EVERDURE HBCE4KBUS Kamado Charcoal Grill User Manual

EVERDURE HBCE4KBUS Kamado Charcoal Grill

Warning

• DO NOT OPERATE THIS APPLIANCE BEFORE READING THE INSTRUTION BOOKLET
• DO NOT PLACE ARTICLES ON OR AGAINST THIS APPLIANCE
• DO NOT STORE CHEMICALS OR FLAMMABLE MATERIALS OR SPRAY AEROSOLS NEAR THIS APPLIANCE
• DO NOT OPERATE THIS APPLIANCE INDOORS
• DO NOT LIGHT WITH HOOD CLOSED.
  • Do not load more than 2.2lb of solid fuel from cold into this appliance. Overfilling the chamber with charcoal can result in spoilt food and / or product damage.
  • This charcoal electric outdoor oven is intended for OUTDOOR USE ONLY. Do not use indoors!
  • For your safety and enjoyment, read all operating instructions before using this appliance.
  • In certain circumstances electrical appliances may be a health hazard. Unplug the appliance before cleaning or carrying out maintenance. When the appliance is not in use, unplug the appliance from the outlet and retract the power cord fully.
  • This appliance can be used by children aged from 8 years and above and persons with reduced physical, sensory or mental capabilities or lack of experience and knowledge if they have been given supervision or instruction concerning use of the appliance in a safe way and understand the hazards involved. Children should not play with the appliance. Cleaning and user maintenance shall not be performed by children without supervision.
  • Unsupervised children or pets should not be near the oven while cooking or during warm up or cool down. Ensure children or pets are kept a distance well away from the oven whilst it is in use. WARNING! Keep children and pets away.
  • Ensure that all electrical connections are secure, dry and protected from moisture before operating this appliance. DO NOT disconnect the appliance with wet hands and DO NOT disconnect the power cord with extreme force.
  • If the power cord is damaged, it must be replaced by the manufacturer, an authorised service center or qualified persons to avoid a hazard.
  • Always fully extend the retractable power cord when in use (leaving the power cord fully or partially retracted can cause the cord to overheat & become damaged). Take care not to exert undue force on the cord and its assembly when adjusting the length. If use of an extension power lead cannot be avoided, always use good quality (low resistance) leads that are suitable for the environment where cooking is taking place, and use the shortest length possible to reduce any power lost to the appliance.
  • Do not use this appliance with a programmer, timer or any other device that switches the appliance on automatically, since a fire risk exists if the appliance is covered or positioned incorrectly.
  • As charcoal can smolder for an extended period of time, take care when removing ash after cooking. It is recommended that a non-combustible container (metal or ceramic) be used to contain any ash before being doused in water and disposed of correctly.
  • This oven has been designed to be used on the base provided or built in. When on the base ensure the surface is level and strong enough to support the oven. When building in the oven the fixture must be able to withstand temperature of 175 F above ambient temperatures.
  • Cool-to-touch* statement: The 4K is built with safety in mind. Insulation material and a double walled construction will drastically reduce the radiant heat transfer to the outer body up to a maxi- mum oven temperature of 430°F with the hood closed for no longer than 2 hours. The hood and top venting area are not cool-to-touch and extreme caution should be exercised when handling this area during times of prolonged use. We always recommend wearing heat resistant gloves when cooking with the 4K. Max temperature for contact zone excluding hood and top venting is 140°F above ambient temperature
  • People with flammable clothing such as nylon etc. should keep well away from the oven when it is operating.
  • Do not use this appliance for any purpose other than what it is intended for. In case of fat fires, remove food (if possible) and allow the fire to burn out naturally. Most fat will burn off quickly when it contacts the charcoal, but regular cleaning after use should reduce the build-up of fat and food residues which are combustible and can result in a fat fire. Fat fires can be prevented with diligence in cleaning fats and oil from the heat shield and bowl around the electrical element and the inner chassis. Do not allow ash to build up inside the chassis – clean up after every use.
  • It is important that you retain these instruction, proof of purchase as well as other important documents about this product for future reference.
    Due to continual product development, Everdure by Heston Blumenthal reserves the right to alter specification or appearance without notice.

WARNING

CALIFORNIA PROPOSITION 65 WARNING:

• (а) The burning of Charcoal cooking fuel generates some by-products which are on the list of substances known by the State of California to cause cancer, reproductive harm, or other birth defects. To reduce exposure to the substances, always operate this unit according to the use and care manual, ensuring you provide good ventilation when cooking with Charcoal.
• (b) Handling the brass material on this product exposes you to lead, a chemical known to the State of California to cause cancer, reproductive harm, or other birth defects.
• (c) This product contain chemicals, including lead and compounds, known by the State of California to cause cancer, reproductive harm, or other birth defects
• (d) Wash your hands after using this product.

For more information go to: www.p65warnings.ca.gov

• Keep your oven protected against strong wind where possible. As charcoal cooking can vary in time and intensity, it is recommended that the oven not be left unat- tended for more than 5 minutes at a time while cooking

• This appliance is not suitable for mounting in a movable vehicle (boat, trailer etc.)

• Do not use or store this appliance in areas of high salt content (a marine environment) or an area with caustic fumes or liquids (such as a domestic pool), as these chemicals can cause the appliance materials to deteriorate (and void the warranty). Regular cleaning and covering with an Everdure by Heston Blumenthal charcoal electric outdoor oven cover can help to reduce this

• WARNING: Accessible parts may become hot when used. – handle with care.

• Charcoal and coal products produce carbon monoxide when burned. When the appliance is being used with solid fuels, always keep the appliance in a well ventilated area to prevent the gasses produced from building up

• Do not use solid fuels impregnated with fire accelerants or use any other type of accelerant on this appliance. This appliance is designed for electrical charcoal ignition only. Using any accelerant could cause serious property damage or personal injury.
  WARNING! Do not use spirits or petrol for lighting or re-lighting! Do not use firelighters for lighting or re-lighting!

• The ignition timer is set to 7 minutes. Whilst this in operation, the element will run, heating and igniting the charcoal above it. Once the timer has finished, do not start again as the heat from the element will interfere with the natural progression of the charcoal ashing. If the oven reaches 575°F the element will automatically stay off as to avoid overheating.

• This oven is designed to cook with lump charcoal. The heat produced and consumption time may vary dramatically depending on the type of fuel and prevailing weather conditions.

• Always allow the solid fuel to burn out naturally after cooking. Do not use any liquids to douse the charcoal. Do not move the appliance while the coals are still burning as hot ash, coal particles, unburned fuel and hot cooking fats & oils could spill and accessible parts may be very hot. The oven should not be moved by lifting. Do not use volcanic rock or any type of non-combustible product in the charcoal chamber. If in doubt on what fuels can be used, check the Everdure by Heston Blumenthal website or contact the Service Department.

• Solid fuels differ widely in burning time, heat, size and combustion. Always be aware of your surroundings and potential fire hazards caused by sparks or spitting fuels. Never dispose of solid fuels or hot ashes in areas where they can be trodden on or be a fire hazard. Never dispose of unburned solid fuels or ash until it has completely extinguished. The oven must be installed on a secure level base prior to use. We recommend using 100% natural lump charcoal in this appliance (see www.everdurebyheston.com)

• Always check with your local/state authorities before using this appliance for any fire restrictions regarding the use of an outdoor oven (due to local weather condi- tions)

• When using solid fuels, take care that the surrounding environment is clear of combustible materials. Do not cook under overhanging buildings or close branches of trees. Note that solid fuels will produce varying amounts of smoke – take this into consideration when setting up the oven.

• We recommend that you regularly maintain your oven and keep it in good condition. This can be achieved by following the cleaning and maintenance suggestions in this booklet. Failure to follow these instructions will void vour warrant.

• CAUTION: The user is cautioned that changes or modifications not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment.

• This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) this device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.

NOTE: This product has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed
to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interfer- ence will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:

• If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encour- aged to try to correct the interference by one or more of the following measures:
• Reorient or relocate the receiving antenna.
• Increase the separation between the equipment and receiver.
• Connect the equipment into an outlet on a circuit different from that to which the receiver is connected.
• Consult the dealer or an experienced radio/TV technician for help.

FCC Radiation Exposure Statement:

This equipment complies with FCC radiation exposure limits set forth for an uncontrolled environment. This equipment should be installed and operated with a minimum distance of 20cm between the radiator and your body. This transmitter must not be co-located or operating in conjunction with any other antenna or transmitter.

This appliance is rated for:

• 120V~ 60Hz
• Output 1400 W
• LENGTH (mm) 700 / (inch) 28
• WIDTH (mm) 550 / (inch) 22
• HEIGHT (mm) 1150 (on stand) / (inch) 45

Digital Touch Display

Charcoal ignition:

Power on. Press the ignition switch for 3 seconds. The switch will light up and there will an audible ‘beep’. The heating element (1400W) will run at full power for 7 mins. The oven temperature will appear and will switch between the ignition time and the oven temperature. When the ignition cycle is complete, another audible ‘beep’ will signal that the ignition is over. The light behind the ignition switch will go off. LED bar: During ignition, the LED bar will show the proportion of the elapsed ignition time. When the ignition cycle is complete, the LED bar will show the actual temperature in proportion to maximum temperature.

Probe display:

The probe toggle switch will automatically pick up the P1-P4 selection, depending on how many probes are inserted into the ports. The display will show the name of the first connected meat probe and the certain indicator lights up. The display will show the temperature of the first connected meat probe for 10 seconds. If no further operation in 10 seconds, the display will go back to the oven temperature and (and ignition time if it is in this cycle)

Timer set:

Hold the light switch for 3 seconds, the display will start to flash. Hold down either the +/- switch to set by the hour, short press for minutes. Press the light switch again to set. The display will switch between the timer set (counting down) and the oven temperature.

Switch off:

Press the on / off button for 3 seconds to switch the power off at the display.

Change temp display from Celsius to Fahrenheit:

Hold the probe selection switch for 3 seconds.

Changing the light globe

The light globe is located in the hood of the oven

1. Disconnect the oven from the power
2. Unscrew the lamp cover (anti-clockwise
3. Gently pull the globe out

Bulb Specifications:

• 10W
• 12V
• 575°F
• G4 Halogen

Error Codes

• E1: Inner hood chamber probe error
• E2: Inner hood chamber probe error
• E3: Meat probe P1 error, buzzer alarm for 1min.
• E4: Meat probe P2 error, buzzer alarm for 1min.
• E5: Meat probe P3 error, buzzer alarm for 1min.
• E6: Meat probe P4 error, buzzer alarm for min.

If you receive any of the above errors, Contact Everdure by Heston Blumenthal for service support.

Troubleshooting

Care for your 4K

CLEANING

WARNING: Ensure the 4K is completely off and unplugged before attempting to clean.
Allow the product to sufficiently cool before handling.

Outer Surface:

Painted surfaces can be cleaned using mild household detergents or cleaners and a clean cloth. It is advisable to test cleaners on a small section of the appliance first. Harsh chemicals and / or abrasive cleaners will dull the paint and remove product decals.

• DO NOT use paint thinners or similar solvents for cleaning,
• DO NOT pour cold water directly over hot surfaces.

Cooking Grills:

After cooking and whilst the oven is still warm, wipe the grills down with a damp cloth. Season the grills before and after use. We recommend vegetable/canola oil. Whilst the grills can be used in the dishwasher we do not recommend cleaning this way. All grills have a coating to stop food from sticking. After prolonged dishwasher cleaning, this surface coating can break down causing the grills to prematurely deteriorate.

Charcoal zone/firebox:

• Always wear heat resistant gloves whilst handling any hot parts!
• To clean the inner firebox, use warm soapy water and a brush.
• 100% natural lump charcoal is great for your garden and can be disposed of naturally. Coal briquettes are not natural and should be disposed off responsibly in a waste bin.
• Never throw hot ash away!

Top air vent:

This part will naturally start to go dark due to the charcoal smoke. We recommend cleaning the inside of the vent with a small chimney brush and the outside with a damp microfiber cloth

STORAGE

When the appliance is not in use, the oven can be stored outdoors but must be under cover and covered. The 4K Premium Cover (HBCACOVERL) is perfect and will protect the product from UV and rain. We recommend cleaning the product thoroughly before storing

CAUTION

Do not leave the power cord connected to the power supply for extended periods of time (disconnect after use)

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>