AMEWI K970-200 Kabolite Metal Forward Shovel Hydraulic RTR Excavator Instruction Manual

: June 9, 2024
: AMEWi

K970-200 Kabolite Metal Forward Shovel Hydraulic RTR Excavator
Instruction Manual

K970-200 Kabolite Metal Forward Shovel Hydraulic RTR Excavator

Welcome to AMEWI
The Amewi Trade GmbH is an international import- and wholesale company for R/C models, toys and creative items, located in Borchen near Paderborn, Germany. Our product range includes over 10,000 items. Above all, this includes remote- controlled car, helicopter, boat, and tank models as well as a wide range of accessories and all necessary spare parts. Our sales network includes over 700 specialist dealer and online retailers across Europe.
The company AMEWI Trade GmbH is a pure wholesale company. We only sell our products to retailers. When you purchase AMEWI products as an end consumer, you are entering into a contract with the retailer. Please always contact your dealer in warranty cases.
AMEWI Trade GmbH
Nikolaus-Otto-Str. 18
33178 Borchen
Servicezeiten: Dienstag 9:30 – 12:00 Uhr | Donnerstag 14:00 – 16:30 Uhr Telefon: +49 180 5009821 (Festnetz 14Ct/Min., Mobil max. 42Ct/Min.)
Support: https://amewi.com

MAXIMUM TRANSMITTING POWER DATA

Operation Frequency	2402, 2440, 2480 MHz

Maximum Radio Frequency power:
Maximum peak power:| 20dBm

DECLARATION OF CONFORMITY

This product has been manufactured according to actual technical standards. The product is matching the requirements of the existing European and national guidelines. The Declaration of Conformity has been proofed. AMEWI Trade e.K. declares that this product is matching the basic requirements and remaining regulations of the guideline 2014/53/EU (RED). The declarations and documents are stored at the manufacturer and can be requested and applied there. https://amewi.com/Konformitaetserklaerungen
For additional questions to the product and conformity please contact:
**** Amewi Trade GmbH Nikolaus-Otto-Str. 18, 33178 Borchen Germany or website https://amewi.com.
For damage, caused by disregarding of the manual, warranty expires.
We are not liable for secondary failures, material, or personal damage, caused by in proper usage or disregarding the security notices.
Based on security and registration {CE) reasons, it is forbidden to modify the product personally. Do not disassemble the product.
Small parts. Danger of suffocation or risk of injury caused by small parts.
Suitable for people aged 14+!
The product is not allowed to get moist or wet. The product is only allowed to be used on flat and clean surfaces. Even a drop down from a small height can cause damage to the product.

BATTERY NOTICE & DISPOSAL

Attention! Battery do not belong in the hands of children. A change of the battery must be done by an adult person.
Never mix rechargeable batteries with non-rechargeable batteries. Never mix fully charged batteries with almost empty batteries. Never mix batteries of different capacities. Never try to charge dry batteries. Take care of the correct polarity. Defective batteries belong to special waste. Never leave a charging battery unattended. For questions about the charging time please read the manual or ask the manufacturer.
Read the safety instructions and warnings before using or charging the Li-Ion battery.
Stop using or charging it immediately if it leaks, has a temperature above 70° C or anything else unusual occurs.
Use only a qualified and specific Li-Po/Li-Ion charger. Never charge the battery unattended. Do not charge the battery if the charge exceeds 4.2 V / cell. Do not charge the battery with a charging current above 2C. Please check and ensure that you are using a qualified charger. An unqualified charger may cause a fire.
Do not discharge the battery with a current exceeding the maximum discharge current. Otherwise, this will cause the battery to overheat. This may result in bursting, fire or explosion.
Never disassemble, puncture, knock, drop, short circuit and/or throw the battery into a fire.
Improper use such as short-circuiting, or overcharging may result in explosion or fire.
Keep the battery in a safe place that babies or children cannot reach.
The above indicates the danger of using the battery. The user assumes full responsibility for the outcome of using the battery.

DISPOSAL

**** AMEWI is registered below the Bat-Reg.-No. DE 77735153 and WEEE-Reg.-No. 93834722 at the foundation EAR and recycles all used electronic parts properly. Electric and electronical products are not allowed to put in household garbage. Please dispose the product at the end of the lifetime according to the actual laws. You as a customer are responsible by law for the return of all used batteries, a disposal over the household garbage is forbidden!
Batteries containing hazardous substances are marked with the alongside symbols, which point to the prohibition of disposal in household garbage.
Additional notations for the critical heavy metal are Cd=Cadmium, Hg=Quicksilver, Pb=lead {Label is placed on the batteries, for example below the bottom left trash symbols).
Based on RoHS labelling the manufacturer confirms, that all limit values were taken care of at the time of manufacturing.
Batteries labelled with the recycling symbol can be put into used battery collecting tank. (Most supermarkets have)
They are not allowed to be put into local household garbage.
AMEWI Trade GmbH is involved in the dual system for boxing over the company Landbell AG.
All used boxes are collected from partner companies (waste disposal contractor) at private customers (local household), sorted and properly utilized. The involvement in a Dual Systems helps to save C02 Emissions.

THANK YOU
Thank you for purchasing the K970-200 Excavator. Please read the instruction manual carefully and keep it for future reference.
WARNING

This remote-controlled plane is not a toy. It consists of many small parts and is not suitable for children under 14 years.
The remote control has a built-in 3,7V 1S 4300mAh LiPo.
A 11,1V 3S 15000 Li-Ion battery is used for the car (included).
Always keep your fingers away from the drive parts and other moving parts to avoid injury.
The model’s motor gets very hot. To avoid burn injuries, allow the motor to cool for 10-15 minutes after use before touching it.

ON INAPPROPRIATE USE OF THE PRODUCT
Please do not disassemble or modify the model in any way.
Please do not use this product improperly or illegally and do not operate it in a manner that could endanger others or yourself.
IMPORTANT NOTICE
Note: This product is manufactured according to strict performance guidelines and complies with safety standards and requirements. This product is not suitable for children under 14 years of age. The manufacturer is not liable for any injury or accident caused using abnormal parts, excessive wear and tear, improper assembly, or operation. Please operate this product safely and responsibly.
PRECAUTIONS
Please read the following safety information before using the model.

Please do not use the model in rain, snow, or thunderstorms. If liquid enters the electronics, they may be irreparably damaged.
Please do not use the model in an environment that you cannot see.
Signal interference can cause the model to go out of control. Please do not use the model in the following places:

| | |
---|---|---|---
Near a radio tower, mobile phone masts or other places with active radio waves.| Near crowds or in public places.| Near rivers, ponds or lakes.| Near electricity pylons or other transmission towers.

Please do not operate the model if you are tired or unwell, have drunk alcohol or taken drugs – this may cause injury to yourself or others.
To avoid burns, never touch drive parts and motors during or immediately after use as they can be very hot.
Incorrect operation of the transmitter can cause injury to you or others. Be sure to familiarize yourself with the operation before using the model.
Check the model and the remote control before use. Check screws to make sure they are tight.
When you have finished using the model, always switch off the model first and then the remote control. Otherwise, the model may get out of control.
If the model gets out of range, it may get out of control. Please always stay close to the model with the transmitter.

THE REMOTE CONTROL

CHANNEL DEFINITION

Channel number| Control definition| Control| Fine-Tuning| Control form| Boot Position
---|---|---|---|---|---
CH1| Platform rotation| J4| TR7| Stick| Middle position
CH2| Boom| J2| TR4| Stick| Middle position
CH3| forearm| J3| TR3| Stick| Middle position
CH4| Bucket| 11| TR8| Stick| Middle position
CH5| Left Track| VRD| TR1| | Middle position
CH6| Right Track| VRD| TR2| | Middle position
CH7| Hydraulic Pump| SWF| | Switch| Up
CH8| Lights| SWH| | Switch| Up
CH10| Sound mixing| | | |
CH12| close| SWL/KTR6| | Switch|
CH13| Sound Module| SWB| | Button| Middle position
CH14| Volume| VRA| | Knob| Normal
CH15| Smoke generator| VRB| | Knob| Normal
CH17| Warning Light| Beacon| | Switch|

THE EXCAVATOR

FILLING HYDRAULIC OIL

Unscrew the fuel tank cap and pull out the air breather plug.
Fill #46 hydraulic oil into the tank, screw on the cover, and reinstall the air breather.
Make sure you have added enough oil.
Pay attention to the oil level: Check the sight glass and make sure hydraulic oil fills the circle by half.
WARNING
If you spill hydraulic oil into your eyes, rinse them immediately and seek medical attention.

REMOTE CONTROL CHARGING

To charge the battery of the remote control, remove the dust cover on the charging socket. Connect the USB charging cable to the DC 5V socket and connect the USB plug to the power supply unit.
The battery is fully charged when the display shows the battery in green.

EXCAVATOR BATTERY INSTALLATION

Open the battery compartment door.
Check whether the switch is pressed in. If it is not, press it once.
Place the battery in the battery compartment as shown in the figure and connect the plug. Make sure that the connection is tightly connected.

BATTERY REMAINING

After you have connected the battery, switch on the battery monitor. The battery capacity is now checked. If the capacity is less than 25%, the battery must be charged.

Display Switch| Battery remaining 25%| Battery remaining 50%| Battery remaining 75%| Battery remaining 100%

BATTERY CHARGING

Connect the charging socket of the battery to the plug of the charger.
Connect the charger to a power outlet.

INDICATOR STATUS WHEN CHARGING

Uncharged state green light| Charging red light| Fully charges state green light
---|---|---

The charging time is approx. 5 hours. When charging is complete, be sure to disconnect the charger from the battery.
Regularly check the charger to ensure the housing, cables and plugs. If there is a defect, do not use the charger under any circumstances.

TURNING ON REMOTE CONTROL AND MODEL

Make sure that the battery is charged.
Make sure that all buttons are in the home position.
Press the two power buttons simultaneously and hold them down until the transmitter is switched on.

Make sure that all switches are in the home position before switching on the remote control. Otherwise, a message will appear on the display. In this case, set the corresponding switches to the correct position.

Press the two power buttons of the remote control at the same time for a few seconds.

Open the battery compartment door.
Place the battery in the battery compartment and connect the plug to the socket.
Press the switch and you will hear a beep-sound.
Now you can operate the excavator.

TURNING OFF REMOTE CONTROL AND MODEL
After use, please proceed in reverse order.
First switch off the model and then the remote control.
Before closing the battery compartment, make sure that the battery is disconnected from the electronics.