REQUIREMENTS……………………………………………………………………………………………. 6
3.1 Product information ………………………………………………………………………………………………. 6 3.2 Product
description……………………………………………………………………………………………….. 6 3.3 Intended use
……………………………………………………………………………………………………….. 6 3.4 Intended
operator…………………………………………………………………………………………………. 6 3.5 Essential
performance…………………………………………………………………………………………… 6 3.6 Non-clinical functions
……………………………………………………………………………………………. 7 3.7 Clinical functions
………………………………………………………………………………………………….. 7 3.8 Product
dimensions………………………………………………………………………………………………. 7 3.9 Connection adapters
…………………………………………………………………………………………….. 9 3.10 Layout proposals
………………………………………………………………………………………………..10 4. INSTRUCTION FOR USE
………………………………………………………………………………………………..11 4.1 Operating the product
……………………………………………………………………………………….11 4.2 Adjusting the height
………………………………………………………………………………………….12 4.3 Installation of
product………………………………………………………………………………………..13
4.3.1 Model 40-41110 + 40-41120 …………………………………………………………………………….13 4.3.2 Model
40-41130 + 40-41140 …………………………………………………………………………….17 4.4 Installation
interfaces…………………………………………………………………………………………….22 4.4.1 Fixed height with low
wall unit …………………………………………………………………………..22 4.4.2 Fixed height with high wall
unit ………………………………………………………………………….23 4.4.3 Height-adjustable with low wall
unit ……………………………………………………………………24 4.4.4 Height-adjustable with high wall
unit…………………………………………………………………..25 5. SAFETY IN USE
…………………………………………………………………………………………………………….26 6. CLEANING
……………………………………………………………………………………………………………………27 6.1 Cleaning of the wash
basin…………………………………………………………………………………….27 7.
MAINTENANCE……………………………………………………………………………………………………………..27 8. COMPONENTS PART
LIST……………………………………………………………………………………………..28 9. ENVIRONMENTAL
PROTECTION…………………………………………………………………………………….28 10.
COMPLAINTS………………………………………………………………………………………………………………..28
2 TF 200.01.0036_eng
1. Symbols used in this manual
Warning Symbol Indication of potentially hazardous situation. If not avoided,
it can result in serious injury or death. Caution Symbol Indication of
potentially hazardous situation which may result in minor or moderate injury.
It may also be used to alert against unsafe practices. Notification Symbol
This symbol is used to notify correct use and handling of the product.
2. General safety
This manual must be read and understood before use. Always keep this manual in
close proximity of the product.
The use, installation and service of this product must be in compliance with
this manual to avoid accidents and serious personal injury.
Never use or handle this product in other ways specified in this manual as it
can result in personal safety hazards and/or cause damage to the product.
Persons installing and/or using this product either as operator or user should
have the necessary safety information and access to this manual.
If the supply cord is damaged, it must be replaced by the manufacturer, its
service agent or similarly qualified designated persons in order to avoid a
hazard.
3 TF 200.01.0036_eng
Do not perform repairs, disassembly or assembly operations, add-ons, re-
adjustments or modification of the product beyond what is described in this
manual. These must be carried out by Ropox or Ropox authorized personnel. Do
not perform service while in use.
This appliance can be used by children aged from 8 years and above and persons
with reduced physical, sensory or mental capabilities or lack of experience
and knowledge if they have been given supervision or instruction concerning
use of the appliance in a safe way and understand the hazards involved.
Children shall not play with the appliance. Cleaning and user maintenance
shall not be made by children without supervision.
Do not use the product if it has defects or have become damaged before being
repaired or replaced. If the control box makes unusual noise or smells, switch
off the mains voltage immediately.
Take care that the cables are not damaged.
Unplug the mains cable on mobile equipment before it is moved.
The products must only be used in an environment that corresponds to their IP
protection.
The information in this manual is based on correct installation in accordance
with installation instructions for this product.
Ropox cannot be held liable if the product is used in any way that differs
from stated in this manual and/or installation instruction.
Ropox reserve the right to amend this manual and reference documents without
prior notice.
4 TF 200.01.0036_eng
2.1 Product Unit label
40-41110-7
Wash basin
Ropox Swing Washbasin, Fixed Short cover. Plumbing is visible
Max load: 80kg Mass of product: 14kg
This product is UKCA-marked in accordance with: UK SI 2002 No. 618 – The
Medical Devices Regulations 2002, and its amendments UK SI 2008 No. 1597 – The
Supply of Machinery (Safety) Regulations 2008, and its amendments This product
is CE-marked in accordance with: European Medical Device Regulation
(EU)2017/745 Council Directive 2006/42/EC on machinery Council Directive
2011/65/EU, RoHS Manufacturer name and address Date of production Stock number
Serial number Consult manual for important safety related information,
warnings and safety precautions. Do not dispose as unsorted municipal waste.
Product must be returned to a designated recycling station.
Operating and storing temperatures may not exceed 5-40C°
Consult the instructions for use
5 TF 200.01.0036_eng
3. General requirements
3.1 Product information
Manufacturer
Ropox A/S
Ringstedgade 221, DK-4700 Naestved
+45 55 75 05 00
Email: Info@ropox.com
Product models Part number Model
Configuration
Basic UDI Expected service life MDR Class 2017/745
40-41110 40-41120 40-41130 40-41140
Ropox Swing washbasin Ropox Swing washbasin Ropox Swing washbasin Ropox Swing washbasin
57075810001QV 5 years
Fixed short cover Fixed long cover Manual short cover Manual long cover
Class I
Intended environments
Maximum user weight according to ISO 17966
This product is to be used only in:
Professional Healthcare Environment Homecare Environment 245kg / 539lbs when
the wash basin is locked in dock-in (sold separately)
80kg / 176lbs free standing
Height adjustment Ambient temperature Relative humidity Materials in contact with patient
15 cm -10 °C to +50 °C Transport and storage +5 °C to +40 °C Operation 20% to
80% – non-condensing Wash basin
Unit
Molded marble
Sand cast aluminum Stainless steel tube Various plastic components
3.2 Product description
The SwingLine washbasin makes every day easier, both at home and in
professional spaces, such as care homes and hospitals. It is height-adjustable
and is able to rotate 180 increasing accessibility in the bathroom.
3.3 Intended use
The Swing Washbasin is a washbasin which can be swung to the user, which makes
it possible for the user to wash hands before leaving the toilet. This
increases the hygiene, makes the user more self-reliant and gives the
assistant better working conditions. The Swing washbasin is available with
manual height adjustment. Depending on the model, the height adjustment range
is 15 cm for models without dock-in and 20 cm for models with dock-in. This
means that the user and carer can set the level of the sink to the
height that fits the user’s needs. The height adjustment also makes the sink
suited for both standing and seated use. It can be lowered for seated users,
e.g., wheelchair users or elderly users who prefer to sit while washing hands
or brushing teeth, and it can be raised for standing users or carers.
3.4 Intended operator
The intended operator may include all that have read and understood this
manual exempt kids.
3.5 Essential performance
The device does not have any function related to basic safety or essential
performance. In case of loss or degradation of performance, the user can still
wash their hands or chose not to.
6 TF 200.01.0036_eng
3.6 Non-clinical functions
Height adjusting offers better ergonomics to the user.
3.7 Clinical functions
This product does not offer clinical benefit for patients, when used as
intended by the manufacturer.
3.8 Product dimensions
40-41110
40-41120
7 TF 200.01.0036_eng
18 6 22 6 8 57/64″
40-41130
40-41140
NB: All dimensions are in mm and inches 8
TF 200.01.0036_eng
3.9 Connection adapters
The highlighted components can be bought separately depending on the type of building installation requirements.
Water supply Swing Wash Basin
Hose from basin
Adapters
Installation in room
(not included)
z
10mm -> 1/2″ Item no. 97001667
1/2″ Thread
10mm (3/8″)
10mm -> 3/8″ Item no. 97001668
3/8″ Thread
Water hose extensions Hose from basin
Coupling piece
10mm -> 15mm Item no. 97001665
15mm Pipe
Extra hose
10mm
1/2″ x 1/2″, 0,5m, steel Item no. 97001123
Drain Swing Wash Basin
10mm -> 1/2″ Item no. 97001101
Drain pipe from basin
1/2″ x 1/2″, 1m, plastic Item no. 97001120
Adapters
No adapter necessary
Installation in room
(not included)
ø32 (1 ¼”)
Drain pipe extensions Drain pipe from basin
Ø32 (1 ¼”)
Ø32 (1 ¼”)
Ø32 -> Ø40
Item no. 97001660
Ø40 (1 ½”)
Coupling piece
Ø32 -> Ø50 Item no. 97001661
Ø50 (2″)
Extra drain pipe
Ø32 Flex hose, 27-62cm Item no. 97001162
Ø32-Ø32 Item no. 97001062
Ø32 Flex hose, 40-110cm Item no. 97001161
9 TF 200.01.0036_eng
3.10 Layout proposals
10 TF 200.01.0036_eng
4. Instruction for use
4.1 Operating the product
Ropox Swing Wash Basin has a turning function, which means that it is NOT allowed to be used as a walking or standing support.
If the wash basin is locked in the Dock-in it functions as a standard wash basin and is safe to use as a standing support.
Maximum Loads
Locked in dock-in (sold separately) A 245kg/539lbs person is able to lean on
the basin while standing, without causing any significant deformation or
safety risk.
Wash basin free standing An 80kg/176lbs person is able to lean on the basin
while standing without causing any significant deformation or safety risk.
Warning! Make sure that the wash basin is locked correctly in dock-in, when
using it as a standing support. Caution! Do not sit or fully displace your
body weight on the sink or on the swing arm.
11 TF 200.01.0036_eng
4.2 Adjusting the height
Warning! The product should always be able to travel the full range of
actuation without colliding with objects. Failing to do so will compromise the
product stability.
12 TF 200.01.0036_eng
4.3 Installation of product
Warning! The fitter should always consider the material, condition and
strength of the wall and use screws and rawlplugs suitable for the specific
wall type. 4.3.1 Model 40-41110 + 40-41120 The screws and raw plugs included
are for mounting on a concrete wall. The installer must always examine the
material, condition and strength of the wall and use appropriate screws and
raw plugs. Maximum load in the top screws are 190lbs. The measurements on the
wall, shown below, position the wash basin in the recommended height of 800mm
– 31 1/2” from the floor.
13 TF 200.01.0036_eng
40-41110
40-41120
2 1
2 1
14 TF 200.01.0036_eng
40-41110
40-41120
Ø32mm – 1 ¼”
Ø10mm – 3/8″
Ø10mm – 3/8″
15 TF 200.01.0036_eng
40-41110 40-41120
2 1
2 1
16 TF 200.01.0036_eng
4.3.2 Model 40-41130 + 40-41140
The screws and raw plugs included are for mounting on a concrete wall. The
installer must always examine the material, condition and strength of the wall
and use appropriate screws and raw plugs. Maximum load in the top screws are
88kg/190lbs.
The measurements on the wall, shown below, enable the wash basin to be height
adjusted 750-900m / 29 17/32 “ 35 7/16”from the floor.
40-41130
40-41140
40-41130
40-41140
17 TF 200.01.0036_eng
40-41130
40-41140
Ø32 – 1 ¼”
Ø10 – 3/8″
Ø10 – 3/8″
18 TF 200.01.0036_eng
40-41130
19 TF 200.01.0036_eng
40-41140
40-41140
20 TF 200.01.0036_eng
40-41140
40-41140
Note! If the wash basin is delivered with a touchless mixer tab, this might
need to be calibrated to accommodate the specific light settings in the room
as well as any individual user needs. The calibration has to be done according
to the user manual of the mixer tab which is supplied with the wash basin.
21 TF 200.01.0036_eng
4.4 Installation interfaces
4.4.1 Fixed height with low wall unit (40-41110)
Construction The wall must be made of a material suited for screw mounting and
approved for damp rooms. The hatched area is the minimum area for
reinforcement of the wall. Reinforcement from floor to ceiling is advisable.
Load-tested according to DS/ISO 17966 the maximum user weight is 80kg (176
lbs).
Max. tensile load of upper screws 88kg/screw (194lbs/screw)
The washbasin is supplied with a set of 8 screws and rawlplugs suitable for
mounting on a concrete wall. The fitter should always consider the material,
condition and strength of the wall and use screws and rawlplugs suitable for
the specific wall type.
Plumbing The drain hose is a flexible Ø32 (1 ¼”) hose.
The water supply ends in 2 (two) 90° shut-off valves with ½” or 3/8″ outside
thread pointing downward (not included). The flexible water connection hoses
from the washbasin end in Ø10 pipes. Adapter fittings from these pipes to the
shut-off valves are available with Ropox and as standard plumbing components.
If a location of the drain higher than the recommended positioning is
required, there may be a risk of reduced draining from the washbasin.
For purchase of adapters for connection to various standard installations, see
“Connection Adapters Swing Washbasin”.
Note: All dimensions are based on a washbasin height of 800mm (21 1/2″) above
floor level. If a change of this height is required, the recommended
dimensions must be changed accordingly.
22 TF 200.01.0036_eng
4.4.2 Fixed height with high wall unit (40-41120)
Construction The wall must be made of a material suited for screw mounting and
approved for damp rooms. The hatched area is the minimum area for
reinforcement of the wall. Reinforcement from floor to ceiling is advisable.
Load-tested according to DS/ISO 17966 the maximum user weight has been fixed
at 80kg (176 lbs).
Max. tensile load of upper screws 88kg/screw (194lbs/screw)
The washbasin is supplied with a set of 8 screws and rawlplugs suitable for
mounting on a concrete wall. The fitter should always consider the material,
condition and strength of the wall and use screws and rawlplugs suitable for
the specific wall type.
Plumbing The drain hose is a flexible Ø32 (1 ¼”) hose.
The water supply ends in 2 (two) 90° shut-off valves with ½” or 3/8″ outside
thread pointing downward (not included). The flexible water connection hoses
from the washbasin end in Ø10 pipes. Adapter fittings from these pipes to the
shut-off valves are available with Ropox and as standard plumbing components.
If a location of the drain higher than the recommended positioning is
required, there may be a risk of reduced draining from the washbasin.
For purchase of adapters for connection to various standard installations, see
“Connection Adapters Swing Washbasin”.
Note: All dimensions are based on a washbasin height of 800mm (23 5/8″) above
floor level. If a change of this height is required, the recommended
dimensions must be changed accordingly.
23 TF 200.01.0036_eng
186 7 21/64″
226 8 57/64″
4.4.3 Height-adjustable with low wall unit (40-41130)
Construction The wall must be made of a material suited for screw mounting and
approved for damp rooms. The hatched area is the minimum area for
reinforcement of the wall. Reinforcement from floor to ceiling is advisable.
Load-tested according to DS/ISO 17966 the maximum user weight has been fixed
at 80kg (176 lbs).
Max. tensile load of upper screws 88kg/screw (194lbs/screw)
The washbasin is supplied with a set of 10 screws and rawlplugs suitable for
mounting on a concrete wall. The fitter should always consider the material,
condition and strength of the wall and use screws and rawlplugs suitable for
the specific wall type.
Plumbing The drain hose is a flexible Ø32 (1 ¼”) hose.
The water supply ends in 2 (two) 90° shut-off valves with ½” or 3/8″ outside
thread pointing downward (not included). The flexible water connection hoses
from the washbasin end in Ø10 pipes. Adapter fittings from these pipes to the
shut-off valves are available with Ropox and as standard plumbing components.
If a location of the drain higher than the recommended positioning is
required, there may be a risk of reduced draining from the washbasin. For
purchase of adapters for connection to various standard installations, see
“Connection Adapters Swing Washbasin”.
Note: All dimensions are based on adjustment of the washbasin from 750 – 900
mm (29 ½” 35 ½”) above floor level. If a change of this adjustment range is
required, the recommended dimensions must be changed accordingly.
24 TF 200.01.0036_eng
4.4.4 Height-adjustable with high wall unit (40-41140)
CONSTRUCTION The wall must be made of a material suited for screw mounting and
approved for damp rooms. The hatched area is the minimum area for
reinforcement of the wall. Reinforcement from floor to ceiling is advisable.
Load-tested according to DS/ISO 17966 the maximum user weight has been fixed
at 80kg (176 lbs).
Max. tensile load of upper screws 88kg/screw (194lbs/screw)
The washbasin is supplied with a set of 12 screws and rawlplugs suitable for
mounting on a concrete wall. The fitter should always consider the material,
condition and strength of the wall and use screws and rawlplugs suitable for
the specific wall type.
PLUMBING The drain hose is a flexible Ø32 (1 ¼”) hose.
The water supply ends in 2 (two) 90° shutoff valves with ½” or 3/8″ outside
thread pointing downward (not included). The flexible water connection hoses
from the washbasin end in Ø10 pipes. Adapter fittings from these pipes to the
shut-off valves are available with Ropox and as standard plumbing components.
If a location of the drain higher than the recommended positioning is
required, there may be a risk of reduced draining from the washbasin.
For purchase of adapters for connection to various standard installations, see
“Connection Adapters Swing Washbasin”.
Note: All dimensions are based on adjustment of the washbasin from 750 – 900
mm (29 ½” 35 ½”) above floor level. If a change of this height-adjustment
range is required, the recommended dimensions must be changed accordingly.
25 TF 200.01.0036_eng
186 7 21/64″
226 8 57/64″
5. Safety in use
The Ropox Swing Wash Basin should only be used by people, who have read and
understood these instructions.
Always use the washbasin so there is no risk of damage to people or property.
The person, who operates the Ropox Swing Wash Basin, is responsible for
avoiding damage or injury.
Children or persons with reduced observation capability should only use the
washbasin when supervised.
If the washbasin is used in publicly accessible locations where children or
people with reduced observation ability may get close to the Ropox Swing Wash
Basin, the person operating the washbasin must pay sufficient attention in
order to prevent dangerous situations.
Do not operate the washbasin in case of defects or damage. Do not overload the
washbasin. Modifications, which may influence the operation or construction of
the wash basin, are not
allowed. Installation, service and repairs must be carried out by competent
personnel. If the washbasin has not been assembled according to these mounting
instructions the right to
complain may become void. Only use Ropox original spare parts as replacement
parts. If other spare parts are used, the right
to complain may become void. Be aware not to swing the wash basin into the
wall at great force it might damage the wash basin
or wall. Keep notice that there is no overflow build into the wash basin. Only
use Ropox’ overflow plug to
fill the wash basin. Overflow of water can cause slippery floor and should be
avoided to minimize the risk of slipping or falling. To avoid risk of pinching
be aware not to place your hand between the wash basin and dock-in when locked
in position. Be aware to check that the wash basin is properly locked in place
in the dock-in before applying any loads. The wash basin may only be applied
to personal hygiene purposes. Do not lean on the accessories attached to the
wash basin. To avoid entrapment do not place you head or body parts between
the water connection hose and the swinging arm. Be aware that the wash basin
might be slippery if covered in water and soap.
26 TF 200.01.0036_eng
6. Cleaning
Note! Do not use cleaning agents containing abrasive e.g. scouring powder,
steel wool, scouring sponge. This product is not designed to be sterilized,
autoclaving and sterilization beyond normal cleaning is may possibly change
the product safety and function.
6.1 Cleaning of the wash basin It is important that the wash basin is cleaned
according to these guidelines. Clean the washbasin with a wrung cloth with
lukewarm water and a mild detergent. Do not use abrasives or grinding cloths.
Ropox Swing wash basin is made of a composite material of marble and plastic
granulate with a gel coat surface. This gives a hard and very hardwearing
finish, which is easy to clean. Wash the surfaces daily with water and dry
with a cloth. Do not use detergents containing hard abrasives e.g. steel
wool, scouring powder or sulfuric acid. If the water has high calcium content,
calcareous deposits will often occur. These deposits should be removed at
least once a week by using a detergent containing citric acid, acetic acid or
phosphoric acid. Leave the detergent to work for 5 to 10 minutes depending on
the thickness of the deposits and clean thoroughly with a soft sponge.
Disinfection of the basin may be done with household spirits.
7. Maintenance
Note! Failing to comply with periodic maintenance may result of degrading of
product function and safety.
The wash basin is maintenance-free, and the moving parts have been lubricated
for life. For reasons of safety and reliability we recommend inspection of the
washbasin once a year: · Check that all bolts have been securely tightened. ·
Check that the washbasin rotates freely and that the arm swings properly After
each inspection, fill in the service schedule. Only use Ropox original spare
parts for replacement of parts. If other spare parts are used, the right to
complain may become void.
27 TF 200.01.0036_eng
8. Components part list
Note!
Ropox will make parts list available for extraordinary maintenance and repair
beyond what is described in this manual. Repair beyond what is described in
this manual may only be done by Ropox designated service personnel.
9. Environmental protection
The product is not intended to be disposed as municipal waste. Proper
disassembly, sorting and disposal of components must be done by waste disposal
professionals.
Part Wash basin Main unit Faucet Cover
Disposal recommendation Ceramic Steel Steel Aluminum
10. Complaints
See our general terms of sale and delivery on www.ropox.com
ROPOX A/S
Ringstedgade 221 DK 4700 Næstved Tel.: +45 55 75 05 00 Fax.: +45 55 75 05 50
E-mail: info@ropox.dk
www.ropox.com
28 TF 200.01.0036_eng
References
- Ropox - World's leading disability friendly solutions
- Ropox - World's leading disability friendly solutions