JUMBO ATV9228RED Electric Vehicle Instruction Manual

JUMBO ATV9228RED Electric Vehicle

Specifications

• Model: ITEM ATV9228RED (GR)
• Standards: GB6675.1-2014, GB6675.2-2014, GB6675.3-2014, GB6675.4-2014, GB19865-2005
• Battery: 12V-4.5AH dry-sealed battery
• Motor: 12V-15W * 2
• Age Range: 3-8 years
• Weight Capacity: 30 kg
• Dimensions: 72 x 43 x 50CM
• Maximum Speed: 3km/h
• Charging Time: 8-12 hours
• Input: AC220V, 50HZ
• Output: DC12V, 500MA

Product Usage Instructions

Assembly:

1. Unpack all the components from the packaging.
2. Attach the seat to the frame using the provided screws and tools.
3. Install the wheels onto the frame and ensure they are securely attached.

Charging the Battery:

1. Connect the charger to an AC220V, 50HZ power source.
2. Plug the other end of the charger into the DC12V, 500MA charging port on the vehicle.
3. Allow the battery to charge for 8-12 hours.
4. Once fully charged, disconnect the charger from the vehicle.

Operating the Vehicle:

1. Ensure the vehicle is on a flat, open surface.
2. Turn on the power switch located on the vehicle.
3. Use the foot pedal to control the acceleration of the vehicle.
4. To stop the vehicle, release the foot pedal.
5. Always supervise children while operating the vehicle.
6. Avoid rough terrain and obstacles to prevent accidents.
7. Do not exceed the maximum weight capacity of 30 kg.

FAQ:

• How do I charge the battery?
  To charge the battery, connect the charger to an AC220V, 50HZ power source, and plug the other end into the DC12V, 500MA charging port on the vehicle. Allow the battery to charge for 8-12 hours and then disconnect the charger.

• How do I assemble the vehicle?
  To assemble the vehicle, attach the seat to the frame using the provided screws and tools. Then, install the wheels onto the frame and ensure they are securely attached.

• What is the recommended age range for this product?
  The recommended age range for this product is 3-8 years.

• What is the maximum speed of the vehicle?
  The maximum speed of the vehicle is 3km/h.

• Can adults ride this vehicle?
  No, this vehicle is designed for children only.

WARNING!

1. The assembly must be carried out by an adult as sharp parts are contained.
2. Not suitable for children under 36 months.
3. Adult supervision is required. Do not allow children to use the vehicle alone.
4. When playing, children should not stand upright on the seat.
5. Charging must be done by an adult. Fully charge before playing.
6. Keep plastic bags out of reach of children to prevent suffocation.
7. Use the accessories provided by the manufacturer.
8. Do not short‐circuit the battery terminals.
9. Regularly check the battery, charger, cables, plugs, and product components for damage. In case of damage, do not use the vehicle if not repaired.
10. The vehicle is only for one person, the weight should be under 30 kg.

SPECIFICATIONS

DC12V,500MA

Spare parts list

Assembly steps

Assemble the driving motor

1. Remove the gearbox from the seat.
2. Insert the rear axle through the hole in the body, then mount the gearbox on the rear axle on the side that is not embossed. Make sure it is mounted close to the vehicle frame.

Assemble the wheels

1. Assemble the wheels and make sure they go through the rear axle and fit into the gearbox. Use the nut to tighten and install the wheel cover.
2. Assemble another wheel. Place it on the rear axle, use the nut to secure it and install the cover.
3. Assemble the two front wheels. First place a nut on the front axle and then install the front wheel. Use the nut to secure it and assemble the cover.

Assemble the rear and steering wheel

1. Insert the rear part into the rear hole in the bodywork.
2. Place the steering wheel on the steering shaft, match the handle hole with the steering shaft hole, insert the screw into the hole, then fasten.

Connect the gearbox and battery

1. Connect the gearbox plug to the vehicle plug.
2. Connect the battery (red line to red interface, black line to black interface) Note: if not connected properly, the vehicle cannot be operated.

OPERATION

Once the driver is seated correctly, press the power switch. For forward motion, move the front/rear switch to the front and press the pedal. Release the pedal and the vehicle will come to a stop. If the front/rear switch is in the middle, the vehicle will not operate.
Notes :

1. Regularly check vehicle parts for damage.
2. Clean the vehicle frequently.
3. Fully charge the battery for 12 hours before first use.
4. Do not drive in dangerous places, or places with traffic such as roads, downhill, slopes, stairs.
5. Do not modify the circuit and do not add extra equipment that is not included in the packing.
6. Do not put it in water or in other liquids or inside another vehicle. Keep away from fire.
7. Stop the vehicle if you encounter obstacles.
8. Do not use indoors.
9. If you do not use the vehicle for a long time, turn it off and remove the battery.
10. Recharge if the speed is low.

TROUBLESHOOTING

2.  The front/rear switch is in middle gear.

The vehicle is moving slowly| 1.  It is overloaded.

2.  It needs charging.

3.  There is something stuck in the wheel.

No charging| 1.  The battery or charger is damaged.

2.  The charger is not connected correctly.

Charging instructions

1. Insert the plug into the slot before charging, then plug the charger into the socket.
2. If you use the vehicle for 1 hour, charge it after use. The charging time is 8‐12 hours.
3. Charging time should not exceed 20 hours.
4. It is normal for the charger and battery case to heat up during charging.
5. Use only the charger and battery supplied by the manufacturer.
6. Charging must be done by an adult.
7. The vehicle should be charged at least once a month, even if not used frequently.
8. When charging, do not operate the vehicle.

CAUTION BATTERY

1. Non-rechargeable batteries are not to be recharged
2. The rechargeable batteries should be charged under adult supervision
3. Do not charge the batteries while they are hot. Let them cool down first.
4. The storage battery should be kept with full power and recharged every month
5. Overcharge, lack of charge or overdischarge are forbidden to avoid damaging the storage battery.
6. Never mix different types of batteries
7. Used and empty batteries are to be removed from the item. Do not mix them with the new ones.
8. Never short-circuit the contacts. Follow the battery polarity indications.
9. Change the batteries if they do not work properly or if they have a leak.
10. If you don’t use the item for a long period then take out the batteries.
11. Never put the batteries near the fire or heat sources, nor throw them into the fire.
12. Please wash immediately if the skin or clothes touch the liquid from the battery.
13. Do not dismantle the batteries
14. Changing of batteries to be done by adults. Keep away from children.
15. In case of swallowing seek medical attention immediately!

WEEE (Waste Electrical and Electronic Equipment):
This symbol indicates that the product should not be disposed of with household waste. It must be placed at the appropriate collection point for recycling, thus conserving natural resources. Proper disposal of the product helps to prevent negative effects on the environment and human health.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>