WARING WDM20 2 Speed Drink Mixer Instruction Manual

WARING WDM20 2 Speed Drink Mixer

Specifications:

• Model: WDM20
• Power Source: 120-volt
• Plug Type: 3-prong grounding-type plug
• Warranty: Limited one-year warranty (U.S. and Canada Only)

Product Usage Instructions

Important Safeguards:

1. Read all instructions carefully.
2. Always unplug from the outlet when not in use, before maintenance, and before cleaning.
3. This appliance should not be used by individuals with reduced capabilities.
4. Supervise children to prevent misuse of the appliance.

Grounding Instructions:
Ensure the product is connected to a properly grounded outlet.

Cleaning & Sanitizing Instructions:
To clean:

1. Turn off the unit using the power switch.
2. Unplug the power cord before cleaning.
3. Prevent liquid from entering the housing.

Use washing solutions as recommended in the manual for effective cleaning and sanitizing.

Helpful Hints:

• Keep all instructions and service information in a safe place.
• Ensure mixing cups are cleaned thoroughly after each use.
• Operate on Speed LO for thin-consistency drinks to avoid splashing.

FAQ:

• Q: What should I do if the appliance malfunctions?
  A: Unplug the appliance and contact an authorized service representative for examination and repair.

• Q: Where can I find the warranty information?
  A: The warranty details are provided in the manual. For the U.S. and Canada, refer to the Limited one-year warranty section.

• Q: Can I use the appliance outdoors?
  A: No, this appliance is not intended for outdoor use. Please use it indoors only.

For your safety and continued enjoyment of this product, always read the instruction book carefully before using it.

IMPORTANT SAFEGUARDS

When using electrical appliances, basic safety precautions should always be taken, including the following:

1. READ ALL INSTRUCTIONS.
2. Unplug from the outlet when not in use, before putting on or taking off parts, and before cleaning.
3. This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge.
4. Children should be supervised to ensure that they do not play with the appliance.
5. To protect against electrical hazards, do not put the Waring® Commercial Drink Mixer in water or other liquids.
6. Avoid contact with moving parts.
7. Do not operate the Waring® Commercial Drink Mixer or any other electrical equipment with a damaged cord or plug, or after the unit malfunctions or is dropped or damaged in any manner. Return it to the nearest authorized service facility for examination, repair, or adjustment.
8. Do not use outdoors.
9. Do not let the cord hang over the edge of the table or counter, or touch hot surfaces.
10. Put this instruction manual in a safe place. Do not discard.

SAVE THESE INSTRUCTIONS APPROVED FOR COMMERCIAL USE GROUNDING INSTRUCTIONS

• For your protection, the Waring® Commercial Drink Mixer is equipped with a 3-conductor cord set.

• 120-volt units are supplied with a molded 3-prong grounding-type plug and should be used in combination with a properly connected grounding-type outlet as shown in Figure 1.

• If a grounding-type outlet is not available, an adapter, shown in Figure 2, may be obtained to enable a 2-slot wall outlet to be used with a 3-prong plug.

• As shown in Figure 3, the adapter must be grounded by attaching its grounding lug under the screw of the outlet cover plate.
  CAUTION : Before using an adapter, it must be determined that the outlet cover plate screw is properly grounded. If in doubt, consult a licensed electrician.

• Never use an adapter unless you are sure it is properly grounded.
  NOTE : Use of an adapter is not permitted in Canada.

HOW TO USE YOUR  WARING® COMMERCIAL DRINK MIXER

• The spindle on your Waring® Commercial Drink Mixer has its own independent 1-peak HP motor. Your new Waring® Commercial Drink Mixer has an automatic ON/OFF button (actuator) located behind the front tab of each upper cup support that starts the motor when the mixing cup is placed in the proper position on the lower cup support. The cup support has two steps. To activate the automatic ON/OFF button, the bottom of the mixing cup must be securely resting on the upper step of the cup support, and the top rim of the mixing cup must go behind the front tab of the upper cup support.
• The motor will continue to operate while the mixing cup remains on the mixer, activating the actuator.
• Removal of the mixing cup will shut off the motor.
• The 2-speed toggle switch on the side of the Waring® Commercial Drink Mixer regulates the operating speed. Choose either LO (I), or HI (III) speed. For mixing heavy drinks, use HI (III) speed only; for light drinks with more liquid, use LO (I) speed.
• Your Waring® Commercial Drink Mixer is supplied with 2 agitators, 1 standard, and 1 “butterfly” (with movable flaps), per spindle. To change agitators, simply hold the spindle shaft with one hand and turn the agitator in a clockwise direction.
• This will loosen the screw, and you can unscrew to remove it. Insert the replacement agitator and screw the bottom screw back in. Use only a standard metal mixing cup with the standard agitator.

%CLEANING & SANITIZING INSTRUCTIONS

TO WASH:

1. TURN THE UNIT OFF USING THE POWER SWITCH LOCATED ON THE BACK OF THE UNIT, OR UNPLUG THE MIXER POWER CORD FROM THE ELECTRICAL OUTLET.
   DO NOT PUT IN DISHWASHER.

2. To remove the bottom cup supports (C), simply push each support up, then pull it out toward you.

3. To remove the upper cup supports (D), firmly hold the notches on both sides of the support, then pull directly out from the base.

• Use only low-foaming detergents formulated for cleaning dishware and cooking utensils. These products can be purchased from restaurant and commercial food-service suppliers. Follow the detergent manufacturer’s instructions.
• Add 12 ounces of washing solution to the mixing cup and place it in the normal operating position on the mixer.
• Run on LO speed for a minimum of two (2) minutes.
• Empty the cup and repeat the two-minute run with 12 ounces of water on LO speed.
• Empty the cup and repeat the two-minute run with 12 ounces of sanitizing solution on LO speed.
• Empty cup. Run the motor for a few seconds with an empty cup in the normal operating position to spin off any excess moisture. Do not rinse cup, spindle or agitator after sanitizing is completed. Allow all parts to air-dry.
• Reassemble the ON/OFF cup actuator and mixing cup supports to the mixer housing by reversing above steps 2 and 3.

TO SANITIZE: Use regular, unscented bleach diluted with water between 50°F and 120°F. Follow the food equipment cleaning instructions on the label to not exceed 200 ppm of total available chlorine. The sanitizing dilutions are based on the hypochlorite concentration of the bleach. The dilutions for two commonly available bleach concentrations are:

• Hypochlorite: 5.25% – 3 teaspoons of bleach per gallon of water
• Hypochlorite: 8.25% – 2 teaspoons of bleach per gallon of water

Immerse in or alternately spray the item with a sanitizing solution and soak for 2 minutes. Wash, rinse, and sanitize as outlined on page 6 before initial use, and whenever the mixer will not be used again within one hour to avoid bacteria buildup. Surfaces of the mixer housing that are outside of the food contact areas may be cleaned as required, using wiping cloths moistened with cleaning solution, rinse water, and sanitizing solution. TURN THE UNIT OFF OR UNPLUG THE POWER CORD FROM THE ELECTRICAL OUTLET BEFORE CLEANING THE HOUSING. Prevent liquid from running into housing by wringing all excess moisture from wiping cloths before using them. Washing solutions based on non-sudsing detergents and chlorine-based sanitizing solutions having a minimum chlorine concentration of 100 PPM are recommended. The following washing, rinsing, and sanitizing solutions, or their equivalents, may be used:

1%–2%: 1¼ – 2¾

Ounce/Gallon (lower dilution of 1% for normal cleaning and up to 2% for more stubborn soils)

| Room Temperature
Rinsing| Plain Water| | Warm 95˚F (35˚C)
Sanitizing| Clorox® Regular Bleach

(8.25% Hypochlorite Concentration)

| 2 Teaspoons/Gallon (Alternately a bleach with 5.25% Hypochlorite Concentration can be used at a dilution of 3 Teaspoons/Gallon)|

Clorox® is a registered trademark owned by the Clorox Corporation.

HELPFUL HINTS

1. Always turn the unit off or unplug the Waring® Commercial Drink Mixer before disassembling or assembling parts.
2. Be sure to keep all the instructions, parts lists, and service information in a safe and handy place.
3. If using ice, only use crushed ice or small cubes in the Waring® Commercial Drink Mixer.
4. Clean the Waring® Commercial Drink Mixer thoroughly before initial use.
5. Keep mixing cups clean. Wash, rinse, and sanitize thoroughly after use.
6. Be sure that all detachable parts are fastened tightly before operating the Waring® Commercial Drink Mixer.
7. Operate the Waring® Commercial Drink Mixer only when it is fully assembled.
8. To avoid splashing drinks of thin consistency, operate on Speed LO.

Any other servicing should be performed by an authorized service representative.

LIMITED ONE-YEAR WARRANTY

(U.S. and Canada Only)
Waring warrants every new Waring® Commercial Drink Mixer to be free from defects in materials and workmanship for one year from the date of purchase when used with foodstuffs, nonabrasive liquids (other than detergents) and nonabrasive semiliquids, provided it has not been subject to loads over the indicated rating. In addition, the motor in this appliance has a full three- year warranty. Under this warranty, the Waring Commercial Division will repair or replace any part that, upon our examination, is defective in materials or workmanship, provided the product is delivered prepaid to the Waring Service Center at: 314 Ella T. Grasso Ave., Torrington, CT 06790, or any Factory Approved Service Center. This warranty does not: a) apply to any product that has become worn, defective, damaged or broken due to use or due to repairs or servicing by other than the Waring Service Center or a Factory Approved Service Center, or due to abuse, misuse, overloading or tampering; or b) cover incidental or consequential damages of any kind. The one-year warranty applies only to appliances used in the United States or Canada; this supersedes all other express product warranty or warranty statements. For Waring products sold outside of the U.S. and Canada, the warranty is the responsibility of the local importer or distributor. This warranty may vary according to local regulations.
Warning : This warranty is void if the appliance is used on Direct Current (DC).

SERVICE

Should service on this product in the USA or Canada be required at any time, call or write to:
Waring Service Center 314 Ella T. Grasso Ave. Torrington, CT 06790
Tel. 1-800-492-7464 • FAX 860-496-9017
or nearest Authorized Service Center
Replacement parts for Waring Out of Warranty repairs are obtainable at the above address.

NOTE :
If your application involves the processing of biologically active materials, any items returned for service must be sterilized before being shipped. Such items must be identified as having been sterilized, both by a tag on the item itself and by a statement in the accompanying correspondence. Waring will not accept delivery of any returns unless they are so identified.

©2023 Waring Commercial 314 Ella T. Grasso Ave. Torrington, CT 06790
www.waringcommercialproducts.com
Printed in Taiwan
WDM20 IB
23WC087592
IB-17798

References

• Waring® Commercial

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>