ABUS 97631 WINTECTO One Window Actuator Instruction Manual

ABUS 97631 WINTECTO One Window Actuator Instruction Manual

Thank you for choosing this ABUS product!

Please read these instructions carefully before assembly and use. Keep them and provide all users with instruction on how to use the product.

The product may only be used for its intended purpose. Any modification to the product is prohibited.

Keep packaging material away from children: Danger of suffocation!

Use cases and important information

WINTECTO One is a retrofit system for motor-operated locking and unlocking of inward-opening windows and patio doors with 7 mm square and a backset of at least 30 mm. The sash frame width of the window must be at least 60 mm. Operation and set-up are performed using the ABUS One app. Communication takes place via Bluetooth. In addition to the window actuator, the system consists of further optional components. To use the window actuator as intended, you need a Bluetooth®-enabled smartphone (Bluetooth® 4.0 LE and higher), a currently supported iOS or Android software version, and the free ABUS One app for iOS or Android.

In addition, WINTECTO One offers the functionality of an intrusion monitoring system. When the window is closed and the push button cylinder is pressed in, attempts to lever open the window will lead to acoustic triggering of the integrated alarm with approx. 110 dBA sound pressure. Motorised opening and closing of WINTECTO One is also possible when the cylinder is pressed in. Before installation, please check the adjustment of your window/patio door.

Make sure that the window can be operated easily and smoothly. Windows/patio doors that cannot be operated easily and smoothly shorten the battery life. The product is intended for use in dry interior rooms only. Like all technical devices, WINTECTO One can fail due to various causes. It must be possible to operate at least one main access to the object from the outside as intended. In the event of an emergency or panic situation, a malfunction or if the batteries are flat, the window/patio door can be unlocked mechanically from the inside by hand using the window handle. Keep the key for unlocking the push button cylinder within reach. The inner housing/electronics may be opened only by ABUS specialist personnel.

Before using the actuator, pull the window in from the outside. When leaving the house or flat, check that the window is properly locked. Do not pull or push on the window/patio door or hold the window handle during operation of the motor. There is danger from moving parts.

WINTECTO One can be upgraded to a security variant. Additionally purchase the corresponding retrofit kit and a bar kit to upgrade your window to make it burglar-resistant.

Contact a specialist company if necessary.

The contents of this installation and operating manual reflect the current status at the time of printing. The printed manual may be outdated at the time of the product’s entry into service due to updates and further developments. We therefore ask you to visit our website www.abus.com and enter „WINTECTO One“ into the search bar. You’ll always find the current and complete version of the installation and operating instructions on the product page under the „Downloads“ column.

Assembly

Icon explanation:

Caution!

Further fitting / using details

The instruction show the assembly on a right-hand window (R). The differences to be noted for left-hand windows are marked with the corresponding fitting steps on the diagram „left-hand window“ (L).

Dismantling existing handle

Installation of the gear box

Please note the different position of DIN right and DIN left windows! Fit base plate and square shaft at 90° to one another without tension and tighten by hand only!

Fitting the handle unit

If the „right“ and „left“ settings are reversed, this will cause a product fault!

Insert batteries

After inserting the batteries, a beep sounds.
Manually check that the window handle is functioning. The handle must turn easily. If the handle can only be turned with difficulty, the window fittings, base plate or square shaft may have to be re-adjusted
The magnet may only be mounted after programming >> 3. >>

ABUS One app

iOS

Android

• Download the ABUS One app and enable Bluetooth® on your smartphone.
• Start the app and follow the instructions in the app.
• Pay attention to the assignment of the different Keycards to the products, and always scan the correct Keycard.
• To program the window actuator, start with the button „Add new ABUS lock“.
• It is imperative to keep the ABUS Keycard in a secure place even after com- pleting the setup! The Keycard serves as proof of ownership for your window actuator. Do not give the Keycard to third parties.
• To guarantee proper function, we expressly recommend performing updates in the app and software/firmware updates for the components in a timely manner. The app will provide information on this. You can also perform the respective update in the component’s settings.

Fitting the magnet

The magnet is required to use the alarm function. WINTECTO One can also be operated without alarm function/magnet

• The magnet may only be mounted after programming the drive >> 3.

• The tilt function can be configured in the settings of the WINTECTO One in the app.

• If this setting is chosen, the window moves when pressing the „open“ button from the tilt position to the “open” position. In doing so, the window must always be brought in manually!

When using the tilting function, always pull the window by hand until the drive has reached its rest position before actuating the drive! In particular with older windows and patio doors, there is a risk that the casement will be lifted out of its anchoring, when it is not brought in manually

Be careful when using magnets!
Magnets must be kept out of reach of children. Children can put magnets in their mouths and choke. This can cause serious injury. Seek immediate medical attention in this event! Risk of trapping fingers! Magnets may damage credit or debit cards with a magnetic strip. If you have a pacemaker, defibrillator or any other implanted device, please bear the following information in mind: the magnet can have an adverse effect on devices such as these, so maintain sufficient distance between the magnet and implanted device (approx. 20 cm), particularly during installation.

*x = Rebate height

Position magnet holder and bases (Attention: do not fasten yet!)

Press in cylinder. After 2 seconds, the arming tone sounds. Mark the position of the holder

If the signal does not sound, the position was not detected. Check the position of the holder and the number of supports, or rotate the magnets by 180°!

Screw on the base(s), magnet holder mounting and screws according to the table in 4.1b at the marked position. Press down on the magnet holder

Battery replacement

After inserting the batteries, a beep sounds.

Check WINTECTO One for damage at least once a year. If the product shows visible damage, it must no longer be used.

Clean WINTECTO One only with a damp cloth, do not use aggressive cleaning agents.

FAQ

The drive cannot be programmed, there is no acknowledgement tone

drive plate on back of housing is not set correctly (go to 2.2f)

It is not possible to move to zero position (handle in closed position)

Adjust ease of operation of the door, fixing screws may be too tight loosen slightly, optimise mechanical fitting

When opening the window / patio door from its tilt position, and it falls

out of its anchoring

Deactivate tilt function or support door during motorised movement (Set the tilt function in the app)

During the motorised movement, a warning signal sounds, the drive jams and

the window handle also stops in an undefined position (overload of the drive)

Check ease of movement of the window / patio door and adjust as necessary Increase drive torque if necessary (Set the torque in the app)

A short beep sounds five times before motorised movement or when pressing

in the pressure cylinder

“Low batt” message, replace all batteries with new alkaline batteries or fully charged “ready-to-use” batteries (go to Battery replacement)

When the cylinder is pushed in, and there is no acknowledgement tone after

2 seconds

The window handle is not in closed position Check the magnet position

The handle cannot be operated mechanically

Cylinder pushed in, unlock with key

Technical data

Battery instructions

This product contains six batteries AA 1,5 V alkaline LR6. Keep batteries out of the reach of children. Children may put batteries in their mouths and swallow them. This can cause serious harm to their health. Seek immediate medical attention in this event! Batteries must be inserted with the correct polarity (+ and -). Empty batteries must be removed or replaced immediately. Different battery types, or new and used batteries, must not be mixed. The battery terminals must not be short-circuited. Risk of burns from contact with leaking or damaged batteries! In these cases, use suitable protective gloves and clean the battery compartment with a dry cloth. Batteries must not be dismantled, punctured, damaged, short-circuited, heated, charged or thrown into an open fire (risk of explosion!). Do not use or store the product in areas where the temperature could reach below 0°C or above +40°C. Do not expose the productv to direct sunlight

Declaration of Conformity

Hereby, ABUS August Bremicker Söhne KG declares that the radio equipment type WINTECTO One is in compliance with Directives 2014/53/EU and 2011/65/EU. The full text of the EU declaration of conformity is available at the following internet address: docs.abus.com

Licence texts

The Bluetooth® word mark and logos are registered trademarks owned by Bluetooth SIG, Inc. and any use of such marks by ABUS August Bremicker Söhne KG is under license. Other trademarks and brand names are those of their respective owners. Apple and the Apple logo are trademarks of Apple Inc., registered in the U.S. and other countries and regions. App Store is a service mark of Apple Inc.
Google Play and the Google Play logo are trademarks of Google LLC.

Disposal

It is your responsibility to delete all stored personal data prior to disposal of the product. This product contains valuable raw materials. At the end of its service life, dispose of the product in accordance with the applicable legal requirements. Electrical appliances, rechargeable batteries and batteries must not be disposed of with household waste. Disposal must be carried out in accordance with Directive 2012/19/EU on waste electrical and electronic equipment (WEEE), or Directive 2006/66/EC on batteries and accumulators and waste batteries and accumulators. Batteries must be removed from electrical appliances and disposed of separately before disposal. Dispose of the packaging according to type. Separate the cardboard, foil and plastic elements for recycling. Please contact the local authority responsible for disposal if you have any queries.You can obtain information on collection points for your old appliances, for example, from the local municipal or city administration, the local waste disposal companies, or your specialist dealer.

Warranty

ABUS products are designed, manufactured and tested in accordance with applicable regulations with great care. The warranty exclusively covers faults that are caused by material or manufacturing defects. If a material or manufacturing defect can be proven, the product will be repaired or replaced at the discretion of the warrantor. In such cases, the warranty ends with the termination of the original warranty period. Any further claims are expressly excluded. ABUS assumes no liability for defects or damage that has been caused by external influences (e.g. transport, external forces), improper use, normal wear and tear or non-compliance with this operating and installation instructions document. If a warranty claim is asserted, the product must be returned with the original receipt with date of purchase and a brief written description of the fault.

Subject to technical alterations. No liability for mistakes and printing errors.

© ABUS 2023
ABUS August Bremicker Söhne KG | D 58292 Wetter | Germany.
Tel.: +49 (0) 23 35 63 40 | www.abus.com | info@abus.de

UK-Importer: ABUS (UK) Ltd.
Unit 30, Portishead Bus. Park Old Mill Road, Portishead BS20 7BX, BRISTOL, UK
Tel.: +44 117 204 70 00 | www.abus.com | info @abus-uk.com

References

• CE Certificates | Declaration of Conformity | ABUS
• UK.COM
• ABUS - Security technology since 1924

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>