Mobilex 306040-306601 Rubber Ramps User Manual
- June 3, 2024
- Mobilex
Table of Contents
306040-306601 Rubber Ramps
**User Manual
Rubber ramps
With non-slip surface for Indoor and outdoor use
Made of rubber (TPE) – PVC free
Available w/without glue on the back side
Mobilex A/S
Grønlandsvej 5
DK-8660 Skanderborg
www.mobilex.dk
**
306040-306601 Rubber Ramps
| |
---|---|---
Rubber ramps
Available in heights from 4 mm to 60 mm
Widths 700 – 900 – 1000 mm| Accessories
Glue tape for adhere to floor Adhesive removal
Mounting brackets| Customization
Multiple possibilities for
height and width adjustments
Introduction
We are pleased that you have purchased a quality product from Mobilex. This
user manual contains a detailedproduct description and essential instructions
for the correct use of the product. Therefore, please read this manual
carefully before using the product. Please pay attention to all precautions,
especially the safety instructions, and always comply with them in order to
achieve a safe and long-lasting use of the product.
Intended use of the product
The product is a medical device used by elderly people or people with mobility
impairments who need equipment to overcome obstacles, such as steps, with or
without the assistance of a caregiver. The ramps are designed to compensate
for level differences down to 4 mm and up to 60 mm. With the additional option
of modular construction.
The ramps can be used indoors as well as outdoors. No other use than that
described in the purpose statement is permitted.
Indications
Ramps are indicated for people with mobility limitations who due to problems
with walking, standing or sitting are forced to use mobility devices such as
wheelchairs, scooters, rollators etc. Ramps are indicated for elimination of
architectural obstacles by smooth connection of the level differences that a
wheelchair user has to overcome and thus they allow the wheelchair user to
reach places normally inaccessible to him/her.
The ramp is intended for use independently or with the help of an attendant.
Using the ramp for purposes other than those indicated above, is prohibited.
Contraindications
Contraindications cannot be tied to a specific clinical picture. The choice of
a suitable ramp type and length must always be made with the help of a
specialist doctor or physiotherapist. Observe the safety information in
chapter 2.
If you have any questions, please contact your dealer or Mobilex A/S
Mobilex A/S
Grønlandsvej 5
DK-8660 Skanderborg
Denmark
Phone: +45 87 93 22 20
Telefax: +45 87 93 17 77
Email: [email protected]
Safety requirements
- Only use the product in perfect condition.
- If any defects or faults are found in the product, the dealer should be contacted immediately.
- Pay attention to the information on the product label.
- Use the product only for the stated purpose.
- Make sure that this user manual is read by all persons using the ramp. Damage caused by not following the user manual will not be compensated.
- Use the ramp only for its intended purpose.
- Only use ramps that are in good technical condition.
- The ramp may only be used on a stable surface.
- The product must never be subjected to loads exceeding a total of 350 kg.
Description
Product description
Mobilex rubber ramps are made of TPE and contain no toxic substances (PVC
free). The product has a grooved surface which makes it slip-resistant. The
ramps can be used both indoors and outdoors.
Parts supplied:
✔ This instruction manual
✔ 1 or more rubberramps
First control
Check above that nothing is missing. If anything is missing, contact the
retailer of the product immediately.
Mounting and assembly instructions
The rubber ramp mounting kit consists of two mounting brackets that are
installed in the doorstep. It is then possible to mount rubber ramps without
gluing the ramp to the substrate (item no. 306910).
Cutting
of rubber ramps
The rubber ramps are easily adjusted in width with a sharp hobby knife or saw
blade from Mobilex (art. no. 306904).
For higher ramps, it is necessary to cut several times in the same groove.
After each cut, break the ramp backwards to facilitate the next cut.
Possibility to combine the ramps with modular construction
Measurements on the outside, inside and possibly the height of a rubber ramp.
Choose suitable ramps.
Can also be built on top of each other.
Accessories
The following accessories are available for the rubber ramps:
Mounting set for rubber ramp zinc plated, 28-60 mm height (306910)
Jigsaw blade for rubber ramp (306904)
Double adhesive tape, width 20 mm, length 50 meter (306911)
Double adhesive tape, width 35 mm, length 50 meter (306912)
Degreaser for removal of glue 1/2 L (306905)
Transport recommendations
The ramps are removable if not glued and can therefore be easily moved to a
new location if necessary
Technical Data:
| Height | Depth | Width | Weight |
|---|---|---|---|
| 4 mm | 40 mm | 900 mm | 130 g |
| 4 mm | 40 mm | 1000 mm | 150 g |
| 6 mm | 60 mm | 900 mm | 310 g |
| 6 mm | 60 mm | 1000 mm | 350 g |
| 8 mm | 80 mm | 900 mm | 490 g |
| 8 mm | 80 mm | 1000 mm | 540 g |
| 10 mm | 100 mm | 900 mm | 770 g |
| 10 mm | 100 mm | 1000 mm | 860 g |
| 12 mm | 120 mm | 900 mm | 1070 g |
| 12 mm | 120 mm | 1000 mm | 1190 g |
| 16 mm | 150 mm | 900 mm | 1230 g |
| 16 mm | 150 mm | 1000 mm | 1370 g |
| 20 mm | 150 mm | 900 mm | 1850 g |
| 20 mm | 150 mm | 1000 mm | 2050 g |
| 24 mm | 150 mm | 900 mm | 1950 g |
| 24 mm | 150 mm | 1000 mm | 2170 g |
| 28 mm | 200 mm | 900 mm | 2180 g |
| 32 mm | 200 mm | 900 mm | 2960 g |
| 36 mm | 200 mm | 900 mm | 3990 g |
| 40 mm | 250 mm | 900 mm | 3550 g |
| 44 mm | 250 mm | 900 mm | 4250 g |
| 48 mm | 250 mm | 900 mm | 5190 g |
| 52 mm | 300 mm | 900 mm | 5800 g |
| 56 mm | 300 mm | 900 mm | 6500 g |
| 60 mm | 300 mm | 900 mm | 7700 g |
Rubber ramps are also available in length 700 mm in sizes 10-48 mm (all models
with self-adhesive tape).
NOTE! Dimensions and weight of rubber ramps may vary.
Product label
MOBILEX A/S
Grønlandsvej 5
DK – 8660 Skanderborg
Tel: +45 87 93 22 20
www.mobilex.dk
Rubber ramps
with glue 4 x 40 x 900mm
Image of the product label
Overview icon meaning
| QR-code link to homepage| | Manufacturing date
---|---|---|---
| Manufacturer| | Max load
| Observe the user manual| | Max width
| To be used indoor and outdoor| | serial no
| CE marked product| | Item Number
| Max load basket| | Medical Device
| Only to be used indoor| |
Care & Maintenance
The rubber ramps are maintenance-free and can be easily cleaned with ordinary
detergents. Machine washable according to The Danish Serum Institute
guidelines for MRSA in home care and in nursing homes.
✔ Cleaning and disinfection of the product
Recommended service life: Normally 10 years depending on use.
Storage
We recommend storage in a dry place.
Reuse
The product is suitable for reuse. Before reusing, where a new user is to take
over the product, the product must be checked according to point 5.
Most common problems and solutions
| Symptoms | possible cause | what to do? |
|---|---|---|
| The rubber ramp is unstable or does not stay in the desired position | The | |
| surface is not level | Use the mounting kit to attach the ramp to the doorstep |
or seek alternative attachment methods*
- On delicate surfaces such as carpets and wooden floors, it is not recommended to attach rubber ramps with adhesive tape.
Disposal of the product
The device cannot be deposited with normal garbage. It must be delivered to the public station for re-use.
Guarantee terms
Mobilex A/S offers 2 years of warranty for damages caused by errors in
production or material errors. The warranty is not valid by not-intended
repair or usage of the product. Parts subject to normal wear are not covered
by the warranty, unless wear is caused by a manufacturing fault. If product
changes are made without our written acceptance the CEmarking and product
warranty will not be valid. In the event of product damages covered by this
warranty, please notify your dealer or Mobilex A/S directly.
The warranty does not cover transport costs and does not include compensation
for personal injuries or non-use of the product during repair. The warranty
does not cover damages due to the user manual not being followed.
https://mobilex.dk/en/aids/threshold-ramps/
In case of unintended incidents or suspected faults, failures or defects of the product, the dealer or Mobilex A/S must be contacted
Declaration of Conformity (CE)
Mobilex A/S, Grønlandsvej 5, DK-8660 Skanderborg, Denmark, SRN: DK-
MF-000021885
Hereby declare under our sole responsibility as a legal manufacturer that
the product specified on the product list below, meet the essential health and
safety requirements and is in conformance with the provisions of the
Regulation (EU) 2017/745 OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL on
medical devices.
The product specified on the product list below is “technical aid for the
disabled”, classified as Class I, medical device.
The CE marking has been affixed on the product according to Annex V of the
Regulation (EU) 2017/745.
PRODUCT LIST
REF/item no.| 30610L| 30612L| 30616L| 30620L|
30624L
---|---|---|---|---|---
UDI-DI| 5740001430004| 5740001430011| 5740001430028| 5740001430035|
5740001430042
REF/item no.| 30628L| 30632L| 30636L| 30640L| 30644L
UDI-DI| 5740001430059| 5740001430066| 5740001430073| 5740001430080|
5740001430097
REF/item no.| 30648L| 306040| 306041| 306042| 306060
UDI-DI| 5740001430103| 5740001430110| 5740001430127| 5740001430134|
5740001430141
REF/item no.| 306061| 306062| 306080| 306081| 306082
UDI-DI| 5740001430158| 5740001430165| 5740001430172| 5740001430189|
5740001430196
REF/item no.| 306100| 306101| 306102| 306120| 306121
UDI-DI| 5740001430202| 5740001430219| 5740001430226| 5740001430233|
5740001430240
REF/item no.| 306122| 306160| 306161| 306162| 306200
UDI-DI| 5740001430257| 5740001430264| 5740001430271| 5740001430288|
5740001430295
REF/item no.| 306201| 306202| 306240| 306241| 306242
UDI-DI| 5740001430301| 5740001430318| 5740001430325| 5740001430332|
5740001430349
REF/item no.| 306280| 306281| 306282| 306320| 306321
UDI-DI| 5740001430356| 5740001430363| 5740001430370| 5740001430387|
5740001430394
REF/item no.| 306321| 306322| 306360| 306361| 306362
UDI-DI| 5740001430394| 5740001430400| 5740001430417| 5740001430424|
5740001430431
REF/item no.| 306400| 306401| 306402| 306440| 306441
UDI-DI| 5740001430448| 5740001430455| 5740001430462| 5740001430479|
5740001430486
REF/item no.| 306442| 306480| 306481| 306482| 306520
UDI-DI| 5740001430493| 5740001430509| 5740001430516| 5740001430523|
5740001430530
REF/item no.| 306521| 306522| 306560| 306561| 306562
UDI-DI| 5740001430547| 5740001430554| 5740001430561| 5740001430578|
5740001430585
REF/item no.| 306600| 3066601| 306602| |
UDI-DI| 5740001430592| 5740001430608| 5740001430615| |
ACCESSORIES LIST
| Item no | Accessories item no. |
|---|
30610L-
306602| 306904: Jigsaw blade for rubber ramp
306911+12: Double adhesive tape
306905: Degreaser for removal of glue
306910: Mounting set for rubber ramp zinc plated
Harmonized norms used during conformity estimation: PN-EN ISO
11199-3:2008; EN ISO 14971:2011, EN 1041:2009
In case of unintended incidents or suspected faults, failures or defects of
the product, the dealer or Mobilex A/S must be contacted
EU2017/745 for Medical Equipment
Managing Director
Serial number / notes
Rev. 10.05.22
UM-306040-306601-MULTI10052022.odt
Documents / Resources
|
Mobilex 306040-306601 Rubber
Ramps
[pdf] User Manual
306040-306601, Rubber Ramps, 306040-306601 Rubber Ramps
---|---