FOAMit FI-BP-25N 25 Gallon Battery Powered Foam Unit Instruction Manual

READ ALL INSTRUCTIONS BEFORE USING OR SERVICING THIS UNIT. KEEP THIS MANUAL IN A LOCATION THAT IS READILY AVAILABLE TO USERS AND SERVICE TECHNICIANS.

Safety

WARNING

PEOPLE OR OBJECTS CAN BE HURT OR DAMAGED IF THIS UNIT IS NOT USED CORRECTLY!

First Aid Instructions

• Failure to follow first aid instructions may result in death or serious personal injury.
• If battery liquid comes in contact with skin, wash immediately with soap and water, then neutralize with lemon juice or vinegar.
• If battery liquid gets in your eyes, flush with clean water for a minimum of 10 minutes, then seek immediate medical attention.
• If battery liquid is swallowed, seek immediate medical attention.

State of California Proposition 65 Warning

• The battery can expose you to chemicals, including cobalt, lithium, manganese, nickel, oxide, and carbon black, which are known to the State of California to cause cancer and reproductive harm. For additional information, go to www.P65Warnings.ca.gov.

NOTICE

Refer to the separate manuals supplied with the battery and charger for additional safety precautions and instructions.
Servicing or modifying this unit with parts not listed in this manual may cause the unit to operate improperly. Do not use unauthorized parts when servicing the unit.

  Protect the Environment
Please dispose of packaging materials, old machine components, and hazardous fluids in an environmentally safe way according to local waste disposal regulations

Service Guide

WARNING

Performing any maintenance with the unit pressurized may result in serious injury or death. Always ensure the unit has been depressurized before conducting any maintenance. Servicing or modifying this unit with parts not listed in this manual may cause the unit to operate improperly. Do not use unauthorized parts when servicing the unit.

Maintaining Your Unit

To keep your unit operating properly, periodically perform the following maintenance procedures:

• Inspect the pump for wear and leaks.
• Inspect all hoses for leaks or excessive wear. Verify all hose clamps are in good condition and properly secured.
• Check the suction line and strainer for debris. Clean as needed.
• If foam quality beings to decrease, inspect the wadding. Replace as needed.
• Store battery in a half-charged state and maintain battery every 3-6 months.

Servicing Your Unit

Most repairs on the unit can be performed with the following tools:

• Crescent wrench (2x)
• 1/4 in. (7 mm) hex bit
• Flat head screwdriver
• Thread seal tape

• 2 Phillips head screwdriver

• 3 Phillips head screwdriver

• Hose cutters
• Knife

Troubleshooting Your Unit

If your unit is not operating properly, try using these troubleshooting tips:

Tank Assembly

Front view

TNKA-25N-BK:
25 gallon natural tank assembly – black* lid – includes drain plug, wheels, suction valve, and backplate thumb nuts

TNKA-25N-BK:
25 gallon natural tank assembly – black* lid – includes drain plug, wheels, suction valve, and backplate thumb nuts

Back Plate Assembly

Inside view

PA-PF38-BP:
Plate assembly for portable foam battery unit – 24 Volt battery and air compressor – 3/8 in. discharge hose barb

Back view

Back Plate Sub-assemblies

Hose Assembly

Wand Assembly Options

PWA384-ST-MX:
Poly wand assembly for 3/8 in. hose – includes 4 in. poly wand, ST8030SS spray tip, ball valve, and mixing media

PSGA384-ST-MX:
Poly spray gun assembly for 3/8 in. hose – includes 4 in. black poly wand, ST8030SS spray tip, mixing media, hose barb, and screw band clamp

Read More About This Manual & Download PDF:

References

• P65Warnings.ca.gov

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>