emerio SDF-2050 Deep Fryer Instruction Manual

SDF-2050

Deep Fryer

IMPORTANT SAFEGUARD INSTRUCTIONS

When using electrical appliances, basic safety precautions should always be followed: Read all instructions.

1. This appliance shall not be used by children from 0 years to 8 years. This appliance can be used by children aged 8 years and above if they are continuously supervised. This appliance can be used by people with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning the use of the appliance in a safe way and understand the hazards involved.
2. Keep the appliance and its cord out of reach of children less than 8 years.
3. Cleaning and user maintenance shall not be made by children.
4. Cooking appliances should be positioned in a stable situation with the handles (if any) positioned to avoid spillage of the hot liquids.
5. If the supply cord is damaged, it must be replaced by the manufacturer, its service agent, or similarly qualified persons in order to avoid a hazard.
6. Regarding the instructions for cleaning the surfaces which come in contact with food or oil, please refer to the paragraph “cleaning and maintenance” of the manual.
7. This appliance is intended to be used in household and similar applications such as staff kitchen areas in shops, offices, and other working environments; farm houses; by clients in hotels, motels, and other residential type environments; bed and breakfast type environments.
8. In case of damage, caused by not paying attention to this instruction manual, the warranty expires at once. The manufacturer/importer does not accept any liability for damage caused as a result of ignorance of the user manual, careless usage, or the usage against the instructions in this manual.
9. This product can only be used according to its rated information printed on the rating label.
10. Make sure the national voltage supply is in compliance with the rating label information. If you have any doubt about the way of operating the product or you are not sure about the compliance of the ratings with the national power supply please contact an authorized electrician/service center.
11. The socket must be designed so that the attached plug will fit into it.
12. This product is for indoor use only! It is not suitable for outdoor use.
13. Please prevent the product to be exposed to excessive dirt and humidity.
14. Any other way of operating the product, except the described one, will lead to dangers such as short circuits, fire, or else. It is not allowed to modify this product in any way and the housing has not to be opened, otherwise, the product will no be any longer in compliance with its safety class.
15. Never connect or disconnect the plug with wet hands.
16. Never unplug the plug by pulling the power supply cord. Always pull the plug itself.
17. During installation/cleaning, please pay attention that the power supply cord will not be squeezed or damaged.
18. Always disconnect the appliance from the mains and allow the product to cool down to room temperature: before storing away the appliance; before cleaning or maintenance; after use; if you are not going to use it for a long period of time.
19. Clean the product itself with a slightly damp cloth.
20. Never replace a damaged power supply cord by yourself. In such case, or in case of malfunction, contact an authorized electrician/service center for examination, repair or adjustment because special tools are required.
21.  Products, which are operated on mains supply, do not belong in the hands of children.
22. Keep out of the reach of children and never leave the unit unattended when switched on.
23. Make sure that the power supply cord does not come into contact with any parts, which generate excessive heat.
24. If you assume that the operating of the product without danger is no longer possible please make sure that the product will be disconnected and not used any longer. The safe operating of this product is no longer possible, if: the product or the power supply cord is damaged in any way; the product does not work any longer; after a longer storage under unfavorable conditions; after heavy damage through transportation.
25. Never immerse the plug or the appliance in water or other liquid.
26. Never place the deep fryer directly into corners and under flammable materials such as curtains, cupboards, etc.
27. Do not operate the machine without supervision, if you should leave the workplace, always switch the machine off or remove the plug from the socket (pull the plug itself, not the lead).
28. Do not move the device when the fat is liquid/hot.
29. Never leave the appliance unattended during use.
30. Keep the lid tightly closed during use.
31. Please always use the frying basket for deep-frying.
32. Always make sure the oil tank is dry and free of water before use. If not the hot oil can be blown out of the tank and burn and injure people, as the oil and the water have a different boiling temperature.
33. Warning: Never mix fats and oils, as the deep fat fryer could spill over, even the mixing of various types of oil and fat with one another is dangerous.
34. If the deep fat fryer should catch fire, do not under any circumstances attempt to extinguish the flames with water, instead, replace the lid and suffocate the flames with a damp cloth.
35. The machine should not be operated by means of an external timer switch or by means of a separate system with remote control.
36. This appliance is not designed for commercial use.
37. If an extension cord is used it must be suited to the power consumption of the appliance, otherwise overheating of the extension cord and/or plug may occur. There is a potential risk of injuries from tripping over the extension cord. Be careful to avoid dangerous situations.
38. ** Caution, hot surface.
    WARNING!!** Please do not touch surfaces while in use. The temperature of accessible surfaces may be high when the appliance is operating.

PARTS DESCRIPTION

1. Thermostat knob
2. Green temperature control light
3. Red power indicator light
4. Detachable control unit with the heating element
5. Handle of the basket
6. Detachable inner tank
7. Handle of the lid
8. Reset button

BEFORE USE
First read all instructions before use and retain for later reference. Only plug this appliance into an earthed socket. Before first use, remove the packing materials. Then, wash the accessories and the inner pan in warm water. Dry them well before use. Make sure that the electrical parts remain dry. The deep fryer is equipped with an adjustable thermostat and indicator lamps. The “open” frying system ensures excellent professional results and easy cleaning. The appliance may emit some smoke and a characteristic smell when you switch it on for the first time. This is normal and will stop soon.
HOW TO OPERATE THE DEEP FRYER
To fix the handle to the basket, press the ends together and insert the ends into the two rounds inside the basket. Press the handle on the rectangular metal part of the basket. Make sure it fits firmly.

• Never switch on the deep fryer without oil or fat, as this could damage the machine. Also, do not place any other liquids such as water or other substances in the pan.

• Place the deep fryer on a dry, stable surface.

• Since the deep fryer becomes hot during use, make sure that it is not too close to other objects.

• Remove the lid from the deep fryer and take out the accessories.

• Fill the deep fryer with the desired amount of oil or liquid fat. Only liquid fat can be used in this type of deep fryer. Make sure that it is filled not less than the minimum level and not higher than the maximum level as indicated on the inside of the appliance. Never mix fats and oils, as the deep fat fryer could spill over, even the mixing of various types of oil and fat with one another is dangerous.

• Connect the power plug to a suitable outlet; the red power indicator light illuminates.

• Set the thermostat knob to the required temperature setting, which is suitable for what you are frying. Consult the temperature table.

• The temperature control light shows green. The oil fat is heated to the required temperature within 10 to 13 minutes.

• Use the handle to place the basket in the deep fryer.

• Place the food to be deep-fried into the basket. For the best result, put dry food into the basket.

• Lower the basket into the oil slowly to prevent excessive bubbling. Always remember to put the lid back on the deep fryer after lowering the baskets into the fat.

• The indicator light will go out when the temperature you have selected has been reached. Always wait until the selected temperature has been reached. To keep the oil at the selected temperature, the thermostat repeatedly goes on and off, and the indicator light as well.

• Raise the basket again when the frying time has elapsed.

• After frying let the product drip dry, never shake the basket.

• Set the thermostat knob to the lowest level (turn the thermostat knob fully anticlockwise.)

• Remove the plug from the outlet.

• Rinse the handle and the basket after use, and dry thoroughly.

• Once the deep fryer has completely cooled off, you can replace the basket in the appliance and store it. Store the deep fryer, with the lid close, in a dark, dry place. In this way, you can leave the oil and the basket in the deep fryer when storing.
  FRYING TIPS

• When using one big basket, the maximum of food is 1300 grams.

• When using two small baskets, the maximum of food is 700 grams for each basket.

• If you want to fry deep-frozen food use a maximum of 75% of the above quantities.

• Always remove excess ice from frozen products before frying.

• When using fries made from fresh potatoes: dry the fries after washing so that no water will go into the oil.
  FRYING TABLE
  This table shows the food product quantities and required temperature and frying times. If the instructions on the product packaging should deviate from the values shown in this table, the instructions on the pack should be followed.

Tempe mature| Type of product| Maximum cycle| quantity per| Frying time(minutes)|
---|---|---|---|---|---
| | Fresh| Keep frozen| Fresh or defrosted| Keep frozen
160°C| Home-made chips
(first frying cycle)
Fresh fish| 600g

500g

| —

—

| 9-10

10-12

| —

—

170°C| Chicken wings
Cheese croquettes
Small potato fritters
Fried vegetables
(mushrooms, cauliflower)
Home–made chips
(second frying cycle)max.175°C
Deep-frozen chips max.175°C| 10-12
10
—
10-12600g

—

| 12-13
9
9
—-

550g

| 10-12
9-10
—
2-39-10

—

| 12-13
10-12
9-10
—-

5-6

180°C| Spring rolls
Chicken nuggets
Mini snacks
Meatballs(small)
Fish fingers
Mussels
Coated squid rings
Fish in batter
Shrimps
Apple rings| 7
10
10-12
8-10
8-10
15-20
10-12
10-12
1 0-125| 8
12
10
—
8
15
10
10
10
—| 7-8
3-4
3-4
3-4
3-4
3-4
3-4
3-4
3-4
3-4| 9-10
4-5
4-5
4-5
4-5
4-5
4-5
4-5
4-5
—
190°C| Potato chips
Aubergine slices
Potato croquettes
Meat/Fish croquettes
Doughnuts
Baked camembert(breaded)
Cordon bleu
Wiener Schnitzel| 600g
600g
5
5
4-5
2-4
2
2| 550g
—
4
4
—
—
—
—| 3-4
3-4
4-5
4-5
5-6
2-3
4-5
3-4| 5-6
—
6-7
6-7
—
—
—
—

TO REPLACE THE OIL
Make sure that the deep fryer and the oil have totally cooled off before replacing the oil. Replace the oil regularly. This is definitely necessary if the oil becomes dark or takes on a different odor. In any case, replace the oil once after every 10 times usage. Replace the oil all at once; do not mix old and new oil. Discarded oil is a burden to the environment. Do not throw in the normal rubbish bin, but follow the guidelines of the municipal waste collector in your area.

CLEANING AND MAINTENANCE

• Clean the deep fryer on both the inside and outside regularly.
• Clean the outside of the deep fryer with a damp cloth and dry with a soft, clean cloth.
• Never use abrasive cleaners or sponges.
• The basket and the handle can be cleaned in warm, soapy water. Dry well before using again.
• When replacing the oil you can also clean the inside of the deep fryer. Empty the deep fryer and first clean the inside with a paper towel and then with a cloth dipped in soapy water. Then wipe with a damp cloth and allow them to dry thoroughly.
• All components, with the exception of the electrical parts, may be cleaned in warm soapy water. Dry thoroughly before use.
• Dishwasher cleaning is not recommended.

TIPS

• Always place the deep fryer on a stable surface and keep all flammable materials away.
• Make sure that the deep fryer is not near or on a switched-on hot plate.
• Before you use the deep fryer it must be filled with the required amount of oil or fat.
• Never use the deep fryer without oil or fat because this could damage the unit.
• Never move the deep fryer during use. The oil becomes very hot and you can get burned. Wait to move the deep fryer until the oil has cooled off.
• This deep fryer is protected with a thermal safety device, which switches the machine off automatically if it overheats.
• Never immerse the unit in water.
• Never leave the deep fryer unattended while in use. Always ensure the safety of children if they are near the deep fryer.
• If the deep fryer and/or cord are damaged, they must be repaired by a professional service department.
• Do not try to repair the unit by yourself, nor replace a damaged cord. This requires special tools.
• Be sure not to damage the heating element. (Do not bend or dent.)
• The electrical component is equipped with a safety cut-off, which ensures that the heating element can only function when the element is correctly placed on the fryer.

SAFETY

Safety thermal cut-out
In the event of overheating, the thermal cut-out will switch off the deep fat fryer. This can happen if the deep fat fryer is not filled with sufficient oil or solid frying fat is melted in the deep fat fryer. In the case of solid fat is melted in the deep fat fryer. In the case of solid fat, the heating element is unable to radiate the produced heat quickly enough. If the safety thermal cut-out switches off the deep fat fryer, proceed as follows:

• Allow the oil or fat to cool down.
• Carefully push in the (reset switch) at the rear of the control element with a small screwdriver. The deep fat fryer is now ready to use again.

Safety switch
The safety switch in the control element ensures that the heating element can only be switched when the control element locks with a click.

TECHNICAL DATA

Operating voltage: 220-240V~ 50Hz
Power: 2000W

TROUBLESHOOTING

The device is not working
Troubleshooting:

• Check the mains connection.
• Check the position of the thermostat.

Troubleshooting:
Check that the control element is correctly in place.
Other possible causes:
The device is fitted with a RESET button. This prevents the heater from being switched on accidentally.
Overheating Protection

• If you should accidentally switch on your deep fat fryer when there is no oil or fat in it the overheating protection is automatically turned on. The appliance is no longer ready to be used. Unplug the deep fryer.
• Only after the device has been left to cool down completely should the RESET button on the rear of the control element be operated in order to use the deep fat fryer again. Please use a pointed object for this purpose.

GUARANTEE AND CUSTOMER SERVICE

Before delivery, our devices are subjected to rigorous quality control. If, despite all care, the damage has occurred during production or transportation, please return the device to your dealer. In addition to statutory legal rights, the purchaser has an option to claim under the terms of the following guarantee: For the purchased device we provide 2 years guarantee, commencing from the day of sale. If you have a defective product, you can directly go back to the point of purchase. Defects that arise due to improper handling of the device and malfunctions due to interventions and repairs by third parties or the fitting of non-original parts are not covered by this guarantee. Always keep your receipt, without the receipt you can’t claim any form of warranty. Damage caused by not following the instruction manual will lead to a void of warranty, if this results in inconsequential damages then we will not be liable. Neither can we hold responsible for material damage or personal injury caused by improper use if the instruction manual is not properly executed? Damage to accessories does not mean free replacement of the whole appliance. In such case please contact our service department. Broken glass or breakage of plastic parts is always subject to a charge. Defects to consumables or parts subjected to wearing, as well as cleaning, maintenance, or the replacement of said parts are not covered by the warranty and are to be paid.

ENVIRONMENT-FRIENDLY DISPOSAL

Recycling – European Directive 2012/19/EU
This marking indicates that this product should not be disposed of with other household wastes. To prevent possible harm to the environment or human health from uncontrolled waste disposal, recycle it responsibly to promote the sustainable reuse of material resources. To return your used device, please use the return and collection systems or contact the retailer where the product was purchased. They can take this product for environmentally safe recycling.

Importer:
Biasicom SRL
420129 Bistrita, Viilor nr.10
www.biasicom.ro

References

• Biasicom
• Biasicom

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>