TERRAKING 45-0584 25 Gallon Spot Sprayer User Manual
- June 9, 2024
- TERRAKING
Table of Contents
25 Gallon Spot Sprayer User Manual
45-0584
45-0584 25 Gallon Spot Sprayer
| REFNO. | PART NO. | QTY | DESCRIPTION |
|---|
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30| ST43652
ST43175
ST44017
ST43176
ST43182
ST43183
ST43191
ST43235
ST43673
ST43258
2-334
2-345
ST43287
ST43918
ST43516
2-467
ST43684
ST62009
ST65000
ST65001
ST65007
ST43472
ST43483
2-318
2-321
ST43014
ST43844
ST43124
ST43515
ST43514
ST43921
ST44031
ST50749*
3-70
ST43490
ST43488| 06
01
01
04
01
01
01
01
01
01
01
01
01
01
01
01
01
02
02
04
04
01
01
01
01
01
02
01
01
01
01
01
01
01
01
01| HOSE CLAMP 3/8″ – 1/2″
TANK FILL CAP
LANYARD FOR TANK FILL CAP
RUBBER BUMPER
SUMP FITTING 3/8″ BARB
ELBOW 3/8″ MP – 3/8″ BARB
HOSE HOLDER 3/8″
TEE 3/8″ BARB – 3/8″ BARB – 3/8″ MP
SPRAY WAND WITH BRASS TIP
SUMP STRAINER 3/8″
HOSE, 3/8″ X 19.5″
HOSE, 3/8″ X 228″
SPRAY WAND HOLDER, LARGE
PUMP 12V, 100PSI, 2.2GPM
DRAIN CAP
25 GALLON TANK, WHITE
WASHER FOR DRAIN CAP
BOTTOM BRACE
SCREW, 10-24 X 3/8″ TRUSS HEAD
SCREW, 10-24 X 1″ TRUSS HEAD
BOLT, FLANGE 5/16-18 X 3/4 GR5
WIRE HARNESS, SWITCH
WIRE HARNESS, BATTERY
HOSE, 3/8″ X 12″
HOSE, 3/8″ X 6.5″
INLINE VALVE 3/8″ BARB
GROMMET 5/8 ID, 1-1/8 OD
SPRAY WAND VALVE
SPRAY WAND EXTENSION
SPRAY WAND BRASS TIP
PUMP HEAD (NOT SHOWN)
PUMP PRESSURE SWITCH (NOT SHOWN)
15A ATO / ATC Fuse (NOT SHOWN)
LABEL, TERRA-KING (NOT SHOWN)
LABEL, 25 (NOT SHOWN)
LABEL, WARNING – CHEMICAL HAZARDS (NOT SHOWN)
SAFETY
- Read this owners manual and the vehicle owners manual before using this sprayer.
- Never allow children to operate this sprayer.
- Do not allow anyone to ride on or sit on this sprayer.
- Keep the area clear of all persons, especially small children.
- Read the chemical label before handling or mixing chemicals.
- Wear eye and hand protection and protective clothing when handling and applying lawn chemicals.
- Do not spray on windy days.
- Be aware of your vehicle’s capabilities. Attaching this sprayer may affect your vehicle’s braking and stability.
- STAY OFF STEEP SLOPES. Refer to the vehicle owner’s manual concerning safe operation on slopes.
- Operate at reduced speed on rough terrain, along ditches and on hillsides to prevent loss of control.
INSTALLATION
- Install sprayer on vehicle and secure to vehicle.
- Connect ring terminals on battery harness to vehicle 12V battery.
- Connect switch harness to the battery harness and route to sprayer
- Connect switch harness to the pump.
OPERATION
CAUTION: Connect to a 12 V battery only.
PUMP PRESSURE SWITCH
The pump pressure switch turns off the pump when it reaches its maximum
pressure setting. Very low flow demand may cause the switch to rapidly cycle
the pump on and off. Rapid on and off cycling must be limited to no more than
6 times per minute. Cycling could cause the motor to heat beyond the
recommended maximum temperature and reduce the operational life of the pump
and pressure switch.
USING THE SPRAYER
- Turn inline switch to ‘on’ position.
- Squeeze handle on spray wand.
- Turn inline switch to ‘off’ position when finished.
ADJUSTABLE SPRAY WAND NOZZLE
Twisting the nozzle will adjust the spray pattern from a cone shaped mist to a
solid stream.
SPRAYER RECIRCULATION
- The sprayer is equipped with a recirculation valve to aid in material agitation and pressure control.
- This valve is in the “open” position when the valve handle is in line with the hose, “closed” when perpendicular to the hose.
- Adjusting the recirculation valve between the open/closed positions will affect the pressure coming through the spray wand.
- Closed position is full pressure through spray wand.
- It may be helpful to adjust the pressure when spraying with the spray wand to avoid damage to plants from excess pressure.
MAINTENANCE
AFTER EACH USE
- Fill the sprayer part way with water and pump the water out through the spray wand. Use the spray wand to wash the inside of the tank.
- Refill the tank about half full with water and a chemical neutralizer solution and repeat the cleaning instructions above. Follow the manufacturers instructions for disposal of all chemicals.
AS NEEDED
- Periodically clean the tank strainer on the end of the intake hose.
Remove the nylon swivel nut from the hose, pull out the screen and flush it with water.
WINTER STORAGE
- Drain all water out of the sprayer, especially the pump and spray wand. These items are prone to damage from freezing temperatures.
- Winterize the sprayer by pumping a 50-50 solution of water and R. V. antifreeze through the spray wand.
Speedepart the fastest way to purchase parts www.speedepart.com
REPAIR PARTS
Agri-Fab, Inc.
809 South Hamilton
Sullivan, IL. 61951
800-448-9282
www.agri-fab.com
This document (or manual) is protected under the U.S. Copyright Laws and the copyright laws of foreign countries, pursuant to the Universal Copyright Convention and the Berne convention. No part of this document may be reproduced or transmitted in any form or by any means, electronic or mechanical, including photocopying or recording, or by any information storage or retrieval system, without the express written permission of Agri-Fab, Inc. Unauthorized uses and/or reproductions of this manual will subject such unauthorized user to civil and criminal penalties as provided by the United States Copyright Laws.
References
Read User Manual Online (PDF format)
Read User Manual Online (PDF format) >>