oursson AG5002D Air Grill Instruction Manual

AG5002D Air Grill

Instruction Manual

 AG5002D Air Grill

SAFETY INSTRUCTIONS, Рiс. А

Danger symbol
A reminder to user about high voltage.

Warning symbol
A reminder to user about the necessity of operating exactly according to the instructions.

When using electrical appliances should take the following precautions:

• Use the device according to the following instructions manual.

• Install the device on a stable surface.

• Use only the tools, which are included in the product set.

• **** To protect against risk of electrical shock do not put the cord in water or other liquid. If for some reason the water got into the unit, contact an authorized service center (ASC) OURSSON AG.

• For power supply, use a power grid with proper characteristics.

• Do not use the device in areas where the air can contain vapors of flammable substances.

• **** Never attempt to open the device by yourself – it could possibly be the reason of an electrical shock can lead to product malfunction and will invalidate the manufacturer’s warranty. For repair and maintenance, contact only authorized service centers meant for repair of products under the trademark OURSSON.

• When moved from a cool to a warm place and vice versa unpack it before use and wait 1-2 hours without turning it on.

• **** In order to prevent electrical shock do not immerse the entire product or the wires into the water.

• Be particularly careful and cautious when using the device near children.

• Do not touch any hot parts, as this may cause injury.

• The power cord is specially made relatively short in order to avoid the risk of injury.

• Do not allow the cord to hang over the sharp edge of the table or touch hot surfaces.

• Do not connect this device to a grid which is overloaded with other appliances: it can lead to the fact that the device will not function properly.

• Do not install the device near gas and electric stoves and ovens.

• After use, make sure to disconnect the device from the power grid.

• Keep the device from bumps, falls, vibration and other mechanical influences.

• Make sure to disconnect the device from the power grid before cleaning or changing accessories.

• Do not use the device outdoors.

• This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge.
  They can only use the device under the supervision of the person responsible for their safety, or after instruction on the safe use of the device. Do not allow children to play with the product.

• This product is intended only for use in the home.

• If the power cord is damaged, it must be replaced by a specialist from the authorized service center (ASC) OURSSON AG to avoid danger.

Risk of burn symbol
Reminder for user of high temperatures.

• Use only the tools, which are included in the product set.
• When cleaning the appliance do not use abrasives and organic cleaners (alcohol, gasoline, etc.). When cleaning the device it is allowed to use a small amount of neutral detergent.

Recommendations

• Please read the instruction manual before using the device. Keep the manual after reading for further use.
• All illustrations in this manual are schematic representations of real objects, which may differ from the actual images.
• Do not move the device during operation.
• Use the device only for cooking and reheating food.
• Do not leave operating device unattended.
• Do not place paper, cardboard, plastic, towels, etc. on the device, as it may cause a fire.
• During cooking, hot air and steam escape from the ventilation openings, be careful not to burn yourself.
• Use potholders or mittens to remove food from the device
• If the food caught on fire or became Smokey during cooking, turn off the device and unplug it.
  Do not remove the bowl until the flame stops, as the supply of oxygen will intensify the flame.

The operation of this device in any case does not imply application of any force to it, as this may damage the product due to user fault.

SETTING, Рiс. A-2

• Place the device on a horizontal, flat surface at a height not reachable by children, leaving free distance around the device.
  One side should be completely free.
  This device must not be built-in.

• Do not place the device under/near curtains or other flammable materials, as this may result in a fire.

• Plug in the device to a power outlet that is grounded, Pic. A-1.

PRODUCT SET, Рiс. В

1 Device ……………………………………………………….. 1 pc.
2 Cooking bowl …………………………………………….. 1 pc.
3 Grill……………………………………………………………. 1 pc.
Instructions manual …………………………………………. 1 pc.
Warranty card …………………………………………………. 1 pc.

ELEMENTS OF DESIGN, Рiс. С

1. Touch control panel
2. Grill’s legs
3. Cooking bowl’s handle
4. Rear vent
5. Top vent

Utilization

Control panel, Рiс. С-1

| Temperature adjustment from 80°C up to 200°C. Holding the button will change the temperature faster.
---|---
| Start/Pause: press the button to start or pause the cooking program.
| ON/OFF button
| Menu button (select cooking program)
| Adjust the cooking time from 0 to 60 minutes. Holding the button will change the cooking time faster.
| heating indication
| ventilation indication
| cooking temperature indication
| indication of cooking time in minutes
| French fries program
| Fish cooking program
| Baking program
| Seafood cooking program
| Steak cooking program
| Cooking program for poultry meat (chicken drumsticks)
| Cooking program for Egg tart
| Cooking program for Sweet potato
| Cooking program for poultry meat (chicken wings)
| Cooking program for vegetables and mushrooms

Preparation for operation
Before first use, wipe the body of the device with a soft, dry cloth. Wash other parts 2 and 3 with warm water and dishwashing liquid. Thoroughly dry all parts. Before assembling or disassembling the device, make sure that the device is unplugged.
Turn on the empty device for 5-10 minutes, setting the maximum temperature to 200 ° C to remove odors of the new device. Ventilate the room. Allow the device to cool.
Order of operation, Рiс.D

1. Plug in the device.

2. Make sure that the bowl with the grill are in the device, Pic. D-3.

3. Press the button, to turn on the device.

4. Press the button and select the program to heat the device before use. With the help of buttons lower the time to 3-5 minutes. Press the button to start the program. After the set time, the program will automatically shut down.

5. Remove the cooking bowl from the device. Place the grill inside the bowl, after bending the legs of the grill, Pic. D-1.
   **** Do not use the bowl without the grill. Put the ingredients in the grill.

6. Place the ingredients into the grill.
   The number of products should not exceed ~ 3/4 of the useful volume of the bowl.
   Do not pour oil or other liquids into the working bowl.

7. Set the bowl into the device, Pic. D-3.

8. Press the button to select the cooking program. When selecting the program, the cooking time and temperature will be displayed. If necessary, change the cooking time and cooking temperature with the help of and buttons.
   NotE: During cooking, the heating indicators and ventilation indicators light up periodically.

9. At the end of cooking, the program will turn off automatically and a beep will sound. To turn off the program manually, press and hold button for a few seconds. Gently, holding the handle, remove the bowl from the device and place it on a heat-resistant surface, Pic. D-6. Use large kitchen tongs to get large pieces of food.
   Do not touch the bowl during or immediately after preparation to avoid burns. Hold the bowl by the handle.
   Beware of hot steam and air when removing the cooking bowl from the device.

NotEs:

• Carefully handle the cooking bowl and grill; they have a non-stick coating. Any damage may result in malfunction.
  For an even frying, some products need to be turned and shaken during cooking. To do this, it is recommended to set the timer to half the cooking time, you will hear the timer ring, shake or turn the products over. Then set the timer for the remaining cooking time. Or press pause during cooking to flip the food.

• Depending on the quantity of the products, you can increase or decrease the cooking time.

Cooking recommendations

• It is recommended to cut the same sized pieces of meat, poultry and vegetables for cooking, so that they are evenly and equally fried.
  When preparing breaded products, it is recommended that you add a little oil to the breading to get a crisp.

• If the product contains a lot of fat or oil, the crust will be less crispy. It is recommended to remove excesses of fat from the cooking bowl with a paper towel during the cooking process.

• Small baked goods (such as muffins) can be cooked on parchment paper. The paper size should be small so that there is enough space for hot air to circulate. Parchment paper/foil should only be placed in a grill, and should not be placed on the cooking bowl.

• The device can be used to heat food, for this, select a temperature of 100-150°C, and set the timer for 10 minutes.
  Before cooking it is recommended to wash the ingredients, cut them and marinade if necessary. The cooking time and weight in the table are advisory in nature and may vary depending on the original quality and freshness of the products and on the recipe and personal preferences.

cooking.
Pork chop (100-500g)| 180°C| 10-15 min| Marinate before cooking. Turn over while cooking.
Hotdog (100-500g)| 200°C| 12-15 min| Ready dough is cooked faster than homemade.
Hamburger (100-500g)| 180°C| 7-14 min|
Chicken Drumstick (100500g)
Chicken Breast (100-500g)| 200°C
180°C| 16-25 min
10-15 min| Marinate before cooking. Turn over while cooking.
Rub with salt, spices, herbs.
Thin frozen potatoes (300700g)| 200°C| 12-16 min| The optimal amount is 300g. Shake while cooking.
Thick frozen potatoes (300700g)| 200°C| 12-20 min| Shake while cooking.
Potato casserole (500g)| 200°C| 20-25 min|
Homemade Potato Slices (300-700g)| 180°C| 18-25 min| Rub the slices slightly with oil (1/2 tbsp.). Shake while cooking.
Stuffed Pancakes (100-500g)| 200°C| 8-10 min| Turn over while cooking.
Frozen Chicken Nuggets (100-500g)| 200°C| 6-10 min| Turn over while cooking.
Frozen Fish Sticks (100-400g)| 200°C| 6-10 min|
Stuffed Vegetables (100400g)| 160°C| 10-18 min|
Pie (— 300g)| 160°C| 20-25 min| Use baking utensils. Install it on the grill.
Cupcakes/Muffins (300g)| 190°C| 10-18 min Use baking paper or baking dishes.
Install it on the grill.| Use baking paper or baking dishes. Install it on the grill.
Sweet snacks (400g)| 160°C| 18-20 min| Use baking utensils. Install it on the grill.

DisPospal

• Before discarding the old device, for safety reasons cut off the electric wire to prevent further use.

CLEANING AND MAINTENANCE, Рiс. E

• Clean all the parts of the device immediately after use.
• After cooking very fatty foods, it is recommended to immediately clean the grill and bowl. Use mittens or heat-resistant gloves. Drain any remaining oil/fat from the bowl, blot the grill and the inside of the bowl. If the fat cools, it will thicken and it will be harder to wash out.
• Unplug the device.
• **** Let the device cool for 30 min. before beginning to clean it.
• Wash the grill, the cooking bowl in warm, soapy water. The grill 3 can be washed in the dishwasher. The temperature in the dishwasher should not exceed 60° C.
• Wipe the body of the device and the inside (except for heating elements) with a damp and soft cloth.
• If dirt adheres to the bowl/grill, fill it with hot water and detergent. Place the grill in the bowl and leave them for about 10 minutes
• **** Never immerse the device in water due to the danger of electric shock.
• Thoroughly dry all the parts of the device.

Possible Problems AND solutions

wait until the voltage recovers.
The dish is not cooked| 1.Too many products placed in the grill.
2.Low cooking temperature is set.
3.Short cooking time is set.| 1.Reduce the volume of the prepared portion. Smaller portions are fried better.
2.Set a higher temperature.
3.Set the required cooking time or add a few additional minutes.
Products are fried unevenly.| Some types of food must be shaken during cooking.| Shake the food after half the cooking time.
The finished product isn’t crispy.| The selected type of product is designed for cooking in conventional deep fryer.| Use the product for deep-fried cooking or lightly oil the ingredients to get the crisp.
The cooking bowl is not installing in the device.| Too many products are placed in the grill inside the cooking bowl.| Reduce the quantity of products.
White smoke comes out of the device.| Cooking foods are too greasy.| During cooking, excess fat/oil drains into the bowl. Burning oil gives off white smoke. Do not use the device to cook too fatty foods or remove excess fat during cooking.
Fresh fries are fried unevenly.| Potato slices were not soaked before frying.| Soak potato slices in water for 30 minutes and then dry them with a napkin and rub them with oil.

Product certification

For information on product certification, see http://www.oursson.com or ask seller for a copy.

Specifications|
---|---
Model| AG5002D
Power consumption, W| Max  1400
Rated voltage| 220-240 V ~; 50 / 60Hz
Bowl volume, l| 5
Storing and transportation temperature| from -25°C up to +35°C
Operation temperature| from +5°C up to +35°C
Humidity Requirements for transportation, storing and operation| 15-70% (no condensation)
Protection class| I
Dimensions, mm (HxWxD)| 250x305x295
Weight, kg| 3,33

Products must be stored in dry, ventilated warehouses at a temperature not lower than -25° C.
**** Only a qualified specialist of an authorized service center OURSSON AG can repair the device

servicing

Company OURSSON AG expresses great appreciation to you for choosing our products. We have done everything possible so that this meets your needs, and the quality corresponds to the best world standards. If your OURSSON branded product will need maintenance, please contact one of the authorized service center (hereinafter – ASC). A complete list of ASC and their exact addresses can be found on the website www.oursson.com.
Warranty obligations OURSSON AG:

1. Warranty obligations OURSSON AG, provided ASC OURSSON AG, apply only to models designed OURSSON AG for the production or supply and sale within the country where the warranty service is provided, purchased in this country, certified for compliance with the standards of this country, and also marked the with official marks of conformity.

2. Warranty obligations OURSSON AG operate within the law on protection of consumer rights and are regulated by the laws of the country in which they are provided, and only when the product is used exclusively for personal, family or household purposes. Warranty obligations OURSSON AG shall not apply to uses of goods for business purposes or in connection with the acquisition of goods to meet the needs of enterprises, institutions and organizations.

3. OURSSON AG sets for its products the following terms of use and warranty periods:
   Product name| Terms of use, months| Warranty Period, months
   ---|---|---
   Microwave ovens
   beadmakers, induction hobs Multicookers, kitchen processors, electric kettles, electric grills, hand blenders, hand mixers, meat grinders, blenders, toasters, airports, toasters, juicers, steamers, coffee makers, choppers, freezers, refrigerators, automatic coffee machines, milk frothier Kitchen scales| 60| 24

4. Warranty obligations OURSSON AG shall not apply to the following products, if their replacement is assumed and is not connected with disassembling products:
   • Batteries.
   • Cases, straps, cords for carrying, mounting accessories, tools, documentation that came with the product.

5. Warranty does not cover defects caused due to violations of the rules of consumer use, storage or transportation of the goods, actions of third parties or force majeure, in- cluding but not limited to the following cases:
   • If the defect was a result of careless handling, used for other purposes, violations of conditions and rules of operation set forth in the instruction manual, including  as a result of exposure to high or low temperatures, high humidity or dust, traces of opening the device independently and/ or self- repair, mismatch state standards for power grids, getting liquids, insects or other foreign objects, substances inside the device, as well as long-term use of the product in extreme operational modes.
   • If the defect of the product was a result of unauthorized attempts to test the product or make any changes in its construction or software programs, including repair or maintenance in unauthorized service centers.
   • If the defect of the product was a result of use of non-standard and/or low quality equipment, accessories, spare parts, batteries.
   • If the defect of the product is associated with its use in conjunction with additional equipment (accessories), other than additional equipment recommended by OURSSON AG for use with this product. OURSSON AG is not responsible for the quality of the additional equipment (accessories) manufactured by third parties, for the quality of its products together with such equipment, as well as the quality of the work of the additional equipment of OURSSON AG together with the products of other manufacturers.

6.  Product defects detected during the lifetime of the product are eliminated by the authorized service centers (ASC). During the warranty period, elimination of defects is free of charge with the presentation of the original certificate of guarantee and documents that confirm the fact and date of the contract of retail purchase. In the absence of such documents, warranty period is calculated from the date of manufacture of goods. It should be taken into account:
   • Setup and Installation (assembly, the connection, etc.) of the product described in the documentation attached to it, does not enter the scope of warranty OURSSON AG and can be performed by the user as well as the specialists of most authorized service
   centers on a paid basis.
   • Work upon maintenance of products (cleaning and lubricating the moving parts, replacement of consumables and supplies, etc.) are made on a paid basis.’

7. OURSSON AG is not responsible for any damage directly or indirectlycaused by their products to people, pets, property, if it occurred as a result ofnon-observance of the rules and conditions of use, storage, transportation or installation of the product, intentional or negligent actions of consumer or third parties.

8. Under no circumstances, OURSSON AG is not responsible for any special, incidental, indirect or consequential loss or damage, including but not limited to: lost profits, damages caused by interruptions in the commercial, industrial or other activities, arising from he use of or inability to use the product.

9. Due to continuous product improvement, design elements and some technical specifications are subject to change without prior notice from the manufacturer.

Using the product when after the terms of use (lifetime):

1. Lifetime set by OURSSON AG for this product applies only when the product is used exclusively for personal, family or household needs, as well as the consumer observes the correct operation, storage and transportation of products. Under thecondition of careful handling of the product and compliance with the rules of operation the actual life may exceed the lifetime set by OURSSON AG.

2.  At the end of the product lifetime, you should contact an authorized service center for to conduct a preventive maintenance of the product and determine the suitabilityfor further use. Work on conducting a preventive maintenance of the products is also
   made in service centers on paid basis.

3. OURSSON AG does not recommend the use of this product after the end of its lifetime without its preventive maintenance by the authorized service center, since inthis case, the product can be dangerous to the life, health or property of the consumer.

Product Recycling and Disposal
This appliance has been identified in accordance with the European directive 2002/96/EG on Waste Electrical and Electronic Equipment – WEEE.
After the expiration of the lifetime, the product cannot be disposed with another household waste. Instead, it shall be deposited in the appropriate recycling collection point for electrical and electronic equipment for proper treatment and disposal in accordance with federal or local law. By disposing correctly this product, you will help to conserve natural resources and preventing the product from damaging the environment and human health. For more information on the collection point and recycling of this product, please contact your local municipal authorities or the enterprise for household waste disposal.
Date of manufacture
Each product has a unique serial number in the form of alphanumeric row and is duplicated with a barcode that contains the following information: name of the product group, date of manufacture, serial number of the product. Serial number is located on the rear of the product, on the package and the warranty card.

1. The first two letters-correspondence to the product group (Air grill – AG).
2. The first two digits – year of manufacture.
3. The second two digits – month of manufacture.
4. The last two digits – serial number of product.

**** To avoid misunderstandings, we highly recommend you to read carefully the instruction  manual and the warranty obligations. Check the correctness of the warranty card. Warranty card is valid only if the following are correctly and clearly stated: model, serial  number, date of purchase, clear stamps, buyer’s signature. The serial number and the model of the device must be  the same as in the warranty  card. If these conditions  are not fulfilled or  the data specified in the warranty card was changed,  the warranty card is invalid.
If you have questions or problems with OURSSON AG products – please contact us by e-mail: support@oursson.com
This manual is under protection of international and EU copyright law. Any unauthorized use of the instructions, including copying, printing and distribution, but not limited to, involves the application of the guilty person to civil liability and criminal liability.
Contact information:

1. Manufacturer of goods – OURSSON AG (Orson AG), Rue du Grand-Chêne 5, 1003 Lausanne, Switzerland.
2. Certification information product available on the website www.oursson.com.

OURSSON AG
Made in China

www.oursson.com

References

• OURSSON / Oursson
• OURSSON / Oursson

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>