Evakool TMDZ50 43L TRAVELMATE DUAL ZONE FRIDGE/FREEZER Instruction Manual

TRAVELMATE
INSTRUCTION MANUAL

CHILLED FOR GOOD TIMES

FOR MODELS
TMDZ50 – 43L DUAL ZONE, TMDZ60 – 51L DUAL ZONE, TMDZ70 – 62L DUAL ZONE, TMDZ80 – 80L DUAL ZONE, TMDZ95 – 96L DUAL ZONE

Please read the operating manual carefully before using your unit.
Please keep the manual in a safe place.
If lost you can find a digital copy at Evakool.com.au or contact Evakool on 1300 865 665.

Key Product Features

• Reliable cooling system – SECOP compressor.
• Efficient electronic technology, and low energy consumption.
• Multi-voltage system (DC 12-24 Volt) and (AC 100-120/220-240 Volt).
• Digital Battery Protection – protects your vehicle battery effectively.

NOTE
Your fridge is preregistered with the following user account for the APP.
User: 12345678900
Password: 123456

Safety Instructions

• Warning: Do not touch exposed cables.
• Warning: Do not use the fridge if you suspect any connections could be wet.
• When using the fridge in the vehicle or boat, please ensure the circuit being used is\ fused.
• Any installation of DC power systems should be handled by a qualified professional.
• Make sure the source voltage is correct. The technical data label has the voltage data.
• Do not place any electrical devices inside the refrigerator as moisture could harm these devices.

Notes On Using The Product

• Your refrigerator requires good ventilation, especially around the vents of the refrigerator; allow a gap of at least 200mm around the vents.
• Avoid humidity: humidity inside the appliance can form frost and impair cooling. Do not allow frost to build up.
• Never clean the appliance using a hose and never submerge the unit in any liquid.
• Avoid placing your refrigerator near a heat source. This helps the refrigerator to work more efficiently and keep the contents cool.
• Place the refrigerator on a flat surface and away from any edges. When using the fridge in a vehicle, please use a fastening device to secure it.

Operation

• Power: The refrigerator can be powered by a multi-voltage system utilizing either 12/24 Volts or 240 Volts. The electronic module controls the compressor motor and has the added function of three-stage battery protection. When the input voltage drops below the minimum, the compressor will cut out; when the voltage comes back up to the cutin value, the compressor will restart automatically.
• Battery Protection : The SECOP compressor requires approximately 11 .0 Volts (12 Volt System) or 23 .0 Volts (24V System) to operate. If the voltage drops below this the fridge will stop running.
• Cable Specification : The DC cables must have a suitable cross-section for their length (measured from the battery to the unit), according to this table:

Cable Thickness (Area)

| 12V Max Cable Length|

24V Max Cable Length

---|---|---
(mm2)| AWG| (m)| (ft)| (m)| (ft)
2.5| 13| 2.5| 8| 5| 16
4| 11| 4| 13| 8| 26
6| 9| 6| 20| 12| 39
10| 7| 10| 33| 20| 66

LED Control Panel

Temperature setting range: -18°C to 10°C.

• Plugin the DC or AC power.

• Press ****the button for 4 seconds to turn the fridge on. The LED display on the control panel will light up and the interior temperature will be displayed.

• Press the SET button once the left bin display will flash, and use the + and – buttons to set the desired temperature for this side .

• Press the SET button again the right side bin display will flash, use the + and – buttons to set the desired temperature for this side.

• Press the SET button again the C (Celsius) will flash and use the + and – buttons to change between C (Celsius) or F (Fahrenheit).

• Press the SET button again the V will flash, use the or buttons to change between .  (We recommend VL setting ) .
  VL – Voltage Low 10 .1 Volt cut out
  VM – voltage Medium 11 .4 Volt cut out
  VH – Voltage High 11 .8 Volt cut out

• Press the SET button again to lock in settings or just leave it for 5 seconds to lock in settings.

USB Charging Port and Thermostat Override Switch

USB Port

• This USB port can be used to charge small devices. E .g . mobile phones and remote controllers. The socket is rated to 500mA / 5 Volts.

Thermostat Override Switch

• If your digital thermostat fails and you are unable to set the temperature, turn this switch to Emergency override.
  This enables the fridge to run until you reach a service center to replace the faulty component.

• If emergency override is enabled the compressor will attempt to run 100% of the time.
  As this removed the ability to set the internal temperature and will increase power usage (total consumption), it is not recommended for everyday use.

Cleaning & Maintenance

• Clean the appliance inside and out with a clean damp cloth every week. If it is dirty, use sodium bicarbonate dissolved in lukewarm water to clean the unit.
• Never use abrasive products, detergents, or soap. After washing, rinse with clean water and dry carefully. Do not leave the refrigerator off with food inside or the lid closed.
• Never clean the appliance under running water. Do not use abrasive cleaning agents or hard objects during cleaning as these can damage the refrigerator.

Troubleshooting

The appliance is not turning on

• Check the power supply.
• Check whether the plug and the socket have a good connection.
• Check whether the fuse requires replacement.
• Check whether the appliance has been turned on.

The food inside is frozen

• The setting temperature is too low.

Bad performance in refrigeration

• The temperature setting is inappropriate.
• The lid is unlocked/or open.
• The lid seal is broken.
• Problems arising from poor ventilation.
• There is no room around the fridge and vents
• Too much food has been placed inside the refrigerator.
• There is too much warm product inside.
• There is a heat source near the unit.

Hear the sound of water from inside the unit

• This is normal, due to the flow of the refrigerant.

Unusual noise when the refrigerator is working

• The refrigerator is not placed on a level surface.
• Some part has come loose inside the refrigeration compartment (see a service agent).

If none of the above solves your issue please contact Evakool on 1300 385 665 or warranty@evakool.com for details of your closest Evakool service center.

Error Codes

Code

|

Reason / Solution

---|---
ER1| Thermistor is Unplugged – Contact EvaKool
ER2| Thermistor is Short Circuited – Contact EvaKool
II I| Low Voltage

· Please check the source voltage to ensure it is above the cutout. Try lowering the voltage cut-out setting to LOW.
· The vehicle cabling may be inadequate/unsuitable, please refer to the cable specifications table for correct cable thickness (page 5).
· Try on a different power source.

E2| Fan Issue
· Fan is drawing too many Amps (Over 1 Amp). – Contact EvaKool
E3| Compressor Start Issues

· Unplug for 10 minutes.
· Try on a different power source.
· Possible Electronic Box or compressor fault. – Contact EvaKool

| The Compressor Speed is Too Low

· Unplug for 10 minutes.
· Reduce product load inside the unit.
· Move unit to a lower ambient temperature.
· Clean vents / ensure clear airflow over the compressor.

| Ambient Temperature Too High

·  Clean vents / ensure clear airflow.
· Fan fault. – Contact EvaKool

Warranty Statement/Terms & Conditions

Newberg Pty Ltd trading as EvaKool undertakes to the original purchaser that this product is sold free of defects in materials and/or workmanship under normal use for a period of 36 months. Subject to the following:

• The warranty period commences from the date of purchase by the original purchaser from an authorized EvaKool dealer.
• The Secop compressor in this unit carries a 5-year warranty under normal use.
• EvaKool will honor this warranty on the presentation of proof of purchase of the unit to EvaKool or its approved service agent. The service agent may be requested to provide EvaKool with a photocopy of the proof prior to the warranty being honored.
• EvaKool will not be held responsible for any costs incurred in making a warranty claim.
• Please telephone 1300 865 665 for the name of an authorized service agent or refer to the list provided on the website. It is the purchaser’s responsibility to freight the unit to and from the service agent.
• EvaKool will not be held responsible for any damage or loss suffered or cost incurred whilst the fridge is in transit.
• Warranty repairs may only be carried out by an authorized service agent. EvaKool will not reimburse repair claims carried out by unauthorized service agents. Any unauthorized tampering with any part of the unit will automatically void the warranty.
• Service agents may charge a fee for viewing or testing the unit. This is not covered by EvaKool or this warranty and is payable at the service point unless authorized by EvaKool.
• Any EvaKool-authorised service center in Australia will be able to carry out the service of your unit. If a repair needs to be undertaken and is covered in terms of this warranty a warranty authorization number must be obtained prior to commencement of any work.
• This warranty does not extend to any products acquired for the purposes of re-supply, to be used up or transformed in a production or manufacture process or in repairing other goods.
• This fridge is intended for recreational use only. If used for commercial use, a 12-month warranty applies.
• To the extent permitted by law, this warranty does not extend to any claim for damages that you or any other person may have for any loss (including without limitation consequential damages or loss of profit) or damage howsoever caused.

• EvaKool will not accept a warranty claim if:

1. Modifications have been carried out to the unit without EvaKool’s written authority.
2. Damage to or failure of the unit has been caused in EvaKool’s opinion by incorrect, extreme, or unreasonable use.
3. Damage to or failure of the unit has been caused in EvaKool’s opinion by misuse, neglect, accident, impact, or similar cause. Refer to the preventative maintenance guidelines.
   • EvaKool has total discretion of the variation of the warranty terms.
   • Our goods come with guarantees that cannot be excluded under the Australian Consumer Law. You are entitled to a replacement or refund for a major failure and for compensation for any other reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure.
   • The above warranty conditions are in addition to any other rights and/or remedies as per the applicable law.
   • Failure to follow the guidelines/recommendations in this manual may void the warranty.
   • This warranty cannot be varied by others.

Please retain your receipt or proof of purchase for warranty purposes.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>