SERVIT 423EST2WOPB Electric Open Well Steam Tables User Manual

SERVIT 423EST2WOPB Electric Open Well Steam Tables

INTRODUCTION

The steam table is designed to be operated dry. If wet operation is required, a spillage pan must be used. Spillage pans are available from the distributor you purchased your ServIt steam table from in stainless steel (Item # 92299765) and aluminum (Item # 92299785). Please read this manual thoroughly prior to equipment set-up, operation, and maintenance. Failure to comply with regular maintenance guidelines outlined in this manual may void the warranty.

WARNINGS

• Do not touch the interior or exterior of the heating wells during operation.
• Use protective gloves when adding a pan to a heated well to prevent burns from steam or touching the hot surface.
• Do not immerse the unit, cord, or plug in liquid at any time
• Unplug cord from outlet when not in use and before cleaning
• Do not use this unit for anything other than intended use
• Do not use outdoors
• Operate the unit with legs provided to prevent overheating of surfaces below
• Do not use if unit has a damaged cord or plug, in the event the appliance malfunctions, or has been damaged in any manner
• Do not plug or unplug unit with wet hands
• Keep children and animals away from unit
• Any incorrect installation, alterations, adjustments, and/or improper maintenance can lead to property loss and injury. All repairs should be done by authorized professionals only
• Ensure that the designated power supply is adequate for continual usage and the voltage is correct

FUNCTION AND PURPOSE
This unit is intended to hold food pans of hot, already cooked food at proper serving temperature. This unit is not designed or intended to cook raw food or reheat prepared food. Returns will not be accepted due to misunderstanding of the purpose of these Electric Steam Tables.

OPERATION

The steam table is designed to be operated dry. If wet operation is required, a spillage pan must be used. The unit is intended for holding hot food for short periods of time. A cover is needed on food to maintain temperature while not serving. The steam table has independent temperature controls in each well.

1. Plug unit into appropriate electrical power supply receptacle. Always check first with a qualified electrician if you are unsure of your facility’s power supply.
2. With the openings covered, set the dials to high for 30-45 minutes to preheat unit.
3. During initial start-up, a small amount of smoke or odor will appear. This is the coating being burnt off the elements and will only last for the initial 15-30 minutes of use.
4. Place precooked food (minimum 160°) in food pans, place in the wells and cover with lids.
5. Adjust to desired setting for proper food temperature in each well. This will vary with the type of food, size of pans and individual serving temperatures.
6. Food pans should be covered to maintain temperature when food is not being served and to prevent food from drying out.

Note: DO NOT put hot water in heating well or on element. Use a spillage pan if wet operation is desired.

CLEANING

NOTE: Your steam table should be cleaned daily to extend the life of the unit and keep sanitary serving conditions. Do not immerse the unit in water or any other liquid. If liquid enters the electrical compartment, it may cause it to short circuit or produce an electrical shock.

1. Allow unit to completely cool before cleaning.
2. Disconnect the cord from the outlet.
3. To avoid damage, do not use abrasive cleaners or scouring pads.
4. Avoid using cleaners as the chemical residue could damage or corrode the surfaces of the unit.

• Wipe the inside and outside surfaces of the unit using a warm damp cloth and an all-purpose cleaner such as Noble Strike, 147STRIKEQT. Since these units can come in contact with spilled foods, a sanitizer should also be used.
• Noble’s 147QUIKSAN comes in a convenient spray bottle and is safe to use on these steam tables. Always wipe the unit dry once done cleaning.

Read User Manual Online (PDF format)

Read User Manual Online (PDF format)  >>

Download This Manual (PDF format)

Download this manual  >>